Effect of hot air and microwave drying on the quality of coal slime

doi:10.16085/j.issn.1000-6613.2019-0989

Chemical Industry and Engineering Progress ›› 2019, Vol. 38 ›› Issue (s1): 122-127.DOI: 10.16085/j.issn.1000-6613.2019-0989

• Energy processes and technology • Previous Articles Next Articles

Effect of hot air and microwave drying on the quality of coal slime

YAN Yecheng, JING Chuanming, SONG Zhanlong, ZHAO Xiqiang, WANG Wenlong, MAO Yanpeng, SUN Jing

Shandong University National Engineering Lab for Coal-fired Pollutants Emission Reduction, Shandong Provincial Key Lab of Energy Carbon Reduction and Resource Utilization, Ji'nan 250061, Shandong, China

Received:2019-06-20 Revised:2019-07-30 Online:2019-11-16 Published:2019-11-16

热风和微波干燥对煤泥品质的影响

闫业成, 井传明, 宋占龙, 赵希强, 王文龙, 毛岩鹏, 孙静

山东大学燃煤污染物减排国家工程实验室, 山东省能源碳减排技术与资源化利用重点实验室, 山东济南 250061

通讯作者: 宋占龙,教授,博士生导师,研究方向为废物资源化利用。
作者简介:闫业成(1991-),男,硕士研究生,研究方向为燃煤污染物减排。E-mail:201734086@mail.sdu.edu.cn。
基金资助:
国家自然科学基金（U1361113）。

Abstract

Abstract: The coal slime was dried by hot air and microwave, and the dried slime products were analyzed from the main component content, combustion characteristics and moisture resorption characteristics. The change of the main component content of the coal slime before and after drying was compared by industrial analysis. It was found that there was no significant change in the volatile matter, ash and fixed carbon content of the coal slime during the drying process. The combustion characteristics of the raw coal slime and the dried products of the two slime were studied by thermogravimetric analysis. It was found that the thermogravimetric curves of the three coal slime samples are not significantly different except for the dehydration stage, and the combustion characteristics of the three samples are very close. Finally, the water resorption characteristics of the two coal slime drying products were investigated. It was found that the environmental humidity and the moisture content of the slime have a significant effect on the water resorption characteristics, while the drying method has no obvious effect on the water resorption characteristics.

Key words: coal slime, combustion characteristics, moisture resorption, microwave drying, hot air drying

摘要： 采用热风和微波两种方式对煤泥进行干燥处理，从主要组分、燃烧特性和水分复吸特性等方面对煤泥干燥产品进行了分析。通过工业分析对比了干燥前后煤泥主要组分的变化，发现两种煤泥干燥过程中煤泥的挥发分、灰分和固定碳含量没有明显变化。采用热重分析研究了原煤泥和两种煤泥干燥产品的燃烧特性，发现除了失水阶段，3种煤泥样品的热重曲线没有较大差异，3种样品的燃烧特性指数十分接近。最后探究了两种干燥方式下煤泥干燥产品的水分复吸特性，发现环境湿度和煤泥含水率对水分复吸特性有显著影响，而干燥方式对水分复吸特性影响并不明显。

关键词: 煤泥, 燃烧特性, 水分复吸, 微波干燥, 热风干燥

CLC Number:

TD926

YAN Yecheng, JING Chuanming, SONG Zhanlong, ZHAO Xiqiang, WANG Wenlong, MAO Yanpeng, SUN Jing. Effect of hot air and microwave drying on the quality of coal slime[J]. Chemical Industry and Engineering Progress, 2019, 38(s1): 122-127.

闫业成, 井传明, 宋占龙, 赵希强, 王文龙, 毛岩鹏, 孙静. 热风和微波干燥对煤泥品质的影响[J]. 化工进展, 2019, 38(s1): 122-127.

References

[1] SONG Z L, JING C M, YAO L S, et al. Microwave drying performance of single-particle coal slime and energy consumption analyses[J]. Fuel Processing Technology, 2016, 143:69-78.
[2] 张晓婉, 龚德鸿. 煤泥燃烧产品析出特性的热重-质谱联用分析[J]. 热能动力工程, 2019(5):77-83. ZHANG X W, GONG D H. Analysis of precipitation characteristics of coal slime combustion products by TG-MS[J]. Journalof Engineering for Thermal Energy and Power, 2019(5):77-83.
[3] FU B A, CHEN M Q, SONG J J. Investigation on the microwave drying kinetics and pumping phenomenon of lignite spheres[J]. Applied Thermal Engineering, 2017, 124:371-380.
[4] SONG Z L, YAO L L, JING C M, et al. Elucidation of the pumping effect during microwave drying of lignite[J]. Industrial &Engineering Chemistry Research, 2016, 55(11):3167-3176.
[5] SONG Z L, YAO L L, JING C M. Experimental study on the characteristics of ignition during microwave drying of lignite[J]. Energy Technology, 2016, 4(9):76.
[6] YANG J C, XIAO L, XU L H, et al. Experiment study on lignite dewatering base on microwave technology[J]. Coal Enginnering, 2012, 9:93-97.
[7] AMER M, NOUR M, AHMED M, et al. The effect of microwave drying pretreatment on dry torrefaction of agricultural biomasses[J]. Bioresource Technology, 2019, 286:121400.
[8] WANG Q, LI S, HAN X, et al. Quality evaluation and drying kinetics of shitake mushrooms dried by hot air,infrared and intermittent microwave-assisted drying methods[J]. Food Science and Technology, 2019, 107:236-242.
[9] XI B, LIU X R. Research on microwave-drying technology and equipment for drying coal slime[J]. Coal Preparation Technology, 2011, 6:23-25.
[10] SONG Z L, JING C M, Yao L S, et al. Coal slime hot air/microwave combined drying characteristics and energy analysis[J]. Fuel Processing Technology, 2017, 156:491-499.
[11] LIAO J, MO Q, LI C, et al. Classification of water forms in lignite and analysis of energy consumption on the drying processesby microwave and fixed bed[J]. Fuel, 2019, 253:580-587.
[12] FENG G. Comparison of microwave drying and conventional drying of coal[D]. Belfast:Queen's University, 2010.
[13] WANG A Y, CHENG J, LIU J Z. Effect of microwave on drying and slurryability of lignite[J]. Energy Engineering, 2012(1):1-5.
[14] 高正阳, 李晋达, 范元周, 等. 褐煤预干燥对锅炉传热特性及运行经济性的影响[J]. 动力工程学报, 2014, 34(3):182-188. GAO Z Y, LI J D, FAN Y Z, et al. Influence of lignite dryness on heat transfer and operation economy of power boilers[J]. Chinese Journal of Power Engineering, 2014, 34(3):182-188.
[15] KÖK M V. Temperature-controlled combustion and kinetics of different rank coal samples[J]. Journal of Thermal Analysis & Calorimetry, 2005, 79(1):175-180.
[16] BRYDEN K, KONG S C, RAGLAND K W. Combustion engineering[M]. 2nd ed. Abingdon:Taylor and Francis, 2018:351.
[17] LI Q, ZHAO C, CHEN X, et al. Comparison of pulverized coal combustion in air and in O₂/CO₂ mixtures by TG analysis[J]. Journal of Analytical and Applied Pyrolysis, 2009, 85(1):521-528.
[18] GUO L, ZHAI M, WANG Z, et al. Comparison of bituminous coal and lignite during combustion:combustion performance coking and slagging characteristics[J]. Journal of the Energy Institute, 2019, 92(3):802-812.
[19] 徐志强, 杨虓, 任阳光, 等. 微波提质褐煤复吸特性的试验研究[J]. 煤炭学报, 2015, 40(s2):486-490. XU Z Q, Y X, RENG Y G, et al. Experimental study on the re-adsorption characteristics of microwave upgraded lignite[J]. Journal of China Coal Society, 2015, 40(s2):486-490.
[20] LI X C, SONG H, WANG Q, et al. Experimental study on drying and moisture re-adsorption kinetics of an Indonesian low rank coal[J]. Journal of Environmental Sciences, 2009, 21(9):127-130.
[21] 杨蛟洋, 朱林丰. 微波干燥褐煤复吸特性研究[J]. 煤炭工程, 2017, 49(7):122-125. YANG J Y, ZHU L F. Study on moisture re-adsorption property of microwave-dehydrated lignite[J]. Coal Engineering, 2017, 49(7):122-125.

Effect of hot air and microwave drying on the quality of coal slime

热风和微波干燥对煤泥品质的影响

PDF (PC)

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 8

Recommended Articles

Metrics

Comments

[1]	ZHENG Xin, JIA Li, WANG Yanlin, ZHANG Jingchao, CHEN Shihu, QIAO Xiaolei, FAN Baoguo. Effect of sewage sludge mixed with coal slime on heavy metal retention characteristics [J]. Chemical Industry and Engineering Progress, 2023, 42(6): 3233-3241.
[2]	WANG Guangyu, MENG Jinghui, ZHANG Kai. Simulation of intermittent microwave drying of coal slime and dielectric properties [J]. Chemical Industry and Engineering Progress, 2023, 42(4): 1779-1786.
[3]	FU Chunlong, WANG Songjiang, LI Guozhi. Research progress on combustion technology of coal gasification fine slag [J]. Chemical Industry and Engineering Progress, 2022, 41(S1): 516-523.
[4]	GUO Jinrong, CHENG Peng, JIA Li, GUO Jingnan, WANG Yanlin, ZHANG Yongqiang, QIAO Xiaolei, FAN Baoguo. Combustion characteristics and mercury emission characteristics of high sulfur coal slime [J]. Chemical Industry and Engineering Progress, 2021, 40(S2): 411-420.
[5]	XUE Xingqiao, FENG Yu, JIN Lijun, HU Haoquan. Combustion characteristics of pyrolysis char of Buliangou coal [J]. Chemical Industry and Engineering Progress, 2017, 36(09): 3287-3292.
[6]	HOU Kang, WU Jianjun, SHANG Xiaoling, ZHANG Yixin. Experimental study on effects of stepwise removal of minerals on the combustion characteristics of lignites by TG/DTG [J]. Chemical Industry and Engineering Progress, 2017, 36(03): 900-908.
[7]	BAI Jingru1，LI Xiaohang1，GENG Shaoyun1，WANG Qing1，LIU Bin2. Investigation on isothermal drying mechanism of Yaojie oilshale [J]. Chemical Industry and Engineering Progree, 2014, 33(01): 75-79.
[8]	RU Saihong1，ZENG Hui2，FANG Yanxiong1，JI Hongbing2. Effect of microwave drying and hot air drying on quality of Jin Xuan tea [J]. Chemical Industry and Engineering Progree, 2012, 31(10): 2183-2186.