乳化液膜法提取废水中的阿司匹林

doi:10.16085/j.issn.1000-6613.2017-1242

摘要/Abstract

摘要： 针对阿司匹林（ASA）结晶母液经处理后产生的废液，采用搅拌和超声结合的方法制备了乳化液膜体系来回收ASA。以环己烷为膜溶剂，Span80做表面活性剂，石蜡做膜稳定剂，氢氧化钠（NaOH）为内水相，研究了表面活性剂浓度、内水相NaOH浓度、内水相类型、外相pH、油内比、乳水比、搅拌速度、膜溶剂类型、盐浓度、ASA初始浓度等试验条件对ASA萃取效果的影响，并进行了破乳研究。结果表明：在最佳实验条件下[环己烷90%（质量分数）、Span80 6%（质量分数）、C（NaOH）=0.1mol/L、油内比1：1、水乳比1：4、搅拌速度200r/min、ASA初始浓度500mg/L]，不对外相进行pH调节时，15min后ASA的萃取率可高达97.4%。对实验后的乳液进行离心破乳，20min后破乳率可达72.9%，破乳后的油相重复利用5次后，对ASA的提取率仍在76%左右。

关键词: 膜, 阿司匹林, 乙酰水杨酸, 萃取, 废水

Abstract: The emulsion liquid membrane(ELM) system was prepared by combining agitation with ultrasonic to extract ASA(acetylsalicylic acid) from wastewater produced by ASA crystallization mother liquor.The ELM system is made up of the cyclohexane as diluent,Span80 as the surfactant,liquid wax as the stabilizer,and the sodium hydroxide as the inneraqueous solution. The effect of the experimental conditions that affect the extraction of ASA,such as surfactant concentration,internal phase concentration,type of internal phase,pH of external phase,volume ratio of oil phase to internal phase,treatment ratio(ratio of emulsion phase to external phase),stirring speed,diluent type,salt concentration,and ASA initial concentration was investigated. The experimental results showed that under the optimum operating conditions[diluent (cyclohexane) 90% (mass ratio);surfactant (Span80) 6% (mass ratio);stabilizer (liquid wax) 4%;C(NaOH)=0.1mol/L;V(oil phase):V(internal phase)=1:1;V(emulsion phase):V(external phase)=1:4;stirring speed=200r/min;ASA initial concentration,500mg/L] about 97.4% ASA was removed in less than 15min of contacting time. Meanwhile,the demulsification rate of emulsion was 72.9% after about 20min,and the extraction rate of ASA was still about 76% after demulsification while oil phase was used for 5 times.

Key words: membrane, aspirin, acetylsalicylic acid, extraction, wastewater

中图分类号:

TQ028.8

姜亚彤, 李明雪, 高瑞昶. 乳化液膜法提取废水中的阿司匹林[J]. 化工进展, 2018, 37(04): 1559-1565.

JIANG Yatong, LI Mingxue, GAO Ruichang. Extraction of aspirin from wastewater by emulsion liquid membrane[J]. Chemical Industry and Engineering Progress, 2018, 37(04): 1559-1565.

参考文献

[1] HAO T T,SIAH W R,YULIATI L. Enhanced adsorption of acetylsalicylic acid over hydrothermally synthesized iron oxide-mesoporous silica MCM-41 composites[J]. Journal of the Taiwan Institute of Chemical Engineers,2016,65:591-598.
[2] 田颖霄. 活性炭对水中乙酰水杨酸和对乙酰氨基酚的吸附研究[D]. 太原:中北大学,2016. TIAN Y X. Study on adsorption of acetylsalicylic acid and acetaminophen by activated carbon[D]. Taiyuan:North Central University,2016.
[3] 吴孝好,何雪涛,陈洪全,等. 阿司匹林残液处理工艺:106397180A[P]. 2017-02-15. WU X H,HE X T,CHEN H Q,et al. Aspirin residue treatment process:106397180A[P]. 2017-02-15.
[4] MOLDOVAN Z. Occurrences of pharmaceutical and personal care products as micropollutants in rivers from Romania[J]. Chemosphere,2006,64(11):1808-1817.
[5] EKPEGHERE K I,LEE J W,KIM H Y,et al. Determination and characterization of pharmaceuticals in sludge from municipal and livestock wastewater treatment plants[J]. Chemosphere,2017,168:1211-1221.
[6] ARRUBLA J P,CUBILLOS J A,RAMÍREZ C A,et al. Pharmaceutical and personal care products in domestic wastewater and their removal in anaerobic treatment systems:septic tank-up flow anaerobic filter[J]. Ingenieria e Investigacion,2016,36(1):70-78.
[7] AGUNBIADE F O,MOODLEY B. Occurrence and distribution pattern of acidic pharmaceuticals in surface water,wastewater,and sediment of the Msunduzi River,Kwazulu-Natal,South Africa[J]. Environmental Toxicology & Chemistry,2016,35(1):36-46.
[8] NAKADA N,TANISHIMA T,SHINOHARA H,et al. Pharmaceutical chemicals and endocrine disrupters in municipal wastewater in Tokyo and their removal during activated sludge treatment[J]. Water Research,2006,40(17):3297-3303.
[9] BESSERGENEV V G,MATEUS M C,MORGADO I M,et al. Photocatalytic reactor,CVD technology of its preparation and water purification from pharmaceutical drugs and agricultural pesticides[J]. Chemical Engineering Journal,2017,312:306-316.
[10] BIANCHI C L,SACCHI B,PIROLA C,et al. Aspirin and paracetamol removal using a commercial micro-sized TiO₂ catalyst in deionized and tap water[J]. Environmental Science & Pollution Research,2017,24(14):12646-12654.
[11] MUKHERJEE D,BARGHI S,RAY A K. Preparation and characterization of the TiO₂immobilized polymeric photocatalyst for degradation of Aspirin under UV and solar light[J]. Processes,2013,2(1):12-23.
[12] Al-KHATEEH L A,ALMOTIRY S,SALAM M A. Adsorption of pharmaceutical pollutants onto graphene nanoplatelets[J]. Chemical Engineering Journal,2014,248:191-199.
[13] CUI Y,MENG Q,DENG X,et al. Fabrication of platinum nano-crystallites decorated TiO₂,nano-tube array photoelectrode and its enhanced photoelectrocatlytic performance for degradation of aspirin and mechanism[J]. Journal of Industrial & Engineering Chemistry,2016,43:177-184.
[14] 夏伊静. 高效金属掺杂PbO₂电极的制备及用于降解典型制药废水的研究[D]. 杭州:浙江工业大学,2016. XIA Y J. Preparation of highly efficient metal doped PbO₂ electrode and its application to degradation of typical pharmaceutical wastewater[D]. Hangzhou:Zhejiang University of Technology,2016.
[15] DAI Q,XIA Y,CHEN J. Mechanism of enhanced electrochemical degradation of highly concentrated aspirin wastewater using a rare earth La-Y co-doped PbO₂,electrode[J]. Electrochimica Acta,2015,188:871-881.
[16] 王林娇. 铁基磁性复合金属氧化物催化臭氧化水中有机污染物的研究[D]. 石家庄:河北师范大学,2015. WANG L J. Study on the catalytic ozonation of organic pollutants in water by iron based magnetic composite metal oxides[D]. Shijiazhuang:Hebei Normal University,2015.
[17] 李越. 负载型催化剂催化臭氧化降解水中水杨酸的研究[D]. 泰安:山东农业大学,2014. LI Y. Study on catalytic ozonation of salicylic acid in aqueous solution by supported catalyst[D]. Tai'an:Shandong Agricultural University,2014.
[18] 宋林林,赵乾琨,高胜寒,等. 乳化液膜法提取废水中的6-APA[J]. 精细化工,2016,33(11):1272-1277,1294. SONG L L,ZHAO Q K,GAO S H,et al. The extraction of 6-APA in waste water by emulsion liquid membrane[J]. Fine Chemicals,2016,33(11):1272-1277,1294.
[19] 胡萌晓,乔楠楠,常嘉丽,等. 乳化液膜的制备及其在1-萘酚废水处理中的实验研究[J]. 膜科学与技术,2015,35(2):93-97. HU M X,QIAO N N,CHANG J L,et al. Preparation of emulsion liquid membrane and experimental study on the treatment of 1-naphthol wastewater[J]. Membrane Science and Technology,2015,35(2):93-97.
[20] CHAOUCHI S,HAMDAOUI O. Removal of 4-nitrophenol from water by emulsion liquid membrane[J]. Desalination & Water Treatment,2016,57(12):5253-5257.
[21] CHAOUCHI S,HAMDAOUI O. Extraction of endocrine disrupting compound propylparaben from water by emulsion liquid membrane using trioctylphosphine oxide as carrier[J]. Journal of Industrial & Engineering Chemistry,2015,22:296-305.
[22] HIRAI T,HIRANO T,KOMASAWA I. Preparation of Gd₂O₃:Eu³⁺ and Gd₂O₂S:Eu³⁺ phosphor fine particles using an emulsion liquid membrane system[J]. Journal of Colloid & Interface Science,2002,253(1):62-69.
[23] MA H,KOKKILIC O,WATERS K E. The use of the emulsion liquid membrane technique to remove copper ions from aqueous systems using statistical experimental design[J]. Minerals Engineering,2017,107:88-89.
[24] SULAIMAN R N R,OTHMN N,AMIN N A S. Emulsion liquid membrane stability in the extraction of ionized nanosilver from wash water[J]. Journal of Industrial & Engineering Chemistry,2014,20(5):3243-3250.
[25] ZHANG J,ZHANG S,YANG X,et al. Reactive extraction of amino acids mixture in hydrolysate from cottonseed meal with di(2-ethylhexyl) phosphoric acid[J]. Journal of Chemical Technology & Biotechnology,2016,91(2):483-489.
[26] LEE S C. Removal of acetic acid from simulated hemicellulosic hydrolysates by emulsion liquid membrane with organophosphorus extractants[J]. Bioresource Technology,2015,192:340-345.
[27] BARRAMA T,PARAEAN D,DURAND G. Batch and dynamic study of lactic acid extraction using emulsion liquid membrane[J]. Membrane Water Treatment,2015,6(4):277-292.
[28] PENG W,JIAO H,SHI H,et al. The application of emulsion liquid membrane process and heat-induced demulsification for removal of pyridine from aqueous solutions[J]. Desalination,2012,286(1):372-378.
[29] DÂAS A,HAMDAOUI O. Extraction of anionic dye from aqueous solutions by emulsion liquid membrane[J]. Journal of Hazardous Materials,2010,348(1):360-368.
[30] BALASUBRAMANIAN A,VENKATESAN S. Removal of phenolic compoundsfrom aqueous solutions by emulsion liquid membrane containingionic liquid[BMIM]⁺[PF₆]^- in tributyl phosphate[J]. Desalination,2012,289:27-34.