Improved multi-stage A/O-MBR combination process for removal of phosphorus of low C/N ratio domestic sewage

doi:10.16085/j.issn.1000-6613.2020-0874

Abstract

Abstract:

When the low-C/N ratio domestic sewage is treated by the multi-stage A/O-MBR combination process, there is a problem that the TP removal rate is low. The removal of the phosphorus is enhanced by the improved multi-stage A/O-MBR combination process of increasing internal reflux. The removal effect of modified multi-stage A/O-MBR combination process on TP in low C/N ratio domestic sewage was studied. The mechanism of removal of modified multi-stage A/O-MBR combined process sludge denitrifying phosphorus was investigated by static analysis of sludge. The results showed that the improved multi-stage A/O-MBR combination process had good TP removal efficiency with the average removal rate of 86.36%. At the same time, the effects of COD, TN and nitrogen removal were good, and all reached the first-class A emission standard. The proportion of polyphosphate bacteria and denitrifying phosphorus accumulating bacteria were increased by the improved multi-stage A/O-MBR combination process, and the removal effect of TP by the combined process was strengthened.

Key words: multi-level A/O-MBR, domestic sewage, low C/N ratio, denitrifying phosphorus removal

摘要：

采用多级厌氧/耗氧膜生物反应器（A/O-MBR）组合工艺对低C/N比生活污水进行处理时，存在总磷（TP）处理不达标的问题。通过改变污泥回流位置并增加内回流的改良型多级A/O-MBR组合工艺强化除磷，探究该工艺对低C/N比生活污水中TP的去除效果，并通过污泥静态分析研究其污泥反硝化除磷机理。结果表明，改良型多级A/O-MBR组合工艺对TP去除效果良好，平均去除率达到了86.36%，同时对化学需氧量（COD）、总氮（TN）及氨氮去除效果良好，均达到一级A排放标准。该工艺提高了聚磷菌及反硝化聚磷菌的比例，有效强化了对TP的去除。

关键词: 多级厌氧/耗氧膜生物反应器, 生活污水, 低C/N比, 反硝化除磷

CLC Number:

X703

ZHENG Kai, ZHANG Zixian, WU Yong, WANG Wanhong, WU Fuping. Improved multi-stage A/O-MBR combination process for removal of phosphorus of low C/N ratio domestic sewage[J]. Chemical Industry and Engineering Progress, 2021, 40(3): 1675-1680.

郑凯, 张子贤, 吴勇, 王万红, 武福平. 改良型多级A/O-MBR组合工艺对低C/N比生活污水的强化除磷[J]. 化工进展, 2021, 40(3): 1675-1680.

Figures/Tables 7

References 24

1	易建婷, 张成, 徐凤, 等. 全国投运城镇污水处理设施现状与发展趋势分析[J]. 环境化学, 2015, 34(9): 1654-1660.
	YI Jianting, ZHANG Cheng, XU Feng, et al. The status and developing trend of municipal sewage treatment plants in China[J]. Environmental Chemistry, 2015, 34(9): 1654-1660.
2	刘智晓, 崔福义, 丁雷, 等. 中小城镇高效低耗污水处理工艺的选择[J]. 给水排水, 2006, 32(4): 32-37.
	LIU Zhixiao, CUI Fuyi, DING Lei, et al. Selection of high-efficiency and low-consumption wastewater treatment technology[J]. Water & Wastewater Engineering, 2006, 32(4): 32-37.
3	王涛, 楼上游. 中国城市污水处理工艺现状调查与技术经济指标评价[J]. 给水排水, 2004, 30(5): 6-9.
	WANG Tao, LOU Shangyou. Investigation on the status quo of urban wastewater treatment technology in China and evaluation of technical and economic indexes[J]. Water & Wastewater Engineering, 2004, 30(5): 6-9.
4	张冰, 周雪飞, 任南琪, 等. 新型城市污水脱氮除磷工艺的试验研究与优化设计[J]. 环境科学, 2008, 33(6): 1518-1525.
	ZHANG Bing, ZHOU Xuefei, REN Nanqi, et al. Novel phosphorus and nitrogen removal process for municipal sewage treatment: performance evaluation and design optimization[J]. Environmental Science, 2008, 33(6): 1518-1525.
5	易鹏, 张树军, 甘一萍, 等. 城市污水三污泥系统自养脱氮与强化生物除磷[J]. 环境科学, 2010, 31(10): 2390-2397.
	YI Peng, ZHANG Shujun, GAN Yiping, et al. Autotrophic nitrogen removal and enhanced biological phosphorus removal from municipal wastewater in a three-sludge system[J]. Environmental Science, 2010, 31(10): 2390-2397.
6	SUN Shengpeng, NÀCHER C P I, MERKEY B, et al. Effective biological nitrogen removal treatment processes for domestic wastewaters with low C/N ratios: a review[J]. Environmental Engineering Science, 2010, 27(2): 111-126.
7	高小波. 改良型多级A/O工艺处理低碳源生活污水试验研究[D]. 兰州: 兰州交通大学, 2016.
	GAO Xiaobo. Experimental study on treatment of low-carbon sewage by modified multi-stages A/O process[D]. Lanzhou: Lanzhou Jiaotong University, 2016.
8	BOELEE N C, TEMMINK H, JANSSEN M, et al. Nitrogen and phosphorus removal from municipal wastewater effluent using microalgal biofilms[J]. Water Research, 2011, 45(18): 5925-5933.
9	李权, 王少坡, 王舜和, 等. 不同碳氮比下分段进水多级A/O耦合MBR工艺的脱氮除磷性能研究[J]. 天津城建大学学报, 2018, 24(4): 298-302.
	LI Quan, WANG Shaopo, WANG Shunhe, et al. The nitrogen and phosphorus removal of multilevel A/O step-feed process combine with membrane bioreactor under the different C/N ratio[J]. Journal of Tianjin Chengjian University, 2018, 24(4): 298-302.
10	王之晖, 宋乾武, 王文君, 等. 组合MBR工艺中试系统处理高氨氮生活污水[J]. 环境科学研究, 2010, 23(12): 1535-1540.
	WANG Zhihui, SONG Qianwu, WANG Wenjun, et al. Pilot study on combined MBR process for treatment of domestic wastewater with high ammonia nitrogen concentration[J]. Research of Environmental Sciences, 2010, 23(12): 1535-1540.
11	李子富, 云玉攀, 曾灏, 等. 城市污水处理厂化学强化生物除磷的试验研究[J]. 中国环境科学, 2014, 34(12): 3070-3077.
	LI Zifu, YUN Yupan, ZENG Hao, et al. Experimental study on chemically enhanced biological phosphorus removal for municipal wastewater treatment plant[J]. China Environmental Science, 2014, 34(12): 3070-3077.
12	WANG D, LI X, YANG Q, et al. Improved biological phosphorus removal performance driven by the aerobic/extended -idle regime with propionate as the sole carbon source[J]. Water Research, 2012, 46(12): 3868.
13	KUBA T, SMOLDERS G, LOOSDRECHT M C M VAN. Biological phosphorus removal from wastewater by anaerobic-anoxic sequencing batch reactor[J]. Water Science & Technology, 1993, 27(5/6): 241-252.
14	李楠. 生物除磷影响因素的研究[D]. 哈尔滨: 哈尔滨工业大学, 2006.
	LI Nan. Factors affecting BPR performance[D]. Harbin: Harbin Institute of Technology, 2006.
15	王晓莲, 王淑莹, 彭永臻. 进水C/P比对A²/O工艺性能的影响[J]. 化工学报, 2005, 56(9): 765-1770.
	WANG Xiaolian, WANG Shuying, PENG Yongzhen. Effects of feed water C/P ratio on performance of anaerobic-anoxic-oxic process[J]. CIESC Journal, 2005, 56(9): 765-1770.
16	孟维苹, 唐文涛. 反硝化聚磷菌在低碳源城市污水脱氮除磷处理中的应用[J]. 环境科学与技术, 2016, 39(7): 91-95.
	MENG Weiping, TANG Wentao. Application of DPBs in the treatment of phosphorus and nitrogen removal in municipal sewage with low carbon source[J]. Environmental Science & Technology, 2016, 39(7): 91-95.
17	孙慧智, 王惊, 王嘉毅. 反硝化除磷工艺及机理研究[J]. 科学技术创新, 2018, 22(2): 148-150.
	SUN Huizhi, WANG Jing, WANG Jiayi. Study on denitrification process and mechanism of phosphorus removal[J]. Scientific and Technological Innovation, 2018, 22(2): 148-150.
18	WACHTMEISTER A, KUBA T, LOOSDRECHT M C M VAN, et al. A sludge characterization assay for aerobic and denitrifying phosphorus removing sludge[J]. Water Research, 1997, 31(3): 471-478.
19	MEINHOLD J, FILIPE C D M, DAIGGER G T, et al. Characterization of the denitrifying fraction of phosphate accumulating organisms in biological phosphate removal[J]. Water Science & Technology, 1999, 39(1): 31-42.
20	王亚宜, 彭永臻, 王淑莹, 等. 反硝化除磷理论、工艺及影响因素[J]. 中国给水排水, 2003, 19(1): 33-36.
	WANG Yayi, PENG Yongzhen, WANG Shuying, et al. Theory, technology and influence factors of denitrification and phosphorus[J]. China Water & Wastewater, 2003, 19(1): 33-36.
21	陈鹏, 张克峰. 反硝化除磷机理与工艺研究进展[J]. 水处理技术, 2009, 35(9): 1-5.
	CHEN Peng, ZHANG Kefeng. Development of denitrifying phosphorus removal mechanisms and process[J]. Technology of Water Treatment, 2009, 35(9): 1-5.
22	Dae Sung LEE, JEON Che Ok, PARK Jong Moon. Biological nitrogen removalwith enhanced phosphate uptake in a sequencing batchreactor using single sludge system[J]. Water Research, 2002, 35(16): 3968-3976.
23	李勇智, 彭永臻, 张艳萍, 等. 硝酸盐浓度及投加方式对反硝化除磷的影响[J]. 环境污染与防治, 2003, 25(6): 323-325.
	LI Yongzhi, PENG Yongzhen, ZHANG Yanping, et al. Effect of nitrate on denitrifying dephosphatation[J]. Environmental Pollution & Control, 2003, 25(6): 323-325.
24	侯红勋, 彭永臻, 殷芳芳, 等. NO2-作为电子受体对反硝化吸磷影响动力学研究[J]. 环境科学, 2008, 33(7): 116-121.
	HOU Hongxun, PENG Yongzhen, YIN Fangfang, et al. Inhibitory effect kinetics of nitrite acting as electron acceptor on anoxic phosphorus uptake and denitrification[J]. Environmental Science, 2008, 33(7): 116-121.

[1]	WU Xinbo, DANG Hongzhong, MA Jiao, YAN Yuan, ZENG Tianxu, LI Weiwei, ZHANG Guozhen, CHEN Yongzhi. Effect of denitrifying phosphorus removal under short-cut nitrification mode with A²/O-BAF process [J]. Chemical Industry and Engineering Progress, 2023, 42(2): 1089-1097.
[2]	LI Dong, GAO Xin, YANG Jie, CHEN Hao, ZHANG Jie. Achieving shortcut nitrification and denitrification phosphorus removal relies on long/short HRT combined with a low/high aeration strategy [J]. Chemical Industry and Engineering Progress, 2022, 41(11): 6111-6119.
[3]	Hongwei WANG, Guozhen ZHANG, Fuping WU, Ju MING, Rui MIN, Wan’er YAN, Jin CHENG. Study on enhanced phosphorus removal effect of improved multi-stage A/O on low C/N domestic sewage [J]. Chemical Industry and Engineering Progress, 2020, 39(S2): 379-384.
[4]	Chao ZHANG, Xujun SHI, Guozhen ZHANG, Fuping WU, Wenwen YAN, Xingxing HUANG. Effect of elastic filler on heavy metals removal and granular sludge by ABR [J]. Chemical Industry and Engineering Progress, 2020, 39(7): 2858-2866.
[5]	Jiamin WEI, Wenru LIU, Jiehong CHENG, Yaoliang SHEN. Influencing factors of denitrifying phosphorus removal and advance research on novel process of coupling PAOs and GAOs [J]. Chemical Industry and Engineering Progress, 2020, 39(11): 4608-4618.
[6]	Jie HU,Jiabao YAN,Xiaoqiong HUO,Meiling CHEN,Chao LI. Screening and nitrification characteristics of heterotrophic nitrification-aerobic denitrification bacteria with low C/N ratio [J]. Chemical Industry and Engineering Progress, 2019, 38(03): 1567-1572.
[7]	CHU Jiansong, ZHANG Chuanyi, WU Qiwei, HE Shilong, MAO Zhen, SUN Dongxu, YUAN Limei. Alternate anaerobic/anoxic-aerobic double membrane denitrifying phosphorus removing process [J]. Chemical Industry and Engineering Progree, 2016, 35(03): 935-943.
[8]	YAN Lilong1，HAO Guoxin1，LIU Yu1，WEN Yan1，WU Zujing1，CHEN Yiyang1，ZHANG Yingmin2. Analysis of removal efficiency of SBR on rural sewage with rice husk as carrier [J]. Chemical Industry and Engineering Progree, 2014, 33(09): 2484-2488.
[9]	LIU Peng，CHEN Yinguang. Progress of new biological nutrient removal technologies [J]. Chemical Industry and Engineering Progree, 2013, 32(10): 2491-2496.
[10]	HOU Jinliang；KANG Yong. Research progress of biological removal of nitrogen and phosphorus in municipal sewage [J]. Chemical Industry and Engineering Progree, 2007, 26(3): 366-.