牡蛎壳改性材料及其吸附多氯联苯的性能

doi:10.16085/j.issn.1000-6613.2017.05.030

化工进展 ›› 2017, Vol. 36 ›› Issue (05): 1802-1810.DOI: 10.16085/j.issn.1000-6613.2017.05.030

牡蛎壳改性材料及其吸附多氯联苯的性能

范立维¹, 周华¹, 卢泽湘², 熊丽凤¹, 海热提³

1. 福建省土壤环境健康与调控重点实验室, 福建农林大学资源与环境学院, 福建福州 350002;
2. 福建农林大学材料工程学院, 福建福州 350002;
3. 北京化工大学环境科学与工程技术中心, 北京 100029

收稿日期:2016-10-08 修回日期:2016-12-23 出版日期:2017-05-05 发布日期:2017-05-05
通讯作者: 范立维(1980-),女,博士,副教授,主要从事环境污染控制与修复。
作者简介:范立维(1980-),女,博士,副教授,主要从事环境污染控制与修复。E-mail:fanlw@163.com。
基金资助:
福建省自然科学基金（2014J011430）及福建农林大学校重点项目（06085C07F）

Modified oyster shell material and its PCBs adsorption characteristics

FAN Liwei¹, ZHOU Hua¹, LU Zexiang², XIONG Lifeng¹, HAI Reti³

1. Fujian Provincial Key Laboratory of Soil Environmental Health and Regulation, College of Resource and Environment, Fujian Agriculture and Forestry University, Fuzhou 350002, Fujian, China;
2. College of Material Engineering, Fujian Agriculture and Forestry University, Fuzhou 350002, China;
3. Center of Environmental Science and Engineering Technology, Bejing University of Chemical Technology, Beijing 100029, China

Received:2016-10-08 Revised:2016-12-23 Online:2017-05-05 Published:2017-05-05

摘要/Abstract

摘要： 以硫酸亚铁为铁源，通过硼氢化钾原位还原-负载制得纳米铁改性牡蛎壳材料，并对其微观结构进行表征，探讨改性后的牡蛎壳材料对持久性有机物多氯联苯（PCBs）的吸附性能。实验结果表明：改性牡蛎壳材料中纳米铁颗粒粒径均匀且分散度较高，改性后的牡蛎壳材料具有很好的PCBs废水处理能力；当处理时间为180min，溶液温度和初始PCBs浓度分别为25℃和5mg/L时，改性材料对PCBs的吸附率达96%，吸附量为2.97mg/g。改性材料可作为一种廉价、高效的持久性有机废水吸附剂，具有很好的工业应用前景。吸附等温线研究表明，Langmuir方程能较好地描述改性材料的PCBs吸附行为，吸附较容易，升高温度有利于吸附；从吸附动力学角度分析，吸附过程符合准二级动力学模型（R²>0.99），以化学吸附为主，吸附速率由表面扩散与颗粒内扩散联合控制。

关键词: 牡蛎壳, 改性材料, 多氯联苯, 吸附, 动力学

Abstract: With ferrous sulfate as the source of iron,the nano iron modified oyster shell material was prepared by the in-situ potassium borohydride reduction. The microstructure of the modified oyster shell material was characterized and its persistent organic adsorption performance of polychlorinated biphenyl (PCBs) was discussed. The experimental results showed that the particle size of nano iron in the modified oyster shell was uniform and had high degree of dispersion;the modified oyster shell material had excellent PCBs wastewater treatment performance. The PCBs adsorption rates of the modified oyster shell material could reach 96% and the adsorption amount is 2.97mg/g at the suitable reaction conditions:the solution temperature of 25℃,the initial PCBs concentration of 5mg/L,and the reaction time of 180min. These results clearly indicated that the modified material had good industrial application prospect as a low-cost and efficient adsorbent for treatment of persistent organic wastewater. Adsorption isotherm researches showed that the equilibrium data were found to follow the Langmuir adsorption isotherm closely. The adsorption was easy to implementand the increment of temperature was helpful to the adsorption. Analyzing from the point of the adsorption kinetics,the adsorption process conforms to pseudo-second-order equation (R²>0.99) ;the chemical adsorption was the main process; the adsorption rate was controlled by both the external diffusion and internal diffusion.

Key words: oyster shell, modified material, PCBs, adsorption, kinetics

中图分类号:

X703.1

范立维, 周华, 卢泽湘, 熊丽凤, 海热提. 牡蛎壳改性材料及其吸附多氯联苯的性能[J]. 化工进展, 2017, 36(05): 1802-1810.

FAN Liwei, ZHOU Hua, LU Zexiang, XIONG Lifeng, HAI Reti. Modified oyster shell material and its PCBs adsorption characteristics[J]. Chemical Industry and Engineering Progress, 2017, 36(05): 1802-1810.

参考文献

[1] UENO D,TAKAHASHI S,TANAKA H,et al. Global pollution monitoring of PCBs and organochlorine pesticides using skipjack tuna as a bioindicator[J]. Archives of Environmental Contamination and Toxicology,2003,45(3):378-389.
[2] SROGI K. Levels and congener distributions of PCDDs,PCDFs and dioxin-like PCBs in environmental and human samples:a review[J]. Environmental Chemistry Letters,2008,6(1):1-28.
[3] PERSON C,HORNBUCKLE K C. Calculation of passive sampling rates from both native PCBs and depuration compounds in indoor and outdoor environments[J]. Chemosphere,2009,74(7):917-923.
[4] 李硕文. 活性炭吸附H₂O₂氧化法处理染色废水的试验研究[J]. 化工环保,1997,17(3):131-134. LI S W. Study on the treatment of dyeing wastewater by activated carbon adsorption H₂O₂ oxidation process[J].Environmental Protection of Chemical Industry,1997,17(3):131-134.
[5] 戚建华,梁宗锁,邓西平,等. 板栗壳吸附Cu²⁺的平衡与动力学研究及工艺设计[J]. 环境科学学报,2009,29(10):2141-2147. QI J H,LIANG Z S,DENG X P,et al. Adsorption of Cu²⁺ onto chestnut(Castanea mollissima)shells:equilibrium,kinetics and process design[J]. Acta Scientiae Circumstantiae,2009,29(10):2141-2147.
[6] 胡六江,李益民. 有机膨润土负载纳米铁去除废水中硝基苯[J]. 环境科学学报,2008,28(6):1107-1112. HU L J,LI Y M. Removal of nitrobenzene from synthetic waste water by nano scale zero-valent iron supported onorganobentonite[J]. Acta Scientiae Circumstantiae,2008,28(6):1107- 1112.
[7] ANDERSON D M,KULIS D M,QI Y Z. Paralytic shellfish poisoning in South China[J].Toxican,1996,34(5):579-590.
[8] 胡世伟,宋文东,王金慧,等. 不同因素对牡蛎壳吸附尿素的性能及缓释性的影响[J]. 大连海洋大学学报,2011,26(4):312-315. HU S W,SONG W D,WANG J H,et al. Absorption and releasing of urea by oyster shells[J]. Journal of Dalian Ocean University,2011,26(4):312-315.
[9] CHANG H L,DO K L,MAHAMMAD A A,et al. Effects of oyster shell on soil chemical and biological properties and cabbage productivity as a liming materials[J]. Waste Management,2008,28(12):2702-2708.
[10] KWON Y T,LEE C W,YUN J H. Development of vermicast from sludge and powdered oyster shell[J]. Journal of Cleaner Production,2009,17(7):708-711.
[11] HSU T C. Experimental assessment of adsorption of Cu²⁺ and Ni²⁺ from aqueous solution by oyster shell powder[J]. Journal of Hazardous Materials,2009,171(1):995-1000.
[12] 刘文,李天华,张滕军,等. 牡蛎壳中钙的改性及吸附特性的研究[J]. 材料导报,2012,26(9):88-92. LIU W,LI T H,ZHANG T J,et al. Study on modification of calcium and adsorbability of oyster shells[J]. Materials Review,2012,26(9):88-92.
[13] 李文鹏. 改性牡蛎壳除磷吸附剂制备及其除磷性能研究[D]. 大连:大连理工大学,2014. LI W P. Study of the preparation and performance of modified oyster shell as phosphorus removal adsorbents[D]. Dalian:Dalian University of Technology,2014.
[14] CHEUNG C W,PORTER J F,MCKAY G. Sorption kinetics for the removal of copper and zinc from effluents using bone char[J]. Separation and Purification Technology,2000,19(1):55-64.
[15] 雷永汉,游东宏,郑曌. 改性牡蛎壳材料去除Cr(Ⅵ)的研究[J]. 化学工程与装备,2011(3):14-16. LEI Y H,YOU D H,ZHENG Z. Study on application of modified oyster shell adsorbent for Cr(Ⅵ) wastewater[J]. Chemical Engineering & Equipment,2011(3):14-16.
[16] LEE C W,KWON H B,JEON H P,et al. A new recycling material for removing phosphorus from water[J]. Journal of Cleaner Production,2009,17(7):683-687.
[17] YU Y,WU R,CLARK M. Phosphate removal by hydrothermally modified fumed silica and pulverized oyster shell[J]. Journal of Colloid and Interface Science,2010,350(2):538-543.
[18] TSAI H C,LO S L,KUO J. Using pretreated waste oyster and clam shells and microwave hydrothermal treatment to recover boron from concentrated wastewater[J]. Bioresource Technology,2011,102(17):7802-7806.
[19] LANGMUIR I. The adsorption of gases on plane surfaces of glass,mica and platinum[J]. Journal of the American Chemical Society,1918,40(9):1361-1403.
[20] FREUNDLICH H M F. Over the adsorption in solution[J]. Journal of Physicochemical,1906,57(1):385-470.
[21] 柴琴琴,呼世斌,刘建伟,等. 有机改性凹凸棒石对养猪废水中有机物的吸附研究[J]. 环境科学学报,2016,36(5):1672-1682. CHAI Q Q,HU S B,LIU J W,et al. The adsorption of organics in swine wastewater by organo-attapulgite[J]. Acta Scientiae Circumstantiae,2016,36(5):1672-1682.
[22] KARTHIKEYAN T,RAJGOPAL S,MIRANDA L R. Chromium (Ⅵ) adsorption from aqueous solution by Hevea Brasilinesis sawdust activated carbon[J]. Journal of Hazardous Materials,2005,124(1):192-199.
[23] HALL K R,EAGLETON L C,ACRIVOS A,et al. Pore-and solid-diffusion kinetics in fixed-bed adsorption under constant-pattern conditions[J]. Industrial & Engineering Chemistry Fundamentals,1966,5(2):212-223.
[24] GONG J L,WANG B,ZENG G M,et al. Removal of cationic dyes from aqueous solution using magnetic multi-wall carbon nanotube nanocomposite as adsorbent[J]. Journal of Hazardous Materials,2009,164(2):1517-1522.
[25] NETHAJI S,SIVASAMY A,MANDAL A B. Preparation and characterization of corn cob activated carbon coated with nano-sized magnetite particles for the removal of Cr(Ⅵ)[J]. Bioresource Technology,2013,134:94-100.
[26] DURANOGLU D,TROCHIMCZUK A W,BEKER U. Kinetics and Thermodynamics of hexavalent chromium adsorption onto activated carbon derived from acrylonitrile-divinylbenzene copolymer[J]. Chemical Engineering Journal,2012,187:193-202.
[27] WEBER W J,MORRIS J C. Kinetics of adsorption on carbon from solution[J]. Journal of the Sanitary Engineering Division,1963,89(2):31-60.
[28] 李坤权,郑正,罗兴章,等. KOH活化微孔活性炭对对硝基苯胺的吸附动力学[J]. 中国环境科学,2010,30(2):174-179. LI K Q,ZHENG Z,LUO X Z,et al. Adsorption kinetics of p-nitroaniline onto microporous carbon activation with KOH[J]. China Environmental Science,2010,30(2):174-179.
[29] 张艳素,豆小敏,赵蓓,等. As(Ⅴ) 在锆铁复合氧化物颗粒上的吸附动力学[J]. 化工进展,2011,30(s1):874-877. ZHANG Y S,DOU X M,ZHAO B,et al. Adsorption kinetics of arsenic (Ⅴ) using granular zirconium-ferric oxide adsorbent[J]. Chemical Industry and Engineering Progress,2011,30(s1):874-877.
[30] MALL I.D,AGARWALV C,et al. Removal of congo red from aqueous solution by bagasse fly ash and activated carbon:kinetic study and equilibrium isotherm analyses[J]. Chemosphere,2005,61(4):223-231.

牡蛎壳改性材料及其吸附多氯联苯的性能

Modified oyster shell material and its PCBs adsorption characteristics

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	黄益平, 李婷, 郑龙云, 戚傲, 陈政霖, 史天昊, 张新宇, 郭凯, 胡猛, 倪泽雨, 刘辉, 夏苗, 主凯, 刘春江. 三级环流反应器中气液流动与传质规律[J]. 化工进展, 2023, 42(S1): 175-188.
[2]	王胜岩, 邓帅, 赵睿恺. 变电吸附二氧化碳捕集技术研究进展[J]. 化工进展, 2023, 42(S1): 233-245.
[3]	崔守成, 徐洪波, 彭楠. 两种MOFs材料用于O₂/He吸附分离的模拟分析[J]. 化工进展, 2023, 42(S1): 382-390.
[4]	陈崇明, 陈秋, 宫云茜, 车凯, 郁金星, 孙楠楠. 分子筛基CO₂吸附剂研究进展[J]. 化工进展, 2023, 42(S1): 411-419.
[5]	许春树, 姚庆达, 梁永贤, 周华龙. 共价有机框架材料功能化策略及其对Hg(Ⅱ)和Cr(Ⅵ)的吸附性能研究进展[J]. 化工进展, 2023, 42(S1): 461-478.
[6]	顾永正, 张永生. HBr改性飞灰对Hg⁰的动态吸附及动力学模型[J]. 化工进展, 2023, 42(S1): 498-509.
[7]	汪鹏, 张洋, 范兵强, 何登波, 申长帅, 张贺东, 郑诗礼, 邹兴. 高碳铬铁盐酸浸出过程工艺及动力学[J]. 化工进展, 2023, 42(S1): 510-517.
[8]	郭强, 赵文凯, 肖永厚. 增强流体扰动强化变压吸附甲硫醚/氮气分离的数值模拟[J]. 化工进展, 2023, 42(S1): 64-72.
[9]	刘阳, 王云刚, 修浩然, 邹立, 白彦渊. 基于动力学分析的核桃壳最佳炭化工艺[J]. 化工进展, 2023, 42(S1): 94-103.
[10]	董佳宇, 王斯民. 超声强化对二甲苯结晶特性及调控机理实验[J]. 化工进展, 2023, 42(9): 4504-4513.
[11]	葛亚粉, 孙宇, 肖鹏, 刘琦, 刘波, 孙成蓥, 巩雁军. 分子筛去除VOCs的研究进展[J]. 化工进展, 2023, 42(9): 4716-4730.
[12]	杨莹, 侯豪杰, 黄瑞, 崔煜, 王兵, 刘健, 鲍卫仁, 常丽萍, 王建成, 韩丽娜. 利用煤焦油中酚类物质Stöber法制备碳纳米球用于CO₂吸附[J]. 化工进展, 2023, 42(9): 5011-5018.
[13]	张振, 李丹, 陈辰, 吴菁岚, 应汉杰, 乔浩. 吸附树脂对唾液酸的分离纯化[J]. 化工进展, 2023, 42(8): 4153-4158.
[14]	姜晶, 陈霄宇, 张瑞妍, 盛光遥. 载锰生物炭制备及其在环境修复中应用研究进展[J]. 化工进展, 2023, 42(8): 4385-4397.
[15]	于静文, 宋璐娜, 刘砚超, 吕瑞东, 武蒙蒙, 冯宇, 李忠, 米杰. 一种吲哚基超交联聚合物In-HCP对水中碘的吸附作用[J]. 化工进展, 2023, 42(7): 3674-3683.