SNCR脱硝技术在液态排渣煤粉工业锅炉中的应用

doi:10.16085/j.issn.1000-6613.2019-2089

化工进展 ›› 2020, Vol. 39 ›› Issue (10): 4290-4296.DOI: 10.16085/j.issn.1000-6613.2019-2089

SNCR脱硝技术在液态排渣煤粉工业锅炉中的应用

陈赛(), 贾明生(), 郭明高, 刘高珍

广东海洋大学机械与动力工程学院，广东湛江 524088

出版日期:2020-10-05 发布日期:2020-10-09
通讯作者: 贾明生
作者简介:陈赛（1993－），男，硕士研究生，研究方向为燃煤锅炉低污染排放技术。E-mail：chensai1110@163.com。
基金资助:
广东海洋大学“创新强校工程”2016年广东省财政专项资金(GDOU2016050257)

Application of SNCR to reduction of NO_x in an industrial scale slag-tap pulverized coal boiler

Sai CHEN(), Mingsheng JIA(), Minggao GUO, Gaozhen LIU

School of Mechanical and Power Engineering, Guangdong Ocean University, Zhanjiang 524088, Guangdong, China

Online:2020-10-05 Published:2020-10-09
Contact: Mingsheng JIA

摘要/Abstract

摘要：

为了检验选择性非催化还原（SNCR）脱硝技术在高效低NO_x液态排渣煤粉工业锅炉中的应用效果，本文在一台8.4MW有机热载体锅炉炉膛内开展了SNCR脱硝技术工业化试验研究。选用尿素作为还原剂，搭建了工业化SNCR脱硝试验平台。在10%、15%、20%三种浓度尿素溶液下进行了不同尿素溶液喷射量、不同氧含量、不同锅炉负荷下的SNCR脱硝试验研究。试验结果表明，提出的“低NO_x燃烧+SNCR脱硝”耦合技术方案是可行的，SNCR脱硝效率在80%以上，完全能够达到烟气中NO_x低于50mg/m³的超低排放要求。

关键词: 煤粉工业锅炉, 选择性非催化还原脱硝, 液态排渣, 尿素, 低氮氧化物

Abstract:

In order to test the application effect of SNCR denitration technology in high efficiency and low NO_x slag-tap pulverized coal industrial boiler, the industrial test of SNCR denitration technology was carried out in the furnace of an 8.4MW organic heat carrier boiler. Urea was selected as reducing agent, and an industrial SNCR denitration test platform was built. The SNCR denitrification tests under different urea solution injection volume, different oxygen content, and different boiler loads were carried out with urea solutions of three concentrations of 10%, 15% and 20%. The preliminary test results show that: the proposed "low NO_x combustion + SNCR denitration" coupling technology scheme is feasible, SNCR denitration efficiency is above 80%, and can completely meet the ultra-low emission requirements of NO_x in the flue gas below 50mg/m³.

Key words: pulverized coal industrial boiler, selective non-catalytic reduction denitrification, slag tapping, urea, low nitrogen oxides

中图分类号:

X701

陈赛, 贾明生, 郭明高, 刘高珍. SNCR脱硝技术在液态排渣煤粉工业锅炉中的应用[J]. 化工进展, 2020, 39(10): 4290-4296.

Sai CHEN, Mingsheng JIA, Minggao GUO, Gaozhen LIU. Application of SNCR to reduction of NO_x in an industrial scale slag-tap pulverized coal boiler[J]. Chemical Industry and Engineering Progress, 2020, 39(10): 4290-4296.

参考文献

1	中华人民共和国生态环境部. 锅炉大气污染排放标准: GB 13271—2014[S]. 北京: 中国标准出版社, 2014.
1	Ministry of Ecology and Environment of the People’s Republic of China. Emission standard of air pollutants for boiler: GB 13271—2014[S]. Beijing: Standards Press of China, 2014.
2	潘玉明.小型煤粉锅炉低NO_x高效燃烧应用技术[J].针织工业, 2016(7): 29-32.
2	PAN Y M. Applied technology of low NO_x high efficient combustion of small pulverized coal boiler[J]. Knitting Industries, 2016(7): 29-32.
3	侯冬尽. 高效低NO_x煤粉工业锅炉试验研究及制粉安全性分析[D]. 湛江: 广东海洋大学, 2016.
3	HOU D J. High efficiency low NO_x pulverized coal industry boiler experimental study and pulverizing safety analysis[D]. Zhanjiang: Guangdong Ocean University, 2016.
4	张林锋. 高效煤粉工业锅炉低NO_x排放特性及燃烧优化研究[D]. 湛江: 广东海洋大学, 2018.
4	ZHANG L F. Research on low NO_x emission characteristics and combustion optimization of high efficiency pulverized coal industrial boiler[D]. Zhanjiang: Guangdong Ocean University, 2018.
5	胥波, 张彦文, 蔡宁生. 链条炉SNCR脱除NO_x数值模拟研究[J]. 热力发电, 2009, 38(3): 18-25.
5	XU B, ZHANG Y W, CAI N S. Simulation study on SNCR for NO_x removal form chain-grate furnace[J]. Thermal Power Generation, 2009, 38(3): 18-25.
6	宋顺鑫, 张光学, 王进卿, 等. 35t/h链条炉SNCR脱硝特性的试验研究[J]. 电站系统工程, 2014, 30(4): 36-38.
6	SONG S X, ZHANG G X, WANG J Q, et al. Experimental study of denitrification characteristics with SNCR in a 35t/h grate-firing furnace[J]. Power System Engineering, 2014, 30(4): 36-38.
7	汪凡. 煤矿链条锅炉烟气SNCR脱硝工艺设计[J]. 化工设计通讯, 2019, 45(8): 104-105.
7	WANG F. Process design for removing NO_x transfermation project of chain boiler for ningtiaota coal mine[J]. Chemical Engineering Design Communications, 2019, 45(8): 104-105.
8	贾明生, 陈赛, 扶廷正, 等. 液态排渣煤粉工业锅炉炉内SNCR脱硝技术探讨[J]. 工业锅炉, 2019(3): 24-27, 40.
8	JIA M S, CHEN S, FU T Z, et al. Discussion on SNCR denitrification technology in slag-tap pulverized coal industrial boiler[J]. Industrial Boilers, 2019(3): 24-27, 40.
9	沈伯雄, 韩永富, 刘亭. 氨选择性非催化还原烟气脱硝研究进展[J]. 化工进展, 2008， 27(9): 1323-1327.
9	SHEN B X, HAN Y F, LIU T. Development of flue gas denitrification using NH₃selective non-catalytic reduction[J]. Chemical Industry and Engineering Progress, 2008， 27(9): 1323-1327.
10	HOSSAIN K A, MOHD-JAAFAR M N, APPALANIDU K B, et al. Application of urea based SNCR system in the combustion effluent containing low level of baseline nitric oxide[J]. Environmental Technology, 2005, 26(3): 251-260.
11	扶廷正. 高效低NO_x煤粉工业锅炉供粉稳定性试验研究及煤种适应性探讨[D]. 湛江: 广东海洋大学, 2019.
11	FU T Z. Experimental research on pulverized coal supply stability of high efficiency and low NO_x pulverized coal industrial boiler and discussion on the adaptablity of coal species[D]. Zhanjiang: Guangdong Ocean University, 2019.
12	HILL S, DOUGLAS S L. Modeling of nitrogen oxides formation and destruction in combustion systems[J]. Progress in Energy and Combustion Science, 2000, 26(4):417-458.
13	GLARBORG P, MILLER J A,RUSCIC B, et al. Modeling nitrogen chemistry in combustion[J]. Progress in Energy & Combustion Science, 2018, 67: 31-68.
14	陈瑶姬, 周志军, 周宁, 等. 贵州无烟煤的燃烧动力学特性和NO_x生成机制试验研究[J]. 中国电机工程报, 2011, 31(20): 52-59.
14	CHEN Y J, ZHOU Z J, ZHOU N, et a1.Combustion kinetics characteristics and experimental study on NO_x formation mechanism of guizhou anthracite[J]. Proceedings of the CSEE,2011, 31(20): 52-59.
15	ARAND J K, MUZIO L J, SOTTER J G. Urea reduction of NO_x in combustion effluents: US4208386[P]. 1980-06-17.
16	吕洪坤, 杨卫娟, 周俊虎, 等. 化学计量比、雾化压力对电站锅炉SNCR脱硝的影响[J]. 化工学报, 2008, 59(11): 2898-2903.
16	LYU H K, YANG W J, ZHOU J H, et a1. Impact of NSR and atomization pressure on SNCR used in power plant boiler[J]. CIESC Journal,2008, 59(11): 2898-2903.

[1]	孙晖, 孟祥海, 魏景海, 周红军, 徐春明. 绿电制氢生产氨的新场景与实践[J]. 化工进展, 2023, 42(2): 1098-1102.
[2]	卓祖优, 宋生南, 黄明堦, 杨旋, 卢贝丽, 陈燕丹. 草酸钾-尿素协同活化法制备超大比表面积面粉基多级孔炭及其电化学储能应用[J]. 化工进展, 2023, 42(2): 925-933.
[3]	王哲, 余颖, 石永杰, 杨顺, 陈久洲, 崔希利, 邢华斌. 尿素包合法分离费托轻质油中的正构烃[J]. 化工进展, 2023, 42(2): 677-683.
[4]	郑瑾, 韩瑞瑞, 李丹丹, 王馨妤, 高春阳, 杜显元, 张晓飞, 邹德勋. 过氧化尿素与微生物联合修复石油污染土壤[J]. 化工进展, 2022, 41(9): 5085-5093.
[5]	杨希刚, 陈国庆, 黄林滨, 古世军, 李昌松, 张勇, 金保昇. 尿素法SNCR对大型电站煤粉锅炉运行影响的工业试验[J]. 化工进展, 2022, 41(7): 3573-3581.
[6]	张军保, 王忠凯, 刘彪, 张晓晖, 刘冠美. 大颗粒尿素造粒尾气冷却洗涤器技术应用进展[J]. 化工进展, 2021, 40(S2): 15-19.
[7]	邓秀春, 卓祖优, 白小杰, 孙杰, 陈燕丹. 银耳菌糠衍生的三维多级孔炭及其电化学应用性能[J]. 化工进展, 2021, 40(10): 5642-5651.
[8]	陆佳, 刘伟, 王欣, 苏小红, 范超. 玉米秸秆衍生碳基固体酸的制备及其催化纤维素水解糖化[J]. 化工进展, 2020, 39(9): 3635-3642.
[9]	郭闯, 仲兆平, 杜浩然, 彭代军. 锐钛型TiO₂对尿素热解过程的影响[J]. 化工进展, 2019, 38(02): 899-904.
[10]	邢静润, 申锋, 仇茉, 漆新华. NaOH/尿素冻融预处理纤维素及其酸催化水解[J]. 化工进展, 2018, 37(06): 2159-2165.
[11]	李艳荣, 张香, 杨岚, 贺建勋, 闵小建, 樊英杰, 马晓迅. 钠添加剂对介质阻挡-电晕放电耦合法尿素脱除NO的影响[J]. 化工进展, 2018, 37(05): 1978-1984.
[12]	向小凤, 张向宇, 张波, 高宁, 陆续, 徐宏杰. 火电厂脱硝用尿素水解中试试验[J]. 化工进展, 2016, 35(S1): 332-336.
[13]	吴雪梅, 丁同梅, 赫崇衡, 田恒水. 尿素醇解法合成碳酸乙烯酯[J]. 化工进展, 2016, 35(10): 3263-3266.
[14]	王燕1，葛喜慧2，张敏卿1，朱怀工3，张子建2，王明1. 费托合成高温油相产品中正构烃的分离[J]. 化工进展, 2014, 33(11): 2894-2898.
[15]	赵晓明1，2，李金来1，2，李伟2，马丽荣2，贾永强2. 液态排渣煤渣的高附加值利用[J]. 化工进展, 2014, 33(08): 2206-2210.

SNCR脱硝技术在液态排渣煤粉工业锅炉中的应用

Application of SNCR to reduction of NO_x in an industrial scale slag-tap pulverized coal boiler

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

SNCR脱硝技术在液态排渣煤粉工业锅炉中的应用

Application of SNCR to reduction of NOx in an industrial scale slag-tap pulverized coal boiler

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

Application of SNCR to reduction of NO_x in an industrial scale slag-tap pulverized coal boiler