纳米晶硅多层薄膜的低温调控及其发光特性

doi:10.16085/j.issn.1000-6613.2017-1247

化工进展 ›› 2018, Vol. 37 ›› Issue (04): 1516-1521.DOI: 10.16085/j.issn.1000-6613.2017-1247

纳米晶硅多层薄膜的低温调控及其发光特性

李云¹, 高东泽¹, 焦玉骁¹, 张博惠¹, 许贺菊^1,2, 赵蔚^1,3, 于威¹, 路万兵¹, 李晓苇¹

1 河北大学物理科学与技术学院, 河北保定 071000;
2 华北理工大学理学院, 河北唐山 063009;
3 河北工程大学数理学院, 河北邯郸 056038

收稿日期:2017-06-21 修回日期:2017-11-18 出版日期:2018-04-05 发布日期:2018-04-05
通讯作者: 于威,教授,研究方向为太阳能电池材料与器件;路万兵,教授,研究方向为光电功能材料与器件。
作者简介:李云(1986-),女,博士研究生。
基金资助:
国家自然科学基金青年基金（61504036），河北省自然科学基金青年基金（A2016201087），河北省科技计划（13214315），国家自然科学基金（11504078）及河北省高等学校科学技术研究项目（Z2015121）。

Low temperature preparation and luminescence properties of nanocrystalline silicon multilayer films

LI Yun¹, GAO Dongze¹, JIAO Yuxiao¹, ZHANG Bohui¹, XU Heju^1,2, ZHAO Wei^1,3, YU Wei¹, LU Wanbing¹, LI Xiaowei¹

1 College of Physics Science and Technology, Hebei University, Baoding 071000, Hebei, China;
2 College of Science, North China University of Science and Technology, Tangshan 063009, Hebei, China;
3 School of Science, Hebei University of Engineering, Handan 056038, Hebei, China

Received:2017-06-21 Revised:2017-11-18 Online:2018-04-05 Published:2018-04-05

摘要/Abstract

摘要： 采用单-双靶交替溅射法低温沉积了纳米晶硅多层薄膜（nc-SiO_x/a-SiO_x），通过改变a-SiO_x势垒层的厚度和化学成分比例，实现了纳米晶硅多层薄膜的低温过程控制。透射电子显微镜（TEM）结果显示，a-SiO_x层太薄，不能有效阻断纳米硅生长，导致多层周期结构在后期沉积过程中受到破坏；增加a-SiO_x层厚度，周期性结构生长得以实现，但仍有部分纳米硅穿透a-SiO_x势垒层；傅里叶变换红外光谱（FTIR）分析表明，薄膜中的氧化反应以及活性氢对物相分离过程的促进作用均对纳米硅生长有影响。进而增加a-SiO_x层氧含量，纳米硅的纵向生长被成功阻断。在此基础上，通过调整nc-SiO_x层厚度实现了薄膜光学带隙调整和纳米硅粒度控制。光吸收谱分析显示，随nc-SiO_x层厚度的增加，薄膜光学带隙逐渐减小；光致发光谱表明，多层周期结构实现了纳米硅尺寸的调控，粒子尺寸为几个纳米的纳米硅表现出了较强的发光，发光机制为量子限制效应-缺陷态复合发光。

关键词: 纳米晶硅, 多层薄膜, 显微结构, 低温过程控制, 纳米粒子, 光致发光

Abstract: The nanocrystalline silicon multilayers(nc-SiO_x/a-SiO_x) were deposited at low temperature by single-double target alternating sputtering technology. The thickness and the chemical composition of the a-SiO_x barrier layers were regulated to control the multilayers' microstructure. Transmission electron microscopy(TEM) analysis showed that the periodic structure was disrupted during the later deposition process because the a-SiO_x layer was too thin to effectively block the growth of nc-Si. The multilayer structure was successfully prepared by increasing the thickness of the a-SiO_x layer,however,there were still a part of nc-Si particles penetrating the barrier layer. Fourier transform infrared(FTIR) spectra showed that the oxidation reaction in the film and the active hydrogen atom effected on the growth of nc-Si. Therefore,the oxygen content of the a-SiO_x layer was increased which further blocked the growth of the nc-Si. Then,the film optical bandgap was adjusted and nc-Si particles size was controlled by regulating the thickness of nc-SiO_x layer. The absorption spectra showed that the optical bandgap of the film decreased with the increase of the nc-SiO_x layer thickness. The photoluminescence(PL) spectra showed that the multilayer structure was regulated by controlling nc-SiO_x layer thickness,and the resultant nc-Si with several nanometer produced a strong luminescence,which was attributed to a complex quantum confinement effect and the defect state luminescence mechanism.

Key words: nanocrystalline silicon, multilayers, microstructure, low temperature process control, nanoparticles, photoluminescence

中图分类号:

O472⁺.8

李云, 高东泽, 焦玉骁, 张博惠, 许贺菊, 赵蔚, 于威, 路万兵, 李晓苇. 纳米晶硅多层薄膜的低温调控及其发光特性[J]. 化工进展, 2018, 37(04): 1516-1521.

LI Yun, GAO Dongze, JIAO Yuxiao, ZHANG Bohui, XU Heju, ZHAO Wei, YU Wei, LU Wanbing, LI Xiaowei. Low temperature preparation and luminescence properties of nanocrystalline silicon multilayer films[J]. Chemical Industry and Engineering Progress, 2018, 37(04): 1516-1521.

参考文献

[1] KIM S K,CHO C H,KIM B H,et al. Electrical and optical characteristics of silicon nanocrystal solar cells[J]. Applied Physics Letters,2009,95(14):143120(1-3).
[2] CHO E C,PARK S,GREEN M A,et al. Silicon quantum dot/crystalline silicon solar cells[J]. Nanotechnology,2008,19(5):245201(1-5).
[3] ZACHARIAS M,HEITMANN J,SCHOLZ R,et al. Size-controlled highly luminescent silicon nanocrystals:a SiO/SiO₂ superlattice approach[J]. Applied Physics Letters,2002,80(4):661-663.
[4] HAO X J,PODHORODECKI A P,SHEN Y S,et al. Effects of Si-rich oxide layer stoichiometry on the structural and optical properties of Si-QD/SiO₂ multilayer films[J]. Nanotechnology,2009,20(48):485703(1-10).
[5] HAO X J,CHO E C,FLYNN C,et al. Synthesis and characterization of boron-doped Si quantum dots for all-Si quantum dot tandem solar cells[J]. Solar Energy Materials & Solar Cells,2009,93(12):273-279.
[6] WATANABE K,TSUCHIYA R,MINE T,et al. Enhanced carrier transport by defect passivation in Si/SiO₂ nanostructure-based solar cells[J]. Applied Physics Letters,2012,101(10):153902(1-3).
[7] HONG S,BAEK I B,KWAK G Y,et al. Improved electrical properties of silicon quantum dot layers for photovoltaic applications[J]. Solar Energy Materials & Solar Cells,2016,150(1):71-75.
[8] LI Y,YIN C C,JI Y,et al. Low-temperature deposition of nc-SiO_x:H below 400℃ using magnetron sputtering[J]. Chinese Physics Letters,2015,32(4):046802-046805.
[9] GASKELL P H,WALLIS D J. Medium-range order in silica,the canonical network glass[J]. Physical Review Letters,1996,76(1):66-69.
[10] VIERA G,HUET S,BOUFENDI L. Crystal size and temperature measurements in nanostructured silicon using Raman spectroscopy[J]. Journal of Applied Physics,2001,90(7):4175-4183.
[11] PETRICH M A,GLEASON K K,REIMER J A. Structure and properties of amorphous hydrogenated silicon carbide[J]. Physical Review B,1987,36(18):9722-9731.
[12] TONG L,JERZY K,WEI K,et al. Interference fringe-free transmission spectroscopy of amorphous thin films[J]. Journal of Applied Physics,2000,88(10):5764-5771.
[13] QIN G G,JIA Y Q. Mechanism of rhe visible luminescence in porous silicon[J]. Solid State Commun.,1993,86(9):559-563.
[14] YANG Y,TAY B K,SUN X W. Photoluminescence and growth mechanism of amorphous silica nanowires by vapor phase transport[J]. Physica E,2006,31(2):218-223.
[15] SUZUKI T,SAKAI T,ZHANG L,et al. Evidence for cathode luminescence from SiO₂ in porous Si[J]. Applied Physics Letters,1995,66(2):215-217.
[16] MUNEKUNI S,YAMANKA T,SHIMOGAICHI Y,et al. Various types of nonbridging oxygen hole center in high-purity silica glass[J]. Journal of Applied Physics,1990,68(3):1212-1217.
[17] MOTAPINEDA E,MELENDEZLIRA M,ZAPATATORRES M,et al. Photoluminescence of as-grown and thermal annealed SiO_x/Si-nanocrystals heterolayers grown by reactive rf sputtering[J]. Journal of Applied Physics,2010,108(9):094323(1-6).

纳米晶硅多层薄膜的低温调控及其发光特性

Low temperature preparation and luminescence properties of nanocrystalline silicon multilayer films

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	张祚群, 高扬, 白超杰, 薛立新. 二次界面聚合同步反扩散原位生长ZIF-8纳米粒子制备聚酰胺混合基质反渗透（RO）膜[J]. 化工进展, 2023, 42(S1): 364-373.
[2]	赵健, 卓泽文, 董航, 高文健. 含蜡原油及其乳状液体系微观结构观测的新方法[J]. 化工进展, 2023, 42(8): 4372-4384.
[3]	谢志伟, 吴张永, 朱启晨, 蒋佳骏, 梁天祥, 刘振阳. 植物油基Ni_0.5Zn_0.5Fe₂O₄磁流体的黏度特性及磁黏特性[J]. 化工进展, 2023, 42(7): 3623-3633.
[4]	董晓珊, 王建, 林法伟, 颜蓓蓓, 陈冠益. 基于钙钛矿氧化物的金属纳米粒子溶出策略：溶出过程、驱动力及控制策略[J]. 化工进展, 2023, 42(6): 3049-3065.
[5]	徐国彬, 刘洪豪, 李洁, 郭家奇, 王琪. ZnO量子点水性喷墨荧光墨水制备及性能[J]. 化工进展, 2023, 42(6): 3114-3122.
[6]	陈怡欣, 甄摇摇, 陈瑞浩, 吴继伟, 潘丽美, 姚翀, 罗杰, 卢春山, 丰枫, 王清涛, 张群峰, 李小年. 铂基纳米催化剂的制备及在加氢领域的进展[J]. 化工进展, 2023, 42(6): 2904-2915.
[7]	郭文杰, 翟玉玲, 陈文哲, 申鑫, 邢明. Al₂O₃-CuO/水混合纳米流体对流传热性能及热经济性分析[J]. 化工进展, 2023, 42(5): 2315-2324.
[8]	宋超, 叶学民, 李春曦. 纳米颗粒与表面活性剂的自组装行为对硅油-水界面性质影响的分子动力学[J]. 化工进展, 2022, 41(S1): 366-375.
[9]	蒋华义, 胡娟, 齐红媛, 游琰真, 王玉龙, 武哲. 磁性纳米粒子类型和质量浓度对微波热解含油污泥的影响[J]. 化工进展, 2022, 41(7): 3908-3914.
[10]	孙娜娜, 孙会娜, 沈莉莎, 苏瑞宇, 赵超. 磁性纳米颗粒-微波辐射对稠油O/W乳状液的协同破乳[J]. 化工进展, 2022, 41(6): 3127-3137.
[11]	李娟娟, 张天永, 李祥高. 电泳显示用高质量铁锰黑纳米分散系的构建[J]. 化工进展, 2022, 41(6): 3178-3185.
[12]	龚鑫, 刘小冬, 温福山, 师楠, 刘东. 中间相炭微球乳化-聚合法制备及电化学性能[J]. 化工进展, 2022, 41(5): 2379-2388.
[13]	刘竞, 郑新国, 李铁军, 王财平, 赵彦旭, 李颖, 楼梁伟, 沈伟. 可再分散乳化沥青粉末改性水泥砂浆的力学性能和微观形貌[J]. 化工进展, 2022, 41(4): 2015-2021.
[14]	刘鸿益, 杨光星, 余皓. 电磁感应加热用于可持续催化技术的研究进展[J]. 化工进展, 2022, 41(3): 1440-1452.
[15]	武世伟, 王廷, 侯焕娣, 申海平. 分散型浆态床渣油加氢双金属催化剂研究进展[J]. 化工进展, 2022, 41(10): 5406-5415.