不同无机酸对聚吡咯/TiO2复合物的吸附性能影响

doi:10.16085/j.issn.1000-6613.2016.s1.048

摘要/Abstract

摘要： 考察了不同无机酸对PPy/TiO₂复合物吸附性能的影响。首先分别在HNO₃、H₂SO₄和H₃PO₄体系中合成了聚吡咯(PPy)/TiO₂复合物(分别简写为N-PPy/TiO₂、S-PPy/TiO₂和P-PPy/TiO₂)。以红外光谱、热重分析、Zeta电位、比表面积分析和扫描电镜等测试方法对复合物的物理化学性能进行了表征。接着以几种合成的复合对阴离子染料酸性红G和阳离子染料亚甲基蓝进行吸附研究,发现无机酸对合成的复合物的吸附性有较大的影响。几种复合物均可在30min内达到吸附平衡,并且可以重复使用6次以上吸附量没有明显的降低。其中S-PPy/TiO₂的吸附性能最好,其对ARG和MB的最大吸附量分别达到218.34mg/g和314.68mg/g。复合物对染料的吸附过程符合准二级动力学模型和Langmuir吸附等温式。对S-PPy/TiO₂进行吸附热力学研究表明,其对染料的吸附过程为熵增的自发过程。

关键词: 聚吡咯/TiO₂复合物, 吸附, 动力学, 热力学

Abstract: This study focused on the impact of various inorganic acids on the adsorption polypyrrole/TiO₂ (PPy/TiO₂) composites.Firstly, PPy/TiO₂ composites were prepared in the HNO₃(N-PPy/TiO₂)、H₂SO₄(S-PPy/TiO₂) and H₃PO₄ (P-PPy/TiO₂)systems, respectively. FT-IR spectra, TG analysis, Zeta potential, specific surface area analysis and SEM were employed to character the physicochemical properties of the composites.Secondly, the adsorption of the as-prepared composites for anionic dye Acid red G (ARG) and cationic dye methylene blue (MB) were investigated.It was found that the adsorption performance of the composites prepared in acid system has been greatly improved.The adsorption equilibrium of all composites can reach in 30min.The composites could be reused for 6 cycles without obvious loss of adsorption capacity.S-PPy/TiO₂ composite had the best adsorption properties.Its maximum adsorption capacity for ARG and MB were 218.34mg/g and 314.68mg/g, respectively.The adsorption process of dyes onto the composites was in accordance with pseudo-second-order models and Langmuir isotherm.The S-PPy/TiO₂ adsorption thermodynamics research showed that the adsorption process of dyes onto the composite was a spontaneous process of entropy increase.

Key words: polypyrole/TiO₂ composite, adsorption, kinetics, thermodynamics

中图分类号:

TQ317

冯江涛, 李晶晶, 徐浩, 延卫. 不同无机酸对聚吡咯/TiO₂复合物的吸附性能影响[J]. 化工进展, 2016, 35(S1): 294-303.

FENG Jiangtao, LI Jingjing, XU Hao, YAN Wei. The influence of various inorganic acids on the adsorption performance of the polypyrrole/TiO₂ composites[J]. Chemical Industry and Engineering Progree, 2016, 35(S1): 294-303.

参考文献

[1] ZHAO Z Q,CHEN X,YANG Q,et al.Selective adsorption toward toxic metal ions results in selective response:electrochemical studies on a polupyrrole/reduced graphene oxide nanocomposite[J].Chemical Communication,2012,48:2180-2182.
[2] HAMEED B H,DIN A T M,AHMAD A L.Adsorption of methylene blue onto bamboo-based activated carbon:kinetics and equilibrium studies[J].Journal of Hazardous Materials,2007,141(3):819-825.
[3] 杨晓东,顾安忠.活性炭吸附的理论研究进展[J].炭素,2000(4):11-16.
[4] 王文华,冯咏梅,常秀莲,等.玉米芯对废水中铅的吸附研究[J].水处理技术,2004,30(2):95-99.
[5] THIEGAULT T,GUEGAN R,BOUSSAFIR M.Adsorption mechanisms of emerging micro-pollutants with a clay mineral:case of tramadol and doxepine pharmaceutical products[J]. Journal of Colloid and Interface Science,2015,453:1-8.
[6] 杨光,许汇,王传明,等.两亲性嵌段共聚物在选择性溶液中吸附行为的理论研究[J].高分子学报,2015(12):1435-4442.
[7] LIU C B,CHEN Z G,NI C Y,et al.Adsorption of phenol from aqueous solution by hierarchical micro-nano porous carbon material[J].Rare Metals,2012,31(6):582-589.
[8] MPHAMAD M A,AHMED A E N.Adsorption of cationic dye(methylene blue)from water using polyaniline nanotubes base[J].Journal of Physical Chemistry C,2010,114:14377-14383.
[9] 张瑜,苏翔,周远涛,等.不同酸掺杂聚吡咯对酸性红G的吸附性能[J].化工进展,2014,33(9):2286-2292.
[10] BHAUMIK M,MCCRINDLE R,MAITY A.Efficient removal of Congo red from aqueous solutions by adsorption onto interconnected polypyrrole-polyaniline nanofibres[J].Chemical Engineering Journal,2013,228:506-515.
[11] 丁艳,金叶,王伟祥,等.硅磁微粒/聚苯胺复合物的制备及其对染料废水的吸附-降解性能[J].中国科学:化学,2015,45(2):202-210.
[12] WANG N,LI J J,LV W,et al.Synthesis of polyaniline-TiO₂ composite with excellent adsorption performance on acid red G[J].RSC Advances,2015,5:21132-21141.
[13] LI J J,ZHANG Q,FENG J T,et al.Synthesis of PPy-modified TiO₂ composite in H₂SO₄ solution and its novel adsorption characteristics for organic dyes[J].Chemical Engineering Journal,2013,225:766-775.
[14] LI J J,FENG J T,YAN W.Excellent adsorption and desorption characteristics of polypyrrole/TiO₂ composite for Methylene Blue[J].Applied Surface Science,2013,279:400-408.
[15] LI J J,FENG J T,YAN W.Synthesis of PPy-modified TiO₂ composite adsorbent and its adsorption performance on Acid Red G[J].Journal of Applied Polymer Science,2013,128:3231-3239.
[16] FOO K Y,HAMEED B H.Insights into the modeling of adsorption isotherm systems[J].Chemical Engineering Journal,2010,156(1):2-10.
[17] IQBAL M J,ASHIQ M N.Adsorption of dyes from aqueous slutions on activated charcoal[J].Journal of Hazardous Materials,2007,139(1):57-66.
[18] BLINOVA N V,STEJSKAL J,TRCHOVA M,et al. Polyaniline and polypyrrole:a comparative study of the preparation[J].European Ploymer Journal,2007,43(6):2331-2341.
[19] LIM CW,SONG K,KIM S H.Synthesis of PPy/silica nanocomposites with cratered surfaces and their application in heavy metal extraction[J].Journal of Industrial and Engineering Chemistry,2012,18(1):24-28.
[20] LI X Y,WANG D S,CHENG G X,et al.Preparation of polyaniline-modified TiO₂ nanoparticles and their photocatalytic activity under visible light illumination[J]. Applied Catalysis B:Environmental,2008,81(3):267-273.
[21] GÓMEA P C,GÁLVEZ O,MOSTEO R G,et al.Clusters of atmospheric relevance:H₂O/HCl/HNO₃.Prediction of IR & MW spectra[J].Physical Chemistry Chemical Physics,2010,12(18):4617-4624.
[22] WANG Z C,SHUI H F.Effect of PO₄^3- and PO₄^3--SO₄^2- modification of TiO₂ on its photocatalytic properties[J]. Journal of Molecular Catalysis A:Chemical,2007,263(1):20-25.
[23] WANG X C,YU J,LIU P,et al.Probing of photocatalytic surface sites on SO₄^2-/TiO₂ solid acids by in suit FT-IR spectroscopy and pyridine adsorption[J].Journal of Photochemistry Photobiology A:Chemistry,2006,179(3):339-347.
[24] TIAN B,ZERBI G.Lattice-dynamics and virbrational spectra of polypyrrole[J].Journal of Chemical Physics,1990,92(6):3886-3891.
[25] LIANG W,LEI J,MARTIN C R.Effect of synthesis temperature on the structure,doping level and charge-transport properties of polypyrrole[J].Synthetic Metals,1992,52(2):227-239.
[26] WEI M,LU Y.Templating fabrication of polypyrrole nanorods/nanofibers[J].Synthetic Metals,2009,159(11):1061-1066.
[27] KULKAMI M V,VISWANATH AK,MARIMUTHA R,et al.Spectroscopic,transport,and morphological studies of polyaniline doped with inorganic acids[J].Polymer Engineering and Science,2004,44(9):1676-1681.
[28] KAR P,CHOUDHURY A.Carboxylic acid functionalized multi-walled carbon nanotube doped polyaniline for choroform sensors[J].Sensors and Actuators B:Chemical,2013,183:25-33.
[29] CHOUDHURY A,KAR P.Doping effect of carboxylic acid group functionalized multi-walled carbonnanotube on polyaniline[J].Composites Part B:Engineering,2011,42(6):1641-1647.
[30] WU T M,LIN Y W.Doped polyaniline/multi-walled carbon nanotube composites:preparation,characterization and properties[J]. Polymer,2006,47(10):3576-3582.
[31] CHENG Q,HE Y,PAVLINEK V,et al.Surfactant-assisted polypyrrole/titanate composite nanofibers:morphology,structure and electrical properties[J]. Synthetic Metals,2008,158(21):953-957.
[32] LI X C,JIANG G L,HE G H,et al.Preparation of porous PPy-TiO₂ composites:improved visible light photoactivity and the mechanism[J].Chemical Engineering Journal,2014,236:480-489.
[33] HO Y S,MCKAY G.Pseudo-second order model for sorption process[J].Process Biochemistry,1999,34(5):451-465.
[34] ZHANG X,BAI R B.Surface electric properties of polypyrrole in aqueous solutions[J].Langmuir,2003,19(26):10703-10709.
[35] 覃岳隆,张寒冰,陈宁化,等.乙酸膨润土对孔雀石绿的吸附去除[J].化工进展,2016,35(3):944-949.
[36] HSU T C.Adsorption of an acid dye onto coal fly ash[J]. Fuel,2008,87:3040-3045.
[37] TONG D S,ZHOU C H,LAN Y,et al.Adsorption of acid red G on octadecyl trimethylammonium montmorillonite[J]. Applied Clay Science,2010,50:427-431.
[38] HAMEED B H,DIN A T M,AHMAD A L.Adsorption of methylene blue onto bamboo-based activated carbon:kinetics and equilibrium studies[J].Journal of Hazardous Materials,2007,141:819-825.
[39] QIAO X Q,Hu F C,TIAN F Y,et al.Equilibrium and kinetic studies on MB adsorption by ultrathin 2D MoS₂ nanosheets[J].Rsc Advances,2016,6:11631-11636.
[40] CRINI G,BADOT P M.Application of chitosan,a natural aminopolysaccharide,for dye removal from aqueous solutions by adsorption processes using batch studies:A review of recent literature[J].Progress in Polymer Science,2008,33:399-447.

不同无机酸对聚吡咯/TiO₂复合物的吸附性能影响

The influence of various inorganic acids on the adsorption performance of the polypyrrole/TiO₂ composites

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	崔守成, 徐洪波, 彭楠. 两种MOFs材料用于O₂/He吸附分离的模拟分析[J]. 化工进展, 2023, 42(S1): 382-390.
[2]	陈崇明, 陈秋, 宫云茜, 车凯, 郁金星, 孙楠楠. 分子筛基CO₂吸附剂研究进展[J]. 化工进展, 2023, 42(S1): 411-419.
[3]	许春树, 姚庆达, 梁永贤, 周华龙. 共价有机框架材料功能化策略及其对Hg(Ⅱ)和Cr(Ⅵ)的吸附性能研究进展[J]. 化工进展, 2023, 42(S1): 461-478.
[4]	顾永正, 张永生. HBr改性飞灰对Hg⁰的动态吸附及动力学模型[J]. 化工进展, 2023, 42(S1): 498-509.
[5]	汪鹏, 张洋, 范兵强, 何登波, 申长帅, 张贺东, 郑诗礼, 邹兴. 高碳铬铁盐酸浸出过程工艺及动力学[J]. 化工进展, 2023, 42(S1): 510-517.
[6]	郭强, 赵文凯, 肖永厚. 增强流体扰动强化变压吸附甲硫醚/氮气分离的数值模拟[J]. 化工进展, 2023, 42(S1): 64-72.
[7]	刘阳, 王云刚, 修浩然, 邹立, 白彦渊. 基于动力学分析的核桃壳最佳炭化工艺[J]. 化工进展, 2023, 42(S1): 94-103.
[8]	黄益平, 李婷, 郑龙云, 戚傲, 陈政霖, 史天昊, 张新宇, 郭凯, 胡猛, 倪泽雨, 刘辉, 夏苗, 主凯, 刘春江. 三级环流反应器中气液流动与传质规律[J]. 化工进展, 2023, 42(S1): 175-188.
[9]	王胜岩, 邓帅, 赵睿恺. 变电吸附二氧化碳捕集技术研究进展[J]. 化工进展, 2023, 42(S1): 233-245.
[10]	董佳宇, 王斯民. 超声强化对二甲苯结晶特性及调控机理实验[J]. 化工进展, 2023, 42(9): 4504-4513.
[11]	葛亚粉, 孙宇, 肖鹏, 刘琦, 刘波, 孙成蓥, 巩雁军. 分子筛去除VOCs的研究进展[J]. 化工进展, 2023, 42(9): 4716-4730.
[12]	杨莹, 侯豪杰, 黄瑞, 崔煜, 王兵, 刘健, 鲍卫仁, 常丽萍, 王建成, 韩丽娜. 利用煤焦油中酚类物质Stöber法制备碳纳米球用于CO₂吸附[J]. 化工进展, 2023, 42(9): 5011-5018.
[13]	张振, 李丹, 陈辰, 吴菁岚, 应汉杰, 乔浩. 吸附树脂对唾液酸的分离纯化[J]. 化工进展, 2023, 42(8): 4153-4158.
[14]	姜晶, 陈霄宇, 张瑞妍, 盛光遥. 载锰生物炭制备及其在环境修复中应用研究进展[J]. 化工进展, 2023, 42(8): 4385-4397.
[15]	于静文, 宋璐娜, 刘砚超, 吕瑞东, 武蒙蒙, 冯宇, 李忠, 米杰. 一种吲哚基超交联聚合物In-HCP对水中碘的吸附作用[J]. 化工进展, 2023, 42(7): 3674-3683.