R290及其混合制冷剂在水平管内相变换热的研究进展

doi:10.16085/j.issn.1000-6613.2016.11.004

摘要/Abstract

摘要： R290（丙烷）及其混合制冷剂具有优秀的环保性和热物性，是理想的替代制冷剂，但存在可燃的问题。通过对R290及其混合制冷剂在水平管内相变换热的研究，可以优化制冷系统的换热器，减少充灌量，降低R290及其混合制冷剂的可燃性。本文综述了国内外R290及其混合制冷剂在水平管内相变换热的研究，表明R290及其混合制冷剂拥有接近或超越传统合成制冷剂的相变换热性能。列出并对比了相关研究中得到的相变换热关联式，汇总了相关研究中质量流量、热流密度、干度等因素对相变换热的影响。指出当前研究大多在过去常用的传热管进行，为了降低R290及其混合制冷剂的可燃性，减少制冷系统的制冷剂充灌量，必须对R290及其混合制冷剂在小管径（7mm、6mm、5mm，甚至4mm）传热管内相变换热的关联式和影响因素进行深入研究。

关键词: 丙烷, 相变, 传热, 流动, 混合制冷剂, 水平管

Abstract: R290(propane)and its refrigerant mixtures have been treated as ideal alternative refrigerants due to their favourable environmental and thermo-physical properties. However, they are flammable. The heat exchangers of the refrigeration system can be optimized, and the charge amount of R290 and its refrigerant mixtures can be reduced by studying the phase change heat transfer of R290 and its refrigerant mixtures in horizontal tube. In this paper, studies on phase change heat transfer of R290 and its refrigerant mixtures in horizontal tube were review. The results showed that the heat transfer performance of R290 and its refrigerant mixtures can be comparable to or above synthetic refrigerants. The phase change heat transfer correlations of R290 and its refrigerant mixtures obtained in related research were listed and compared, and the influence of mass flow, heat flux, vapor quality and other factors on phase change heat transfer from relevant researches were summarized. Finally, it is pointed out that all above researches have been conducted mainly on the traditional heat transfer pipes, the phase change heat transfer correlations and factors of R290 and its refrigerant mixtures in small tube (with the diameters of 7mm、6mm、5mm or even 4mm) should be studied in order to reduce the charge amount and flammability.

Key words: propane, phase change, heat transfer, flow, refrigerant mixture, horizontal tube

中图分类号:

TB61⁺1

邹思凯, 戴源德, 何国庚. R290及其混合制冷剂在水平管内相变换热的研究进展[J]. 化工进展, 2016, 35(11): 3413-3420.

ZOU Sikai, DAI Yuande, HE Guogeng. Studies on phase change heat transfer of R290 and its refrigerant mixtures in horizontal tube[J]. Chemical Industry and Engineering Progress, 2016, 35(11): 3413-3420.

参考文献

[1] SPATZ M W,SAMUEL F,YANA M. An evaluation of options for replacing HCFC-22 in medium temperature refrigeration systems[J]. International Journal of Refrigeration,2004,27:475-483.
[2] 何国庚,刘璇斐. R290 在小型空调器中替代 R22 的优势与问题及其解决措施[J]. 制冷与空调,2008,8(2):58-62.
[3] WONGWISES S,CHIMRES N. Experimental study of hydrocarbon mixtures to replace HFC-134a in a domestic refrigerator[J]. Energy Conversion and Management,2005,46:85-100.
[4] TIAN Q Q,CAI D H,REN L,et al. An experimental investigation of refrigerant mixture R32/R290 as drop-in replacement for HFC410A in household air conditioners[J]. International Journal of Refrigeration,2015,57:216-0228.
[5] SHIN J Y,KIM M S,RO S T. Experimental study on forced convective boiling heat transfer of pure refrigerants and refrigerant mixtures in a horizontal tube[J]. International Journal of Refrigeration,1997,20(4):267-275.
[6] CHANG Y S,KIM M S,RO S T. Performance and heat transfer characteristics of hydrocarbon refrigerants in a heat pump system[J]. International Journal of Refrigeration,2000,23:232-242.
[7] LEE H S,YOON J I,KIM J D,et al. Evaporating heat transfer and pressure drop of hydrocarbon refrigerants in 9.52 and 12.70 mm smooth tube[J]. International Journal of Heat and Mass Transfer,2005,48:2351-2359.
[8] LEE H S,YOON J I,KIM J D,et al. Characteristics of condensing and evaporating heat transfer using hydrocarbon refrigerants[J]. Applied Thermal Engineering,2006,26:1054-1062.
[9] PARK K J,JUNG D,SEO T. Flow condensation heat transfer characteristics of hydrocarbon refrigerants and dimethyl ether inside a horizontal plain tube[J]. International Journal of Multiphase Flow,2008,34:628-635.
[10] RAJ M H,LAI D M. Performance evaluation of a fin-and-tube evaporator with R407C/R290/R600a refrigerant mixture[J]. International Journal of Ambient Energy,2010,31(1):33-46.
[11] 肖航,李俊明. R290和R22在水平细圆管内流动凝结换热的实验研究[J]. 制冷学报,2015,36(5):22-29.
[12] 韩晓霞. R290与R404A内螺纹管中沸腾换热研究[D]. 西安:西安建筑科技大学,2004.
[13] WEN M Y,HO C Y,HSIEH J M. Condensation heat transfer and pressure drop characteristicsof R-290 (propane),R-600 (butane),and a mixture of R-290/R-600 in the serpentine small-tube bank[J]. Applied Thermal Engineering,2006,26:2045-2053.
[14] WEN Y M,HO C Y. Evaporation heat transfer and pressure drop characteristics of R-290 (propane),R-600 (butane),and a mixture of R-290/R-600 in the three-lines serpentine small-tube bank[J]. Applied Thermal Engineering,2005,25(17/18):2921-2936.
[15] CHO M J,KIM Y J,KIM M S. Experimental studies on the characteristics of evaporative heat transfer and pressure drop of CO₂/propane mixtures in horizontal and vertical smooth and micro-fin tubes[J]. International Journal of Refrigeration,2010,33:170-179.
[16] 刘芳. 混合制冷剂 R32/R290水平管内沸腾换热的实验研究[D]. 武汉:华中科技大学,2015.
[17] 韩北鲲. 混合制冷剂 R32/R290 水平通道内凝结换热的实验研究[D]. 武汉:华中科技大学,2015.
[18] THOME J R,EL Hajal J,CAVALLINI A. Condensation in horizontal tubes. Part 2:New heat transfer model based on flow regimes[J]. International Journal of Heat Mass Transfer,2003,46:3365-3387.
[19] CAVALLINI A,COL D D,DORETTI L,et al. Condensation in horizontal smooth tubes: a new heat transfer model for heat exchanger design[J]. Heat Transfer Eng.,2006,27(8):31-38.
[20] CAVALLINI A,CENSI G,COL D D,et al. Condensation of halogenated refrigerants inside smooth tubes[J]. HVAC&R Research,2002,4(8):429-451.
[21] DITTUS F W,BOELTER L M K. Heat transfer in automobile radiators of the tubular type[M]. Berkeley:University of California Publications of Engineering,1930:443-461.
[22] STEPHAN K,ABDELSALAM M. Heat transfer correlations for natural convection boiling[J]. Heat Mass Transfer,1980,23:73-87.
[23] THOME J R,SHAKIR S. A new correlation for nucleate pool boiling of aqueous mixtures[J]. AIChE Symp,1984,83:46-51.
[24] GUNGOR K E,WINTERTON R H S. A general correlation for flow boiling in tubes and annuli[J]. Heat Mass Transfer.,1986,29:351-358.
[25] GUNGOR K E,WINTERTON R H S. Simplified general correlation for flow saturated boiling and comparisons of correlations with data[J]. Chem. Eng. Res. Des.,1987,65:148-196.
[26] CHOI K I,PAMITRAN A S,OH J T,et al. Pressure drop and heat transfer during two-phase flow vaporization of propane in horizontal smooth minichannels[J]. International Journal of Refrigeration,2009,32(5):837-845.
[27] CHEN J C. A correlation for boiling heat transfer to saturated fluids in convective flow[J]. Ind. Eng. Chem. Process Des.,1966,5: 322-329.
[28] JUNG D S,McLinden M,Radermacher R,et al. A study of flow boiling heat transfer with refrigerant mixtures[J]. Heat Mass Transfer,1989,32(9):1751-1764.
[29] COOPER M G. Heat flow rates in saturated nucleate pool boiling a wide ranging examination using reduced properties[J]. Advances in Heat Transfer,1984,16:157-239.
[30] MACDONALD M,GARIMELLA S. Hydrocarbon condensation in horizontal smooth tubes:Part II-Heat transfer coefficient and pressure drop modeling[J]. International Journal of Heat and Mass Transfer,2016,93:1248-1261.
[31] EDWARDS D K,DENNY V E,MILLS A F. Transfer processes: an introduction to diffusion,convection and radiation,2ed[C]. Washington:Hemisphere Publication Corp,1979:166-169.
[32] ZHU Y,WU X M,WEI Z F.Heat transfer characteristics and correlation for CO₂/propane mixtures flow evaporation in a smooth mini tube[J]. Applied Thermal Engineering,2015,81:253-261.
[33] KATTAN N,THOME J R,FAVRAT D. Flow boiling in horizontal tubes: Part 1—Development of a diabatic two-phase flow pattern map[J]. Journal of Heat Transfer,1998,120(1): 140-147.
[34] KATTAN N,THOME J R,FAVRAT D. Flow boiling in horizontal tubes: Part 3—Development of a new heat transfer model base on flow pattern[J]. Journal of Heat Transfer,1998,120(1):156-165.
[35] EL Hajal J,THOME J R,CAVALLINI A. Condensation in horizontal tubes. Part 1:Two-phase flow pattern map[J].International Journal of Heat Mass Transfer,2003,46:3349-3363.
[36] 杨鹏. R290含油混合物在水平微翅管内沸腾换热及流动特性的实验研究[D]. 重庆:重庆大学,2002.
[37] LIU F,HAN B K,CAI D,et al. Experimental study on boiling heat transfer of R32/R290 in horizontal tubes[C]// The 24th IIR International Congresses of Refrigeration,Yokohama,2015.
[38] 吴晓敏,赵然,魏兆福,等. CO₂/丙烷混合工质水平管内流动沸腾换热特性研究[J]. 工程热物理学报,2013,34(4):706-709.
[39] WANG S,GONG M Q,CHEN G F,et al. Two-phase heat transfer and pressure drop of propane during saturated flow boiling inside a horizontal tube[J]. International Journal of Refrigeration,2014,41:200-209.
[40] 陈伟清,巨永林,EIKEVIK M T. R290在水平光滑管内沸腾换热和压降特性的性能模拟[J]. 制冷技术,2015,43(6):55-60.
[41] COL D D,BORTOLIN S,BORTOLATO M,et al. Condensation heat transfer and pressure drop with propane in a minichannel[C]// International Refrigeration and Air Conditioning Conference,2012:1347.
[42] 宁静红,刘圣春,李慧宇. 自然工质R290管内凝结换热特性的数值模拟[J]. 化工学报,2012,63(4):1038-1043.
[43] HAN B K,LIU F,CAI D,et al. Experimental study on condensation heat transfer of R32/R290 in horizontal tubes[C]//The 24th IIR International Congresses of Refrigeration,Yokohama,2015.
[44] MACDONALD M,GARIMELLA S. Hydrocarbon condensation in horizontal smooth tubes:PartⅠ—Measurements[J]. International Journal of Heat and Mass Transfer,2016,93:75-85.
[45] FERNANDO P,PALM B,AMEEL T,et al. A minichannel aluminium tube heat exchanger. Part Ⅲ:Condenser performance with propane[J]. International Journal of Refrigeration,2008,31:696-708.
[46] LIU N,XIAO X,LI J M. Experimental investigation of condensation heat transfer and pressure drop of propane,R1234ze(E) and R22 in minichannels[J]. Applied Thermal Engineering,2016,102:63-72.