不同掺杂剂对磷矿碳热还原反应的影响

doi:10.16085/j.issn.1000-6613.2020-0350

化工进展 ›› 2020, Vol. 39 ›› Issue (12): 5112-5118.DOI: 10.16085/j.issn.1000-6613.2020-0350

不同掺杂剂对磷矿碳热还原反应的影响

郑光亚¹^,²^,³(), 曹任飞¹^,²^,³, 夏举佩¹^,²^,³(), 梅毅¹^,²^,³, 陈正杰⁴

^1.昆明理工大学化学工程学院，云南昆明 650500
^2.云南省磷化工节能与新材料重点实验室，云南昆明 650093
^3.云南省高校磷化工重点实验室，云南昆明 650500
^4.昆明理工大学化学冶金与能源工程学院，云南昆明 650093

出版日期:2020-12-05 发布日期:2020-12-02
通讯作者: 夏举佩
作者简介:郑光亚（1994—），男，硕士研究生，研究方向为固体废弃物共伴生资源利用。E-mail：810193075@qq.com。
基金资助:
国家自然科学基金(21566018)

Effect of different dopants on the carbothermal reduction of phosphate rock

Guangya ZHENG¹^,²^,³(), Renfei CAO¹^,²^,³, Jupei XIA¹^,²^,³(), Yi MEI¹^,²^,³, Zhengjie CHEN⁴

^1.Faculty of Chemical Engineering, Kunming University of Science and Technology, Kunming 650500, Yunnan, China
^2.Yunnan Provincial Key Laboratory of Energy Saving in Phosphorus Chemical Engineering and New Phosphorus Materials, Kunming 650500, Yunnan, China
^3.The Higher Educational Key Laboratory for Phosphorous Chemical Engineering of Yunnan Province, Kunming 650500, Yunnan, China
^4.Faculty of Metallurgical and Energy Engineering, Kunming University of Science and Technology, Kunming 650093, Yunnan, China

Online:2020-12-05 Published:2020-12-02
Contact: Jupei XIA

摘要/Abstract

摘要：

对比分析了分别以K₂CO₃、Na₂CO₃、NiSO₄、K₂CO₃-NiSO₄为掺杂剂的不同磷矿碳热还原反应体系，结果表明，1200℃时，掺杂碱金属的体系由于其更易产生液相，利于扩散，因此，其反应进度比其他体系略好；对比掺杂物体系和无掺杂体系的各温度XRD图谱可知，掺杂物只是强化了反应的进度，并未有新的物质产生。添加掺杂物后残渣的流动温度也有明显差异，1250℃时，掺杂碱金属的残渣其流动温度较低，而随着温度的升高，残渣的流动温度均下降；但1350℃时，混合掺杂体系和掺杂硫酸镍体系的流动温度却低于碱金属体系；从1300℃下残渣的SEM图谱分析可知，具有掺杂物体系的残渣外观形态与无掺杂体系基本一致，说明添加掺杂物并没改变残渣的外观形态，均是固体残渣，符合窑法磷酸固态排渣的要求。

关键词: 窑法磷酸, 掺杂剂, 磷矿, 碳热还原

Abstract:

The carbon thermal reduction of phosphate rock with different dopants of K₂CO₃, Na₂CO₃, NiSO₄ and K₂CO₃-NiSO₄ were compared and analyzed. The results showed that the reaction progress of the systems with alkali metals doped was slightly better than that of other systems at 1200℃ because it was easier to produce liquid phase that was conducive to the diffusion. Comparing the XRD patterns at different temperatures of the doped system with those of the undoped system, we found that the dopant only strengthened the reaction progress, and no new substance was produced. There was also a significant difference in the flow temperature of the residue after doping. At 1250℃, the flow temperature of the residue with alkali metal dopants was relatively low, which decreased with the increase of the temperature. However, the flow temperature of the mixed doping system and the doped system with nickel sulfate was lower than that of the alkali metal system at 1350℃. From the SEM analysis of the residue at 1300℃, it can be seen that the appearance of the residue from the doped system was basically the same as that from the unadulterated system, indicating that the doping did not change the appearance of the residue, which was solid and met the solid slag discharge requirements of kiln phosphoric acid.

Key words: kiln process phosphoric acid, dopant, phosphate rock, carbothermal reduction

中图分类号:

TQ126.3

郑光亚, 曹任飞, 夏举佩, 梅毅, 陈正杰. 不同掺杂剂对磷矿碳热还原反应的影响[J]. 化工进展, 2020, 39(12): 5112-5118.

Guangya ZHENG, Renfei CAO, Jupei XIA, Yi MEI, Zhengjie CHEN. Effect of different dopants on the carbothermal reduction of phosphate rock[J]. Chemical Industry and Engineering Progress, 2020, 39(12): 5112-5118.

参考文献

1	覃扬颂, 王重华, 黄小凤, 等. 熔融态黄磷炉渣的综合利用现状[J]. 化工进展, 2012, 31(10): 2319-2323.
1	QIN Y S, WANG C H, HUANG X F, et al. Utilization of melting yellow phosphor furnace slag[J]. Chemical Industry and Engineering Progress, 2012, 31(10): 2319-2323.
2	刘丽芬, 李耀基, 柏中能, 等. 云南磷矿选矿产业化开发利用及发展历程[J]. 云南化工, 2019, 46(11): 36-39, 68.
2	LIU L F, LI Y J, BAI Z N, et al. Development and utilization of phosphatem ineral processing industry in Yunnan province[J]. Yunnan Chemical Technology, 2019, 46(11): 36-39, 68.
3	WANG X J, TANG L, JIANG Z. Numerical simulation of Venturi ejector reactor in yellow phosphorus purification system[J]. Nuclear Engineer & Design, 2014, 268(3): 18-23.
4	MA L, NING P, ZHANG Y, et al. Experimental and modeling of fixed-bed reactor for yellow phosphorous tail gas purification over impregnated activated carbon[J]. Chemical Engineering Journal, 2008, 137(3): 471-479.
5	魏琴. 黄磷生产中磷过滤新工艺的开发及应用效果[J]. 硫磷设计与粉体工程, 2012 (2): 6-9.
5	WEI Q. Development and application of new process for yellow phosphorus filtration during yellow phosphorus production[J]. Sulphur Phosphorus & Bulk Materials Handling Related Engineering, 2012(2): 6-9.
6	陈善继. 我国电炉制磷副产物综合利用概要[J]. 硫磷设计与粉体工程, 2011(5): 1009-1904.
6	CHEN S J. Summary of comprehensive utilization of by-products from phosphorus by electric furnace in China[J]. Sulphur Phosphorus & Bulk Materials Handling Related Engineering, 2011(5): 1009-1904.
7	KIJKOWSKA R, PAWLOWSKA-KOZINSKA D, KOWALSKI Z, et al. Wet-process phosphoric acid obtained from Kola apatite. Purification from sulphates, fluorine, and metals[J]. Separation & Purification Technology, 2002, 28(3): 197-205.
8	ABU-EISHAH S I, ABU-JABAL N M. Parametric study on the production of phosphoric acid by the dehydrate process[J]. Chemical Engineering Journal, 2001, 81(1): 231-250.
9	刘明理. 立窑法利用中低品位磷矿石生产工业磷酸的研究[J]. 化学研究与应用, 2009, 21(1): 131-134.
9	LIU M L. Study of producing industrial phosphoric acid with middle-low grade phosphate rock by vertical Kiln method[J]. Chemical Research and Application, 2009, 21(1): 131-134.
10	邓淑元, 梁斌, 李春, 等. 窑法磷酸技术研究进展[J]. 化工进展, 2012, 31(7): 402-406.
10	DENG S Y, LIANG B, LI C, et al. Research progress of Kiln phosphoric acid process[J]. Chemical Industry and Engineering Progress, 2012, 31(7): 402-406.
11	吕莉, 梁斌, 刘强, 等. 窑法磷酸中磷酸钙对P₂O₅反吸过程[J]. 化工学报, 2016, 67(10): 4399-4405.
11	LYU L, LIANG B, LIU Q, et al. Reactions between P₂O₅ and calcium phosphate in Kiln phosphoric acid[J]. CIESC Journal, 2016, 67(10): 4399-4405.
12	孙国超, 李燕凤, 袁圣娟. 窑法磷酸工业生产评述[J]. 化肥工业, 2019, 46(3): 10-15, 51.
12	SUN G C, LI Y F, YUAN S J. Review of industrial production of Kiln process phosphoric acid[J]. Chemical Fertilizer Industry, 2019, 46(3): 10-15, 51.
13	马超, 吴元欣, 金放, 等. 磷酸的工业生产研究现状与展望[J]. 化学工程, 2013, 41(6): 74-78.
13	MA C，WU Y X, JIN F, et al. Current status and prospect of industrial phosphoric acid production[J]. Chemical Engineering, 2013, 41(6): 74-78.
14	吴潘, 吕莉, 李剑锋. 中低品位磷矿窑法磷酸工艺条件的研究[J]. 辽宁化工, 2017, 46(12): 1176-1178.
14	WU P, LYU L, LI J F. Research on production process conditions of mid-low-grade phosphate ore with Kiln-phosphoric acid process[J]. Liaoning Chemical Industry, 2017, 46(12): 1176-1178.
15	任占东, 陈樑, 宁平. 催化氧化法脱除黄磷尾气中的磷化氢和硫化氢[J]. 化工环保, 2005, 25(3): 221-224.
15	REN Z D, CHEN L, NING P. Progress in purification of PH₃, H₂S in yellow phosphorus tail gas with activated carbon[J]. Environmental Protection of Chemical Industry, 2005, 25(3): 221-224.
16	张永, 宁平, 徐浩东, 等. 改性活性炭吸附净化黄磷尾气中的PH₃[J]. 中国环境学报, 2007, 1(5): 74-78.
16	ZHANG Y, NING P, XU H D, et al. Adsorptive removal of PH₃ in off-gas of yellow phosphorus by modified activated carbon[J]. Chinese Journal of Environmental Engineering, 2007, 1(5): 74-78.
17	MEGY J A. Rotary Kiln process for phosphoric acid manufacture: US 2005019598[P]. 2005-06-03.
18	JACOB K D, REYNOLDS D S. Reduction of tricalcium phosphate by carbon[J]. Industrial & Engineering Chemistry, 2002, 20(1): 1204-1210.
19	JACOB M U, FREDERIC L, PARK W C, et al. Reduction of phosphate ores by carbon: PartⅠ. Process variables for design of rotary Kiln system [J]. Metallurgical Transactions B, 1986, 17(4): 861-868.
20	FREDERIC L, HOWARD R, JACOB M U, et al. Reduction of phosphate ore by carbon: Part Ⅱ. rate limiting steps[J]. Metallurgical Transactions B, 1986, 17(4): 869-877.
21	江善喜. 提高窑法磷酸还原率的探讨[J]. 磷肥与复肥, 1995, 10(1): 13-17, 56.
21	JIANG S X. Discussion on improving reduction rate of Kiln phosphoric acid[J]. Phosphate & Compound Fertilizer, 1995, 10(1): 13-17, 56.
22	GENG R X, XIA J P, CHEN Z J, et al. Effects of potassium feldspar on slagging and fluxing in phosphorus produced via electric furnace[J]. Phosphorus Sulfur & Silicon & the Related Elements, 2016, 192(4): 475-480.
23	朱晁莹, 屈敏, 李银, 等. 助熔剂硅石及钾页岩对磷矿碳热还原反应的影响[J]. 硅酸盐通报, 2018, 37(9): 2908-2912, 2918.
23	ZHU C Y, QU M, LI Y, et al. Effect of silica and potassium shale as the flux agents on the phosphorus carburizing reduction reaction[J]. Bulletin of the Chinese Ceramic Society, 2018, 37(9): 2908-2912, 2918.
24	曹任飞, 夏举佩, 李宛霖, 等. 碱金属碳酸盐对磷矿碳热还原反应的影响研究[J]. 高校化学工程学报, 2018, 32(3): 568-576.
24	CAO R F, XIA J P, LI W L, et al. Effects of alkali metal carbonates on carbothermal reduction of phosphate rock[J]. Journal of Chemical Engineering of Chinese Universities, 2018, 32(3): 568-576.
25	BAI S, WEN S, LIU D, et al. Effects of sodium carbonate on the carbothermic reduction of siderite ore with high phosphorus content[J]. Minerals & Metallurgical Processing, 2013, 30(2): 100-107.
26	MA Y, LIU B, JING M M, et al. Promoted potassium salts based Ru/AC catalysts for water gas shift reaction[J]. Chemical Engineering Journal, 2016, 287: 155-161.
27	赵禺，夏举佩，曹任飞，等. 钾系添加剂促进磷矿碳热还原的可行性研究[J]. 硅酸盐通报, 2018, 37(12): 3983-3988.
27	ZHAO Y, XIA J P, CAO R F, et al. Feasibility study on potassium additive promoting carbothermal reduction of phosphate rocks[J]. Bulletin of the Chinese Ceramic Society, 2018, 37(12): 3983-3988.
28	CAO R F, LI Y, XIA J P, et al. NiSO₄ as additive effect on the carbothermal reduction process of phosphate rock and SiO₂[J]. Silicon, 2019, 11(6): 1-8.
29	ZHENG G Y, CAO R F, LI Y, et al. The additive effect of K₂CO₃-NiSO₄ on the carbothermal reduction process of phosphate rock and SiO₂[J]. Silicon, 2020, 12(8): 1985-1994.
30	KOPYSCINSKI J, HABIBI R, MIMS C A, et al. K₂CO₃-catalyzed CO₂ gasification of ash-free coal: kinetic study[J]. Energy Fuels, 2013, 27(8): 4875-4883.
31	马超. 混合碳基熔融还原磷矿的研究[D]. 武汉: 武汉工程大学, 2015.
31	MA C. Study on mixed carbon-based smelt reduction phosphate[D]. Wuhan: Wuhan Engineering University, 2015.
32	孙志力, 杜建学. 电炉法制磷[M]. 北京: 冶金工业出版社, 2010: 356-380.
32	SUN Z L, DU J X. Electric furnace method for making phosphorus[M]. Beijing: Metallurgical Industry Press, 2010: 356-380.
33	曹任飞, 李银, 夏举佩, 等. 氟磷灰石碳热还原过程及动力学研究[J]. 高校化学工程学报, 2019, 33(2): 372-379.
33	CAO R F, LI Y, XIA J P, et al. Study on carbothermal reduction process and kinetics of fluoroapatite[J]. Journal of Chemical Engineering of Chinese Universities, 2019, 33(2): 372-379.
34	刘予成, 李秋霞, 刘永成. 氟磷酸钙真空碳热还原反应机理[J]. 真空, 2012, 49(3): 84-87.
34	LIU Y C, LI Q X, LIU Y C. Carbothermal reduction mechanism of fluorapatite in vacuum[J]. Vacuum, 2012, 49(3): 84-87.

[1]	陈永珍, 黎华玲, 宋文吉, 冯自平. 废旧磷酸铁锂材料碳热还原固相再生方法[J]. 化工进展, 2018, 37(S1): 133-140.
[2]	武春锦, 吕武华, 梅毅, 俞宝根. 湿法烟气脱硫技术及运行经济性分析[J]. 化工进展, 2015, 34(12): 4368-4374.
[3]	邓淑元1，梁斌1，李春1，吕莉1，吴潘1，邱礼有1，王黎明2. 窑法磷酸技术研究进展[J]. 化工进展, 2012, 31(07): 1402-1406.
[4]	周兆懿1，赵亚萍1，蔡再生1，朱美芳2. 纤维表面不同无机酸掺杂聚苯胺的制备及表征 [J]. 化工进展, 2010, 29(5): 909-.

不同掺杂剂对磷矿碳热还原反应的影响

Effect of different dopants on the carbothermal reduction of phosphate rock

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 4

编辑推荐

Metrics

本文评价