限氧条件下亚硝化的稳定运行及动力学

doi:10.16085/j.issn.1000-6613.2015.12.011

化工进展 ›› 2015, Vol. 34 ›› Issue (12): 4198-4202.DOI: 10.16085/j.issn.1000-6613.2015.12.011

限氧条件下亚硝化的稳定运行及动力学

胡晓娜, 戴晓虎, 曹达文, 陈文静, 杨殿海

同济大学环境科学与工程学院, 上海 200092

收稿日期:2015-06-03 修回日期:2015-07-14 出版日期:2015-12-05 发布日期:2015-12-05
通讯作者: 曹达文,高级工程师,研究方向为水污染控制技术。E-mailcaodawen@163.com。
作者简介:胡晓娜(1991—),女,硕士研究生,研究方向为水污染控制技术。E-mailhuxiaona92@126.com。
基金资助:
国家水体污染控制与治理科技重大专项项目(2013ZX07315- 001)。

Stable operation and kinetics of partial nitrification under limited oxygen concentration

HU Xiaona, DAI Xiaohu, CAO Dawen, CHEN Wenjing, YANG Dianhai

College of Environmental Science and Engineering, Tongji University, Shanghai 200092, China

Received:2015-06-03 Revised:2015-07-14 Online:2015-12-05 Published:2015-12-05

摘要/Abstract

摘要： 采用高氨氮人工配水和序批式反应器,在限氧(0.2～0.3mg/L)条件下,研究了进水氨氮负荷、游离氨和游离亚硝酸对氨氮转化率、亚硝化率和亚硝氮生成速率的影响及游离氨对氨氧化菌的基质抑制动力学。结果表明,在进水氨氮负荷逐步提升过程中,由于高浓度游离氨的抑制作用及负荷冲击的影响,亚硝化效果易出现波动,且负荷越高,亚硝化性能恢复的时间越长。反应系统最终可达到的氨氮容积负荷为3.60kg/(m³·d),亚硝氮生成速率为2.98kg/(m³·d),亚硝化率始终维持在85%左右。反应体系中较高的游离氨浓度(24.4～85.8mg/L)和低浓度溶解氧是维持亚硝化工艺稳定运行的主要因素。游离氨对氨氧化菌的抑制动力学符合Haldane模型,拟合得到最大氨氧化速率为6.71gN/(gVSS·d),游离氨半饱和常数和抑制常数分别为3.2mg/L和27.8mg/L。

关键词: 序批式反应器, 亚硝化, 高氨氮废水, 限氧, 基质抑制模型

Abstract: The effects of ammonium nitrogen loading rate,free ammonia and free nitrous acid on ammonium nitrogen removal efficiency,nitrite accumulation ratio and nitrite nitrogen accumulation rate were studied with a sequencing batch reactor under limited oxygen concentration(0.2—0.3mg/L). The substrate inhibition kinetics of ammonium oxidizing bacteria was also analyzed. The fluctuations of performance of reactor were observed due to the influence of shock loading and inhibition of high free ammonia when ammonium nitrogen loading was gradually improved. The recovery process was slower with higher load. Ammonium nitrogen loading rate of 3.60kg/(m³·d) and nitrite nitrogen accumulation rate of 2.98kg/(m³·d) were attained with nitrite accumulation ratio maintained at around 85%. High free ammonia(24.4—85.8mg/L)and limited dissolved oxygen are the main factors to achieve stable partial nitrification. The Haldane model was used to describe the substrate inhibition of partial nitrification and the results show that the maximum specific ammonium nitrogen oxidizing rate is 6.71gN/(gVSS·d). Affinity constant and inhibition constant for free ammonia are 3.2mg/L and 27.8mg/L,respectively.

Key words: sequencing batch reactor(SBR), partial nitrification, ammonium-rich wastewater, limited oxygen concentration, substrate inhibition kinetic model

中图分类号:

X703.1

胡晓娜, 戴晓虎, 曹达文, 陈文静, 杨殿海. 限氧条件下亚硝化的稳定运行及动力学[J]. 化工进展, 2015, 34(12): 4198-4202.

HU Xiaona, DAI Xiaohu, CAO Dawen, CHEN Wenjing, YANG Dianhai. Stable operation and kinetics of partial nitrification under limited oxygen concentration[J]. Chemical Industry and Engineering Progree, 2015, 34(12): 4198-4202.

参考文献

[1] 张珏,陈辉,姬玉欣,等. 厌氧氨氧化脱氮工艺研究进展[J]. 化工进展,2014,33(6):1589-1595.
[2] Anthonisen A C,Loehr R C,Prakasam T B S,et al. Inhibition of nitrification by ammonia and nitrous-acid[J]. Journal Water Pollution Control Federation,1976,48(5):835-852.
[3] van Dongen U,Jetten M S M,van Loosdrecht M C M. The SHARON-ANAMMOX process for treatment of ammonium rich wastewater[J]. Water Science and Technology,2001,44(1):153-160.
[4] Hellinga C,Schellen A A J C,Mulder J W,et al. The Sharon process:An innovative method for nitrogen removal from ammonium rich wastewater[J]. Water Science and Technology,1998,37(9):135-142.
[5] 张星,林炜铁,朱雅楠. 硝化细菌中亚硝酸盐氧化还原酶的研究进展[J]. 微生物学通报,2008,35(11):1806-1810.
[6] Tokutomi T,Shibayama C,Soda S,et　al. A novel control method for nitritation:The domination of ammonia-oxidizing bacteria by high concentrations of inorganic carbon in an airlift-fluidized bed reactor[J]. Water Research,2010,44(14):4195-4203.
[7] 张昭,李冬,曾辉平,等. 常温下部分亚硝化的启动中试研究[J]. 中国给水排水,2012,28(17):21-25.
[8] Chai L Y,Ali M,Min X B,et al. Partial nitrification in an air-lift reactor with long-term feeding of increasing ammonium concentrations[J]. Biosource Technology,2015,185:134-142.
[9] Chuang H P,Ohashi A,Imachi H,et al. Effective partial nitrification to nitrite by down-flow hanging sponge reactor under limited oxygen condition[J]. Water Research,2007,41(2):295-302.
[10] 卢俊平,杜兵,张志高,等. 高氨氮废水稳定亚硝化技术研究[J]. 中国给水排水,2010,26(11):80-83.
[11] Chen J W,Zheng P,Yu Y,et al. Enrichment of high activity nitrifers to enhance partial nitrification process[J]. Bioresource Technology,2010,101(8):2700-2705.
[12] Ciudad G,Rubilar O,Munoz P,et al. Partial nitrification of high ammonia concentration wastewater as a part of a shortcut biological nitrogen removal process[J]. Process Biochemistry,2005,40(5):1715-1719.
[13] Jaroszynski L W,Oleszkiewicz J A. Autotrophic ammonium removal from reject water:Partial nitrification and ANAMMOX in one-reactor versus two-reactor systems[J]. Environmental Technology,2011,32(3):289-294.
[14] Vadivelu V M,Keller J,Yuan Z. Free ammonia and free nitrous acid inhibition on the anabolic and catabolic processes of Nitrosomonas and Nitrobacter[J]. Water Science and Technology,2007,56(7):89-97.
[15] Jubany I,Lafuente J,Baeza J. A total and stable washout of nitrite oxidizing bacteria from a nitrifying contunious activated sludge system using automatic control based on oxygen uptake rate measurements[J]. Water Research,2009,43(11):2761-2772.
[16] Pambrun V,Paul E,Sprandio M. Modelling the partial nitrification in sequencing batch reactor for biomass adapted to high ammonia　concentrations[J]. Biotechnology and Bioengineering,2006,95(1):120-131.
[17] Park S,Bae W. Modeling kinetics of ammonium oxidation and nitrite oxidation under simultaneous inhibition by free ammonia and free nitrous acid[J]. Process Biochemistry,2009,44(6):631-640.

限氧条件下亚硝化的稳定运行及动力学

Stable operation and kinetics of partial nitrification under limited oxygen concentration

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 4

编辑推荐

Metrics

本文评价

[1]	陈娜, 张肖静, 张楠, 马冰冰, 张涵, 杨浩洁, 张宏忠. 淬灭酶对亚硝化-混合自养脱氮系统的影响[J]. 化工进展, 2023, 42(7): 3816-3823.
[2]	胡璇, 陈滢. 聚酯纤维微塑料胁迫下活性污泥系统性能及微生物群落的变化情况[J]. 化工进展, 2023, 42(2): 1051-1060.
[3]	钱允致,马华继,苑宏英,丁艳梅,张轶凡,田素凤,李玉友,池勇志,张博文. 内循环接触氧化型膜生物反应器部分硝化启动与运行条件[J]. 化工进展, 2019, 38(9): 3995-4002.
[4]	崔剑虹, 李祥, 黄勇. 部分亚硝化-厌氧氨氧化工艺联合形式、应用及脱氮效能评析[J]. 化工进展, 2015, 34(08): 3142-3146.