碱改性城市污泥-煤的成浆性能

doi:10.16085/j.issn.1000-6613.2016-2130

化工进展 ›› 2017, Vol. 36 ›› Issue (07): 2691-2697.DOI: 10.16085/j.issn.1000-6613.2016-2130

碱改性城市污泥-煤的成浆性能

朱梦园¹, 吴国光¹, 胡远丰¹, 孟献梁^1,2, 马少莲¹

1 中国矿业大学化工学院, 江苏徐州 221116;
2 江苏省煤基CO₂捕集与地质储存重点实验室, 江苏徐州 221116

收稿日期:2016-11-18 修回日期:2016-12-30 出版日期:2017-07-05 发布日期:2017-07-05
通讯作者: 吴国光,教授,主要从事煤化工及洁净能源方面研究。
作者简介:朱梦园(1993-),女,硕士研究生,主要从事煤化工及洁净能源方面研究。E-mail:zhumycumtedu@163.com。
基金资助:
国家自然科学基金项目（51674256，51204179）。

Effect of alkali-treated sludge on sludge-coal water slurry performance

ZHU Mengyuan¹, WU Guoguang¹, HU Yuanfeng¹, MENG Xianliang^1,2, MA Shaolian¹

1 School of Chemical Engineering, China University of Mining and Technology, Xuzhou 221116, Jiangsu, China;
2 The Key Laboratory of Coal-Based CCO₂Capture and Geological Storage, Jiangsu Province, Xuzhou 221116, Jiangsu, China

Received:2016-11-18 Revised:2016-12-30 Online:2017-07-05 Published:2017-07-05

摘要/Abstract

摘要： 为解决污泥与煤掺混制浆时存在浓度低和掺混量少等问题，本文将污泥干燥基质量20%的NaOH粉末与污泥均匀混合以对其进行改性，并用改性前后的污泥分别制备污泥-水煤浆，采用红外光谱仪、SEM扫描电镜和表面Zeta电位对样品进行表征，考察了改性对污泥结构性质的变化及不同污泥及改性污泥添加量对成浆性能的影响。通过NaOH改性处理，得到的改性污泥表面含氧官能团含量下降，表面电负性增强，有利于成浆。结果表明，改性可以解决污泥-水煤浆浓度低和流动性差的问题，对比污泥-水煤浆，当改性污泥添加量为10%时，浓度提高了5.64%，流动性得到很大提高，表现为连续流动，稳定性也有明显改善。在满足污泥-水煤浆性能的条件下，提高了污泥的利用率，促进了污泥在水煤浆制备中的应用。

关键词: 污泥, 改性, 水煤浆, 成浆性能

Abstract: In order to improve the addition of sludge and sludge coal water slurry concentration,sludge was mixed with NaOH powder (m_NaOH:m_{sludge drying}=1:5) to modify its quality.The sludge-coal water slurry (CWS) was prepared with the sludge and modified sludge,respectively,and the effects of modification on the properties of the sludge and different additions on the slurry properties were investigated by Fourier transform infrared spectrum (FTIR),scanning electron microscope (SEM) and surface zeta potential.The content of oxygen-containing functional groups on the surface of modified sludge decreased and the surface electronegativity was enhanced by being modified on sludge after alkali-treated,which had an advantage on slurry.Sludge modification can solve the problem of the low concentration,poor fluidity and stability of CWS.Comparing with sludge-CWS,results showed that when the amount of modified sludge addition was 10%,the concentration increased by 5.64% and fluidity improved greatly.Stability was also improved significantly.Under the condition of satisfying the performance of sludge-coal slurry,the utilization rate of sludge was improved and the application of sludge in coal slurry preparation was promoted.

Key words: municipal sludge, modification, coal water slurry, slurry performance

中图分类号:

TQ536.1

朱梦园, 吴国光, 胡远丰, 孟献梁, 马少莲. 碱改性城市污泥-煤的成浆性能[J]. 化工进展, 2017, 36(07): 2691-2697.

ZHU Mengyuan, WU Guoguang, HU Yuanfeng, MENG Xianliang, MA Shaolian. Effect of alkali-treated sludge on sludge-coal water slurry performance[J]. Chemical Industry and Engineering Progress, 2017, 36(07): 2691-2697.

参考文献

[1] 马淞江,张仲欢,王劲,等. 半焦与城市污泥混合物的燃烧性能研究[J]. 环境污染与防治,2016,38(5):22-26. MA S J,ZHANG Z H,WANG J,et al. Study on combustion performance of semi-coke and municipal sludge mixture[J]. Environ. Poll. Control,2016,38(5):22-26.
[2] 陈涛,孙水裕,刘敬勇,等. 城市污水污泥焚烧二次污染物控制研究进展[J]. 化工进展,2010,29(1):157-162. CHEN T,SUN S Y,LIU J Y,et al. Progress in the treatment of secondary pollutants generated from municipal sewage sludge incineration[J]. Chemical Industry and Engineering Progress,2010,29(1):157-162.
[3] 姚杰. 污水污泥与高灰熔点煤制备水煤浆及气化实验研究[D]. 淮南:安徽理工大学,2015. YAO J. Experimental study on slurry preparation and gasification of urbaⅡsewage sludge and high ash fusion temperature coal[D]. Huainan:Anhui University of Science and Technology,2015.
[4] 金大钺,孔顺利,朱芝材,等. 利用城市污泥制备水煤浆的实验研究[J]. 广州化工,2015,43(17):106-110. JIN D Y,KONG S L,ZHU Z C,et al. CWS preparation with sewage sludge[J]. Guangzhou Chem. Ind.,2015,43(17):106-110.
[5] 张辉,胡勤海,吴祖成,等. 城市污泥能源化利用研究进展[J]. 化工进展,2013,32(5):1145-1151. ZHANG H,HU Q H,WU Z C,et al. An overview on utilization of municipal sludge as energy resources[J]. Chemical Industry and Engineering Progress,2013,32(5):1145-1151.
[6] HOU X F,XUE H F. Application of genetic algorithm in site selection of municipal sewage sludge treatment and disposal projects[J]. Journal of Shanghai Jiaotong University,2011,45(7):1080-1084.
[7] 张宏科,孙少文,徐辉,等. 活性污泥掺混水煤浆的成浆性能实验研究[J]. 煤化工,2016,44(2):30-33. ZHANG H K,SUN S W,XU H,et al. Study on slurrying performance of activated sludgeblending CWS[J]. Coal Chem. Ind.,2016,44(2):30-33.
[8] NDAJI F E,ELLYAT W A T,MALIK A A,et al. Temperature programmed combustion studies of the co-processing of coal and waste materials[J]. Fuel,1999,78(3):301-307.
[9] OTERO M,DIEZ C,CALVO L F,et a1. Analysis of the co-combustion of sewage sludge and coal by TG-MS[J]. Biomass Bioenerg.,2002,22(4):319-329.
[10] 王丹,孟媛媛,胡勤海,等. 两种城市污泥掺混水煤浆的成浆性[J]. 环境科学学报,2009,29(8):1690-1695. WANG D,MENG Y Y,HU Q H,et a1. Slurry ability of coal water slurry prepared with two kinds of sewage sludge[J]. Acta. Scientiae Circumstantia.,2009,29(8):1690-1695.
[11] 李伟东,李明,李伟锋,等. 改性污泥与无烟煤成浆性的研究[J]. 燃料化学学报,2009,37(1):26-30. LI W D,LI M,LI W F,et a1. Co-slurryability of modified sewage sludge and anthracite[J]. J. Fuel Chem. Technol.,2009,37(1):26-30.
[12] 杨威,张明月,任雅楠,等. 剪切增稠液体材料的研究现状及其在人体防护装备上的应用[J]. 中国塑料,2013,27(9):1-5. YANG W,ZHANG M Y,REN Y N,et a1. Research progress in shear-thickening fluids and its application in body protection[J]. China Plastics,2013,27(9):1-5.
[13] LI W,LI W, LIU H. Effects of sewage sludge on rheological characteristics of coal-water slurry[J]. Fuel,2010,89(9):2505-2510.
[14] 周加祥,佘鹏,刘铮,等. 水平电场污泥脱水过程[J]. 化工学报,2001,52(7):635-638. ZHOU J X,SHE P,LIU Z,et a1. Sludge dewatering in horizontal field[J]. CIESC J.,2001,52(7):635-638.
[15] 曹秉帝,张伟军,王东升,等. 污泥絮凝调理对絮体理化性质的影响机制研究[J]. 环境污染与防治,2016,38(2):29-33. CAO B D,ZHANG W J,WANG D S,et al. Influence of physical and chemical properties of sludge flocculation conditioning[J]. Environ. Poll. Control,2016,38(2):29-33
[16] DENG W Y,LI X D,YAN J H,et al. Moisture distribution in sludge based on different testing methods[J]. J. Environ. Sci.,2011,23(5):875-880.
[17] 刘晓玲. 城市污泥厌氧发酵产酸条件优化及其机理研究[D]. 无锡:江南大学,2008. LIU X L. Optimization of anaerobic fermentation conditions for municipal wastewater and its mechanism[D]. Wuxi:Jiangnan University,2008.
[18] YU G H,HE P J,SHAO L M,et al. Toward understanding the mechanism of improving the production of volatile fatty acids from activated sludge at pH 10.0[J]. Water Res.,2008,42(18):4637-4644.
[19] SONG Y,FENG Q,AHN Y. Performance of the bioelectrochemical anaerobic digestion of sewage sludge at different HRTs[J]. Energ. Fuel.,2015,30(1):352-359.
[20] ZHANG Y,ZHANG P,ZHANG G,et al. Sewage sludge disintegration by combined treatment of alkaline + high pressure homogenization[J]. Bioresource Technol.,2012,123:514-519.
[21] XIAO B,HAN Y,LIU X,et al. Relationship of methane and electricity production in two-chamber microbial fuel cell using sewage sludge as substrate[J]. Int. J. Hydrogen Energ.,2014,39(29):16419-16425.
[22] 池勇志,刘晓敏,李玉友,等. 微波预处理剩余污泥的研究进展[J]. 化工进展,2013,32(9):2221-2226. CHI Y Z,LIU X M,LI Y Y,et al. Research progress on microwave pretreatment of waste activated sludge[J]. Chemical Industry and Engineering Progress,2013,32(9):2221-2226.
[23] LI J,ZHANG G,SHANG T,et al. Synthesis, characterization and application of a dispersant based on rosin for coal-water slurry[J]. Int. J. Min. Technol.,2014,24(5):695-699.
[24] 肖本益,刘俊新. 污水处理系统剩余污泥碱处理融胞效果研究[J]. 环境科学,2006,27(2):319-323. XIAO B Y,LIU J X. Study on treatment of excess sludge under alkaline condition[J]. Environ. Sci.,2006,27(2):319-323.

碱改性城市污泥-煤的成浆性能

Effect of alkali-treated sludge on sludge-coal water slurry performance

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	王家庆, 宋广伟, 李强, 郭帅成, DAI Qingli. 橡胶混凝土界面改性方法及性能提升路径[J]. 化工进展, 2023, 42(S1): 328-343.
[2]	陈崇明, 陈秋, 宫云茜, 车凯, 郁金星, 孙楠楠. 分子筛基CO₂吸附剂研究进展[J]. 化工进展, 2023, 42(S1): 411-419.
[3]	顾永正, 张永生. HBr改性飞灰对Hg⁰的动态吸附及动力学模型[J]. 化工进展, 2023, 42(S1): 498-509.
[4]	朱杰, 金晶, 丁正浩, 杨会盼, 侯封校. 化学链气化中准东煤灰对CaSO₄载氧体改性及其作用机理[J]. 化工进展, 2023, 42(9): 4628-4635.
[5]	王晋刚, 张剑波, 唐雪娇, 刘金鹏, 鞠美庭. 机动车尾气脱硝催化剂Cu-SSZ-13的改性研究进展[J]. 化工进展, 2023, 42(9): 4636-4648.
[6]	李志远, 黄亚继, 赵佳琪, 于梦竹, 朱志成, 程好强, 时浩, 王圣. 污泥与聚氯乙烯共热解重金属特性[J]. 化工进展, 2023, 42(9): 4947-4956.
[7]	史天茜, 石永辉, 武新颖, 张益豪, 秦哲, 赵春霞, 路达. Fe²⁺对厌氧氨氧化EGSB反应器运行性能的影响[J]. 化工进展, 2023, 42(9): 5003-5010.
[8]	李雪佳, 李鹏, 李志霞, 晋墩尚, 郭强, 宋旭锋, 宋芃, 彭跃莲. 亲水和疏水改性膜的抗结垢和润湿能力的对比[J]. 化工进展, 2023, 42(8): 4458-4464.
[9]	陈俊俊, 费昌恩, 段金汤, 顾雪萍, 冯连芳, 张才亮. 高生物活性聚醚醚酮化学改性研究进展[J]. 化工进展, 2023, 42(8): 4015-4028.
[10]	谭利鹏, 申峻, 王玉高, 刘刚, 徐青柏. 煤沥青和石油沥青共混改性的研究进展[J]. 化工进展, 2023, 42(7): 3749-3759.
[11]	杨子育, 朱玲, 王文龙, 于超凡, 桑义敏. 阴燃法处理含油污泥的研究及应用进展[J]. 化工进展, 2023, 42(7): 3760-3769.
[12]	殷成阳, 侯铭, 杨爽, 毛迪, 刘俊言. 过渡金属改性Cu-SSZ-13分子筛脱硝催化剂研究进展[J]. 化工进展, 2023, 42(6): 2963-2974.
[13]	郑昕, 贾里, 王彦霖, 张靖超, 陈世虎, 乔晓磊, 樊保国. 污泥与煤泥混烧对重金属固留特性的影响[J]. 化工进展, 2023, 42(6): 3233-3241.
[14]	修浩然, 王云刚, 白彦渊, 邹立, 刘阳. 准东煤/市政污泥混燃燃烧特性及灰熔融行为分析[J]. 化工进展, 2023, 42(6): 3242-3252.
[15]	詹咏, 王慧, 韦婷婷, 朱星宇, 王先恺, 陈思思, 董滨. Mn²⁺强化臭氧调理对生物处理工艺的污泥原位减量效果[J]. 化工进展, 2023, 42(6): 3253-3260.