Research on microalgae oil extraction by organic solvent

doi:10.16085/j.issn.1000-6613.2015.05.018

Abstract

Abstract: With increasing depletion of conventional fossil energy,more and more attention has been paid to biodiesel as a renewable alternative energy source. Microalgae oil extraction is a key part in promotion and the application of biodiesel. In this study,microalgae oil was extracted with organic solvents,and oil extraction yield of microalgae was investigated under different conditions. Microalgae oil extraction yield was especially studied by successive use of two organic solvents,methanol and petroleum ether. Temperature,liquid-material ratio and extraction time affected extraction rate,and the use of methanol and petroleum ether increased algae oil extraction yield significantly via two steps. Extraction yield was 58.71% when organic solvent was petroleum ether,liquid-material ratio was 15mL/g,temperature was 45℃ and extraction time was 5h. Moreover,extraction yield could be increased to 87.90% when methanol and petroleum ether were used successively in two steps,while temperature could be lowered to 35℃ under the same conditions of liquid-material ratio and extraction time.

Key words: biomass, microalgae oil, oil extraction, extraction yield, bioenergy, biodiesel

摘要： 在传统化石能源日益枯竭的趋势下,微藻生物柴油作为第三代绿色可再生的替代型能源越来越受到人们的重视.在微藻生物柴油的产业链上,油脂的提取是影响其推广应用的一个关键环节.本文实验利用有机溶剂提取微藻油脂,探究在不同的条件下微藻油脂的提取效果,并特别研究了先后使用甲醇和石油醚两种有机溶剂对微藻油脂提取率的影响.研究结果表明:温度、液料比、浸提时间对提取效率都有一定的影响,并且使用甲醇和石油醚两种溶剂分步提取时会使微藻油脂提取率明显提高;在液料比为15mL/g、提取温度为45℃、提取时间为5h时,使用石油醚作为提取剂的提取率为58.71%;使用甲醇溶剂提取后再使用石油醚提取时,在液料比和提取时间相同的条件下,温度为35℃时提取率即可达87.90%

关键词: 生物质, 微藻油脂, 油脂提取, 提取率, 生物能源, 生物柴油

CLC Number:

YIN Hai, XU Jin, WANG Zhongming, HAO Xiaohong, YUAN Zhenhong, WANG Yabing. Research on microalgae oil extraction by organic solvent[J]. Chemical Industry and Engineering Progree, 2015, 34(05): 1291-1294,1306.

殷海, 许瑾, 王忠铭, 郝小红, 袁振宏, 王亚兵. 利用有机溶剂提取微藻油脂的方法探究[J]. 化工进展, 2015, 34(05): 1291-1294,1306.

References

[1] Chisti Yusuf. Biodiesel from microalgae[J]. Biotechnology Advances,2007,25(3):294-306.

[2] 李雪静,张璐瑶,乔明,等. 藻类生物燃料研究开发进展[J]. 中外能源,2009,14(4):23-26.

[3] 蒋晓菲,周红茹,金青哲,等. 微藻油脂制取技术的研究进展[J]. 中国油脂,2012,37(10):62-66.

[4] Rösch C,Skarka J,Wegerer N. Materials flow modeling of nutrient recycling in biodiesel production from microalgae[J]. Bioresource Technology,2012,107(3):191-199.

[5] 杨忠华,陈明明,曾嵘,等. 利用微藻技术减排二氧化碳的研究进展[J]. 现代化工,2008,28(8):15-19.

[6] 姚茹,程丽华,徐新华,等. 微藻的高油脂化技术研究进展[J]. 化学进展,2010,22(6):1221-1230.

[7] 倪培德,江志炜. 高油分油料水酶解法预处理制油新技术[J]. 中国油脂,2002,27(6):5-8.

[8] 马帅,付莉莉,汪萌,等. 从微藻中提取粗脂的方法比较[J]. 中国油脂,2010,35(5):77-79.

[9] 王晓晨,兰永辉,张小平,等. 溶剂提取-荧光光谱法测定微藻油脂[J]. 化工进展,2013,32(1):114-117.

[10] Aresta M,Dibenedetto A,Barberio G. Utilization of macro-algae for enhanced CO₂ fixation and biofuels production:Development of a computing software for an LCA study[J]. Fuel Proc. Technol.,2005,86:1679-1693.

[11] 陈国,赵珺,苏鹏飞,等. 微藻产生物柴油研究进展[J]. 化工进展,2011,30(10):2186-2193.

[12] Taher H,Al-Zuhair S,Al-Marzouqi AH,et al. Effective extraction of microalgae lipids from wet biomass for biodiesel production[J]. Biomass Bioenergy,2014,66:159-67.

[13] 张梦,程霞萍,李昌灵,等. 三种浸提方法从普通小球藻中提取油脂的比较研究[J]. 食品工业科技,2013,34(8):245-248.

[14] 张芳,程丽华,徐新华,等. 能源微藻采收及油脂提取技术[J]. 化学进展,2012,24(10):2062-2072.

[15] Folch J,Ascoli I,Lees M,et al. Preparation of lipide extracts from brain tissue[J]. The Journal of Biological Chemistry,1951:833-841.

[16] Halim R,Gladman B,Danquah M K,et al. Oil extraction from microalgae for biodiesel production[J]. Bioresource Technology,2011,102(1):178-185.

[17] Chiara B,Inna K,et al. Sammy B,et al. Lipid and fatty acid composition of the green oleaginous alga Parietochloris incisa,the richest plant source of arachidonic acid[J]. Phytochemistry,2002,60(5):497-503.

[18] Hemanathan K. Biodiesel production from freshwater algae[J].Energy Fules，2009，23（4）：5448-5453.

[19] Halim R，Danquah M K，Webley P A. Extraction of oil from microalgae for biodiesel production：A review[J]. Biotechnology Advances，2012，30（3）：709-732.

[20] Lam M K，Lee K T. Microalgae biofuels：A critical review of issues，problems and the way forward[J]. Biotechnology Advances，2012，30（3）：673-90.

[21] Ana Maria Pereira Neto，Rafael Augusto Sotana de Souza，Amanda Denisse Leon-Nino，et al. Improvement in microalgae lipid extraction using a sonication-assisted method[J]. Renewable Energy，2013，55：525-531.

[22] Bligh E G，Dyer W J. A rapid method for total lipid extraction and purification[J]. Canadian Journal of Biochemistry and Physiology，1959，37：911-917.

[23] 邓祥元，高坤，景吉，等. 索氏法提取微藻油脂的工艺优化研究[J].安徽农业科学，2012，40（22）：11370-11385.

[24] 李明. 提取技术与实例[M]. 北京：化学工业出版社，2006.