Experimental study of mechanical vapor recompression of heat pump driven by roots compressor

doi:10.16085/j.issn.1000-6613.2015.06.016

Chemical Industry and Engineering Progree ›› 2015, Vol. 34 ›› Issue (06): 1602-1606,1612.DOI: 10.16085/j.issn.1000-6613.2015.06.016

Previous Articles Next Articles

Experimental study of mechanical vapor recompression of heat pump driven by roots compressor

GU Chengzhen¹, HONG Housheng^1,2, ZHANG Zhiqiang¹, YAN Xu¹

1 College of Life Science and Pharmaceutical Engineering, Nanjing Technology University, Nanjing 211816, Jiangsu, China;
2 Nanjing Huike Bioengineering Equipment Corporation, Nanjing 210009, Jiangsu, China

Received:2014-10-31 Revised:2014-11-14 Online:2015-06-05 Published:2015-06-05

罗茨压缩机驱动MVR热泵系统的实验研究

顾承真¹, 洪厚胜^1,2, 张志强¹, 颜旭¹

1 南京工业大学生物与制药工程学院, 江苏南京 211816;
2 南京汇科生物工程设备有限公司, 江苏南京 210009

通讯作者: 洪厚胜,教授,硕士生导师,主要从事生物过程装备研究。E-mail:hhs@njut.edu.cn。
作者简介:顾承真(1986—),男,硕士研究生,主要从事生物过程装备研究。E-mail:guchengzhenadu@yeah.net。

Abstract

Abstract: Mechanical vapor recompression(MVR) evaporation system is a new energy efficient evaporation technology. This paper established a set of MVR evaporator device using water as raw material, falling-film evaporator as evaporating body, and roots compressor as steam compressors. This paper investigated the effects of feed temperature, evaporation pressure and compressor frequency on the evaporation of the total amount of water and specific moisture extraction rate(SMER), which is considered performance indicator of MVR. The results showed that the optimum temperature of the feed was the saturated liquid temperature at the evaporator pressure;the optimum evaporation pressure was closely related to evaporation capacity and compressor efficiency in specific systems;lower the evaporator pressure was beneficial to energy saving when maintaining a high level of efficiency of the compressor;frequency of the compressor directly affected evaporation of the total amount of water and compressor power; SMER increased with the increase of the frequency of the compressor within the allowable range.

Key words: mechanical vapor recompression(MVR), feed temperature, evaporation pressure, compressor frequency

摘要： 机械蒸汽再压缩(MVR)蒸发系统是一种高效节能的蒸发体系。本文采用降膜蒸发器为蒸发主体、罗茨压缩机为蒸汽压缩机, 并以水为实验原料研究了一套MVR蒸发装置。实验中以总蒸发水量和单位能耗蒸发水量(SMER)作为MVR蒸发系统的性能指标, 分别研究了进料温度、蒸发压强、压缩机频率对其影响。结果表明:最佳进料温度是蒸发压强下的饱和液体温度;最适蒸发压强与具体系统的蒸发能力和压缩机效率密切有关, 在压缩机效率保持较高水平的前提下, 适当降低蒸发压强有利于系统的节能;压缩机的频率直接影响系统的蒸发量和压缩机的功耗, 在压缩机允许的范围内增大压缩机频率, 单位能耗蒸发量是增加的。

关键词: 机械蒸汽再压缩, 进料温度, 蒸发压强, 压缩机频率

CLC Number:

TQ51

GU Chengzhen, HONG Housheng, ZHANG Zhiqiang, YAN Xu. Experimental study of mechanical vapor recompression of heat pump driven by roots compressor[J]. Chemical Industry and Engineering Progree, 2015, 34(06): 1602-1606,1612.

顾承真, 洪厚胜, 张志强, 颜旭. 罗茨压缩机驱动MVR热泵系统的实验研究[J]. 化工进展, 2015, 34(06): 1602-1606,1612.

References

[1] 杨德明, 叶梦飞, 杜鹏, 等. 基于 MVR 热泵精馏的乙醇-异丙醇分离工艺[J]. 化工进展, 2014, 33(5):1344-1347.
[2] Edmundas Zavadskas, Raslanas Saulius, Kaklauskas Artūras. The selection of effective retrofit scenarios for panel houses in urban neighborhoods based on expected energy savings and increase in market value:The Vilnius case[J]. Energy and Buildings, 2008, 40(4):573-587.
[3] 顾承真, 闵兆升, 洪厚胜. 机械蒸汽再压缩蒸发系统的性能分析[J]. 化工进展, 2014, 33(1):30-35 .
[4] 常志勇. 浅谈机械蒸汽再压缩制盐技术在钙型卤水中的应用[J]. 化工设计, 2012, 22(5):15-16.
[5] Shen J, Xing Z, Wang X, et al. Analysis of a single-effect mechanical vapor compression desalination system using water injected twin screw compressors[J]. Desalination. 2014, 333(1):146-153.
[6] 李清方, 刘中良, 韩冰, 等. 基于热力蒸汽压缩蒸发的油田污水淡化系统及分析[J]. 化工学报, 2012, 63(6):1859-1864.
[7] 顾承真, 洪厚胜, 颜旭, 等. 罗茨压缩机驱动MVR热泵系统的节点分析[J]. 现代化工, 2014, 34(4):125-129.
[8] Wu H, Li Y, Chen J. Research on an evaporator-condenser-separated mechanical vapor compression system[J]. Desalination, 2013, 324:65-71.
[9] 孙钦鹤. 多效精馏和热泵技术用于低浓度废水处理的研究[D]. 青岛:中国海洋大学, 2012.
[10] 庞卫科, 林文野, 戴群特, 等. 机械蒸汽再压缩热泵技术研究进展[J]. 节能技术, 2012, 30(4):312-315.
[11] Tuan C, Cheng Y, Yeh Y, et al. Performance assessment of a combined vacuum evaporator-Mechanical vapor re-compression technology to recover boiler blow-down wastewater and heat[J]. Sustain.Environ.Res., 2013, 23(2):139
[12] Kansha Yasuki, Tsurn Naoki, Sato Kazuyoshi, et al. Self-heat recuperation technology for energy saving in chemical processes[J]. Industrial & Engineering Chemistry Research, 2009, 48(16):7682-7686.
[13] 韩东, 顾昂, 岳晨, 等. 可用于MVR蒸发系统的气液分离器改进结构分析[J]. 化工学报, 2012, 63(2):508-515.
[14] 高丽丽, 张琳, 杜明照. MVR蒸发与多效蒸发技术的能效对比分析研究[J]. 现代化工, 2012, 32(10):84-86.
[15] 陈涛, 李宁, 晏波, 等. 稀土湿法冶炼废水污染治理技术与对策[J]. 化工进展, 2014, 33(5):1306-1311.
[16] Ben Mansour R, Ouzzane M, Aidoun Z. Numerical evaluation of ejector-assisted mechanical compression systems for refrigeration applications[J]. International Journal of Refrigeration, 2014, 43:36-49.
[17] 梁林, 韩东. 蒸汽机械再压缩蒸发器的实验[J]. 化工进展, 2009, 28(s1):358-360.
[18] 焦冬生. 机械压汽蒸馏技术的实验应用与仿真研究[D]. 合肥:中国科学技术大学, 2012.
[19] Uday Bhaskar Babu G, Jana A K. Impact of vapor recompression in batch distillation on energy consumption, cost and CO₂ emission:Open-loop versus closed-loop operation[J]. Applied Thermal Engineering, 2014, 62(2):365-374.
[20] 庞卫科, 林文举, 潘麒麟, 等. 离心风机驱动机械蒸汽再压缩热泵系统的性能分析[J]. 机械工程学报, 2013, 49(12):142-146.
[21] 席光, 周莉, 丁海萍, 等. 叶片扩压器进口安装角对离心压缩机性能影响的数值与实验研究[J]. 工程热物理学报, 2006, 27(1):61-64.
[22] Alexander K, Donohue B, Feese T, et al. Failure analysis of an MVR (mechanical vapor recompressor) Impeller[J]. Engineering Failure Analysis, 2010, 17(6):1345-1358.
[23] Liang L, Han D, Ma R, et al. Treatment of high-concentration wastewater using double-effect mechanical vapor recompression[J]. Desalination, 2013, 314:139-146.
[24] 赵博, 马国远, 许树学. 水蒸汽再压缩热泵系统的性能分析[J]. 制冷技术, 2012(2):29-32.
[25] 郝冬青, 沙作良, 王彦飞, 等. 低温多效海水淡化系统的Aspen Plus模拟[J]. 天津科技大学学报, 2011, 26(1):47-50.
[26] Sassner Per, Mats Galbe, Guido Zacchi. Techno-economic evaluation of bioethanol production from three different lignocellulo sic materials[J]. Biomass and Bioenergy, 2008, 32(5):422-430.
[27] 沈维道, 蒋智敏, 童钧耕. 工程热力学[M]. 北京:高等教育出版社, 2001.

Experimental study of mechanical vapor recompression of heat pump driven by roots compressor

罗茨压缩机驱动MVR热泵系统的实验研究

PDF (PC)

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 6

Recommended Articles

Metrics

Comments

[1]	JIANG Hua, ZHANG Zihui, GONG Wuqi, CHANG Yueyong. Design and performance analysis of mechanical vapor recompression salt fractionation evaporation crystallization system [J]. Chemical Industry and Engineering Progress, 2022, 41(7): 3947-3956.
[2]	Hua JIANG,Ziyao ZHANG,Wuqi GONG. Design and research of MVR parallel double-effect evaporation crystallization system [J]. Chemical Industry and Engineering Progress, 2019, 38(10): 4461-4469.
[3]	Kuan HE,Jianhua LIU,Liang ZHANG,Xiaoxiao YU. Evaporation pressure drop characteristics of R404Ain 5mm microfin tube [J]. Chemical Industry and Engineering Progress, 2019, 38(08): 3548-3555.
[4]	HONG Yongqiang, CHEN Guifang, MAO Yanpeng, MA Chunyuan. Distillation characteristics of wet flue gas desulfurization serosity [J]. Chemical Industry and Engineering Progree, 2016, 35(08): 2561-2568.
[5]	YANG Deming, TAN Jiankai, WANG Ying, JIANG Yu, GAO Xiaoxin. Heat integrated separation technology for separating mixed alcohol based on the MVR heat-pump distillation [J]. Chemical Industry and Engineering Progree, 2015, 34(11): 4120-4125.
[6]	ZHANG Lin, JIANG feng, LU Kaijie, XU Chen, CUI Tengfei, ZHAO Feng, JI Jiachao. Comparison and analysis of the performances in MVR steam Roots blower [J]. Chemical Industry and Engineering Progree, 2015, 34(06): 1550-1556.