TG-FTIR在煤灰研究中的应用 ——真实煤灰和模拟灰受热气体释放规律比较

doi:10.16085/j.issn.1000-6613.2015.06.023

化工进展 ›› 2015, Vol. 34 ›› Issue (06): 1641-1645.DOI: 10.16085/j.issn.1000-6613.2015.06.023

TG-FTIR在煤灰研究中的应用 ——真实煤灰和模拟灰受热气体释放规律比较

熊金钰^1,2, 李寒旭², 董众兵²

1 安徽理工大学地球与环境学院, 安徽淮南 232001;
2 安徽理工大学化学工程学院, 安徽淮南 232001

收稿日期:2015-01-29 修回日期:2015-04-13 出版日期:2015-06-05 发布日期:2015-06-05
通讯作者: 李寒旭,教授,博士生导师。E-mail:hxli@aust.edu.cn。
作者简介:熊金钰(1979—),女,讲师,博士研究生。
基金资助:
国家自然科学基金项目(21176003)。

Application of TG-FTIR in coal ash —Comparison of gas release from real and factitious ash during heating process

XIONG Jinyu^1,2, LI Hanxu², DONG Zhongbing²

1 School of Earth and Environment, Anhui University of Science and Technology, Huainan 232001, Anhui, China;
2 School of Chemical Engineering, Anhui University of Science and Technology, Huainan 232001, Anhui, China

Received:2015-01-29 Revised:2015-04-13 Online:2015-06-05 Published:2015-06-05

摘要/Abstract

摘要： 我国的煤炭种类多, 煤灰组成千变万化, 从中找到明确的矿物转变规律并非易事。为探索用模拟灰替代真实煤灰开展高温转变规律研究的可行性, 依据镇雄煤(ZX)煤灰化学成分, 利用FeS₂矿物和Fe₂O₃、SiO₂、Al₂O₃等分析纯化学试剂配制模拟灰, 测试灰熔融温度, 并借助热重红外联用(TG-FTIR)技术比较ZX真实煤灰和模拟灰在氮气气氛下升温过程中的质量变化及气态产物组成。结果表明, 模拟灰的流动温度接近ZX煤灰的流动温度, 最大相差49℃。当温度大于770℃时, 含有FeS₂的模拟灰与真实煤灰的TG-DTG曲线变化趋势一致。FTIR谱图显示两者释放的气体种类相同, 1080℃左右都产生SO₂气体, 此时的硫来源于黄铁矿的部分氧化产物FeS_x。含有FeS₂的模拟灰在高温下的变化更接近真实煤灰。

关键词: TG-FTIR, 模拟灰, 气态产物, 含铁成分

Abstract: There is a great variety of coal whose ash composition is greatly different in China. The behavior of coal ash at high temperature is so complicated that it is difficult to understand definitely minerals transformation. In order to explore the feasibility of the factitious ash instead of coal ash for studying transformation mechanism, the factitious ash was prepared from FeS₂ mineral and analytically pure reagents such as Fe₂O₃, SiO₂, and Al₂O₃ based on the composition of ZX coal ash. The ash fusion temperatures of samples were tested. Mass change and gaseous product compositions of the factitious ash were analyzed by thermogravimetry combining with Fourier-transform infrared spectroscopy (TG-FTIR) in the nitrogen atmosphere during temperature increase, in order to compare with ZX coal ash. The flow temperature (FT) of the factitious ash was approximate to that of ZX coal ash, and the maximum difference was 49℃. The TG results showed that the mass loss tendency of both the factitious ash containing FeS₂ and ZX coal ash was similar at the temperature above 770℃. It was observed that the gaseous products of the two ash samples were the same in species from the FTIR spectra. SO₂ was released at the temperature of 1080℃, which might be derived from FeS_x, partial oxidation of pyrite. The variation of the factitious ash containing FeS₂ at high temperature was more similar to that of ZX coal ash.

Key words: thermogravimetry combining with Fourier-transform infrared spectroscopy (TG-FTIR), factitious ash, gaseous product, iron-bearing component

中图分类号:

TQ536

熊金钰, 李寒旭, 董众兵. TG-FTIR在煤灰研究中的应用 ——真实煤灰和模拟灰受热气体释放规律比较[J]. 化工进展, 2015, 34(06): 1641-1645.

XIONG Jinyu, LI Hanxu, DONG Zhongbing. Application of TG-FTIR in coal ash —Comparison of gas release from real and factitious ash during heating process[J]. Chemical Industry and Engineering Progree, 2015, 34(06): 1641-1645.

参考文献

[1] 饶甦, 曹欣玉, 兰泽全, 等. 煤灰矿物质在炉内的迁徙分布规律及其对沾污结渣的影响[J]. 燃料化学学报, 2004, 32(4):395-399.
[2] 董一真. 煤灰中成分结渣特性研究[D]. 杭州:浙江大学, 2006.
[3] 赵京. 改善燃煤结渣以及燃烧特性的研究[D]. 杭州:浙江大学, 2011.
[4] Yani S, Zhang D. An experimental study of sulphate transformation during pyrolysis of an Australian lignite[J]. Fuel Proceeding Technology, 2010, 91(3):313-321.
[5] Corradi A B, Leonelli C, Manfredini T, et al. Quantitative determination of pyrite in ceramic clay raw materials by DTA[J]. Thermochimica Acta, 1996, 287(1):101-109.
[6] Boyabat N, Özer A K, Bayrakc S, et al. Thermal decomposition of pyrite in the nitrogen atmosphere[J]. Fuel Process Technology, 2004, 85:179-188.
[7] Mehring M, Elsener M, Kröcher O. Development of a TG-FTIR system for investigations with condensable and corrosive gases[J]. J. Therm. Anal. Calorim., 2011, 105:545-552.
[8] Cheng H F, Liu Q F, Huang M, et al. Application of TG-FTIR to study SO₂evolved during the thermal decomposition of coal-derived pyrite[J]. Thermochimica Acta, 2013, 555:1-6.
[9] Loría-Bastarrachea M, Herrera-Kao W, Cauich-Rodríguez J, et al. A TG/FTIR study on the thermal degradation of poly(vinyl pyrrolidone)[J]. J. Therm. Anal. Calorim., 2011, 104:737-742.
[10] 郭晓娟, 张刚. 手机SIM卡TG-FTIR热解实验研究[J]. 化工进展, 2014, 33(4):1030-1034.
[11] 张丽丽, 徐龙, 马晓迅. 应用TG-FTIR法研究铜川油页岩的热解特性[J]. 化工进展, 2011, 30(s1):115-119.
[12] 李少华, 高俊男, 车德勇. CO₂气氛下乌拉盖煤热解过程中气体释放特征及机理[J]. 化工进展, 2014, 33(2):358-363.
[13] 彭云云, 武书彬. 蔗渣碱木素的热裂解特性[J]. 化工进展, 2012, 31(2):462-467.
[14] 煤炭科学研究总院. GB/T 219—2008 煤灰熔融性的测定方法[S]. 北京:中国标准出版社, 2009.
[15] Duan L B, Zhao C S, Zhou W, et al. Sulfur evolution from coal combustion in O₂/CO₂mixture[J]. Journal of Analytical and Applied Pyrolysis, 2009, 86:269-273.
[16] Bhargava S K, Garg A, Subasinghe N D. In situ high-temperature phase transformation studies on pyrite[J]. Fuel, 2009, 88:988-993.
[17] Pat Skhonde M, Henry Matjie R, Reginald Bunt J, et al. Sulfur behavior in the sasol-lurgi fixed-bed dry-bottom gasification process[J]. Energy & Fuels, 2009, 23:229-235.
[18] Li F H, Huang J J, Fang Y T, et al. Mineral behavior of low-temperature lignite ashes under gasification atmosphere[J]. Korean J. Chem. Eng., 2013, 30(3):605-612.
[19] 肖海平, 周俊虎, 刘建忠, 等. 高温下CaS氧化反应特性的实验研究[J]. 高校化学工程学报, 2006, 20(3):494-498.

TG-FTIR在煤灰研究中的应用 ——真实煤灰和模拟灰受热气体释放规律比较

Application of TG-FTIR in coal ash —Comparison of gas release from real and factitious ash during heating process

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 2

编辑推荐

Metrics

本文评价

[1]	罗万江, 兰新哲, 宋永辉. 油页岩微波热解气态产物析出特性[J]. 化工进展, 2015, 34(3): 689-694.
[2]	王擎，闫宇赫，贾春霞，朱玉成. 甘肃油页岩红外光谱分析及热解特性[J]. 化工进展, 2014, 33(07): 1730-1734.