有机朗肯循环中的工质热源转折温度及其特征

doi:10.16085/j.issn.1000-6613.2017-0056

化工进展 ›› 2017, Vol. 36 ›› Issue (09): 3223-3230.DOI: 10.16085/j.issn.1000-6613.2017-0056

有机朗肯循环中的工质热源转折温度及其特征

李新国, 王伟, 翟哲, 南来福, 王竞逸

天津大学机械工程学院, 天津 300350

收稿日期:2017-01-10 修回日期:2017-05-08 出版日期:2017-09-05 发布日期:2017-09-05
通讯作者: 李新国(1965-),男,博士,教授,主要从事工程热力学研究。
作者简介:李新国(1965-),男,博士,教授,主要从事工程热力学研究。E-mail:xgli@tju.edu.cn
基金资助:
国家自然科学基金项目（51276122）。

Shift-temperature of heating fluid and its characteristics for working fluid in organic Rankine cycle

LI Xinguo, WANG Wei, ZHAI Zhe, NAN Laifu, WANG Jingyi

School of Mechanical Engineering, Tianjin University, Tianjin 300350, China

Received:2017-01-10 Revised:2017-05-08 Online:2017-09-05 Published:2017-09-05

摘要/Abstract

摘要： 有机朗肯循环中存在有极值功循环与无极值功循环，即存在一种净功的转折线与所对应的工质热源转折温度，它对工质的选择与循环性能评价具有指标性的作用。基于梯形循环及其理论模型，本文建立工质饱和线形状（饱和液线斜率、饱和气线斜率及其斜率比与临界温度）及物性为自变量的数学关系，并提出和定义线性饱和线工质模型，建立循环性能与工质物性之间的数学关系。分别推导出有机朗肯循环中工质热源转折温度的经验公式，以及梯形循环下线性饱和线工质的热源转折温度理论公式及其修正。研究热源转折温度及其对应的优化工况的特征与一般性规律，得到21种工质热源转折温度的有机朗肯循环数值计算与经验公式之间的偏差小于1.97%。线性饱和线工质模型下，工质的热源转折温度为临界温度和蒸发器窄点温差之和；热源转折温度所对应的最高优化工况（最高优化蒸发温度与最大净功极值）随斜率比单调增加，至干工质时，最高优化工况接近工质的临界点。

关键词: 有机朗肯循环, 梯形循环, 线性饱和线工质, 工质热源转折温度, 最高优化工况

Abstract: The existence of the maximum power cycle and no maximum power cycle in organic Rankine cycle(ORC)means that there is a kind of shift-curve of net power output and its corresponding shift-temperature of heating fluid for the working fluids; which played an index function in the selection of the working fluids and the evaluation of the cycle performance. Based on trapezoidal cycle and its theoretical model,the relation and formulas of the saturated line shape(saturated liquid line slope,saturated gas line slope and its ratio and critical temperature)and thermal properties of the working fluids as variables were established. The model of working fluid with linear saturated line was proposed and defined. The mathematical model and relation between the cycle performance and properties of the working fluids were built. The empirical equations of the shift-temperature of heating fluid for the working fluid in ORC and the theoretical equations of the shift-temperature of heating fluid in working fluid with linear saturated line were derived,respectively. The characteristics and general principles of the shift-temperature of heating fluid and its corresponding optimum condition were investigated. Results showed that the deviation of shift-temperature of heating fluid with 21 working fluids between empirical equations and numerical simulations in ORC was less than 1.97%. The shift-temperature of heating fluid in model of working fluid with linear saturated line is the addition of the critical temperature of working fluid and the pinch point temperature difference of evaporator. The maximum optimal conditions(maximum optimal evaporation temperature and maximum net power output)corresponding to the shift-temperature of heating fluid increases with the ratio of the saturated line slope, which will be close to the critical point of the working fluid when it becomes the dry working fluid.

Key words: organic Rankine cycle, trapezoidal cycle, working fluid with linear saturated line, shift-temperature of heating fluid for working fluid, maximum optimum condition

中图分类号:

TK123

李新国, 王伟, 翟哲, 南来福, 王竞逸. 有机朗肯循环中的工质热源转折温度及其特征[J]. 化工进展, 2017, 36(09): 3223-3230.

LI Xinguo, WANG Wei, ZHAI Zhe, NAN Laifu, WANG Jingyi. Shift-temperature of heating fluid and its characteristics for working fluid in organic Rankine cycle[J]. Chemical Industry and Engineering Progress, 2017, 36(09): 3223-3230.

参考文献

[1] 徐荣吉,张晓晖,闫美玉,等.过热/过冷对内回热有机朗肯循环影响的热力学分析[J].化工进展,2016,35(12):3783-3792. XU Rongji,ZHANG Xiaohui,YAN Meiyu,et al.Thermal dynamics analysis on the organic Rankine cycle (ORC)with internal heat regenerator at superheated and subcooling conditions[J].Chemical Industry and Engineering Progress,2016,35(12):3783-3792.
[2] 韩中合,潘歌,范伟,等.内回热器对低温有机朗肯循环热力性能的影响及工质选择[J].化工进展,2016,35(1):40-47. HAN Zhonghe,PAN Ge,FAN Wei,et al.Effect of internal heat exchanger on thermodynamic performance of low temperature organic Rankine cycle and working fluid selection[J].Chemical Industry and Engineering Progress,2016,35(1):40-47.
[3] 杨绪飞,戚风亮,刘秀龙,等.有机朗肯循环膨胀机入口过热度实验[J].化工进展,2016,35(7):2007-2014. YANG Xufei,QI Fengliang,LIU Xiulong,et al.Experiment on expander inlet superheat of organic Rankine cycle[J].Chemical Industry and Engineering Progress,2016,35(7):2007-2014.
[4] 王明涛,方筝,刘启一.涡轮增压柴油机余热利用的有机郎肯循环烃类高温工质热力学分析[J].化工进展,2016,35(9):2721-2727. WANG Mingtao,FANG Zheng,LIU Qiyi.Thermodynamic analysis of an organic Rankine cycle for waste heat recovery of a turbo-charged diesel engine based on working fluids of alkanes[J].Chemical Industry and Engineering Progress,2016,35(9):2721-2727.
[5] 张军辉,刘娟芳,陈清华.有机朗肯循环系统最佳蒸发温度和(火用)分析[J].化工学报,2013,64(3):820-826. ZHANG Junhui,LIU Fangjuan,CHEN Qinghua.Optimal evaporating temperature and exergy analysis for original Rankine cycle[J].CIESC Journal,2013,64(3):820-826.
[6] 贺超,刘朝,高虹,等.工业余热有机朗肯循环参数优化和分析[J].工程热物理学报,2012,33(12):2042-2046. HE Chao,LIU Chao,GAO Hong,et al.Parameters optimization and performance analysis of organic Rankine cycle for industrial waste heat recovery[J].Journal of Engineering Thermophysics,2012,33(12):2042-2046.
[7] LI H,MA X L,WEI X L,et al.Selection of working fluids for low-temperature waste heat recovery using organic Rankine cycle[J].Advanced Materials Research,2012,512-515:1217-1222.
[8] YU H S,FENG X,WANG Y F.A new pinch based method for simultaneous selection of working fluid and operating conditions in an ORC (Organic Rankine Cycle) recovering waste heat[J].Energy,2015,90:36-46.
[9] 严家禄.低温热能发电方案中选择工质和确定参数的热力学原则和计算[J].工程热物理学报,1982,3(1):1-7. YAN Jialu.Thermodynamic principles and formulas for choosing working fluids and parameters in desgning power plant of low temperature heat[J].Journal of Engineering Thermophysics,1982,3(1):1-7.
[10] WANG D X,LING X,PENG H,et al.Efficiency and optimal performance evaluation of organic Rankine cycle for low grade waste heat power generation[J].Energy,2013,50(1):343-352.
[11] WANG D X,LING X,PENG H.Cost-effectiveness performance analysis of organic Rankine cycle for low grade heat utilization coupling with operation condition[J].Applied Thermal Engineering,2013,58(1-2):571-584.
[12] HE C,LIU C,GAO H,et al.The optimal evaporation temperature and working fluids for subcritical organic Rankine cycle[J].Energy,2012,38(1):136-143.
[13] HE C,LIU C,ZHOU M T,et al.A new selection principle of working fluids for subcritical organic Rankine cycle coupling with different heat sources[J].Energy,2014,68(15):283-291.
[14] CHEN H,GOSWAMI D Y,STEFANAKOS E K.A review of thermodynamic cycles and working fluids for the conversion of low-grade heat[J].Renewable & Sustainable Energy Reviews,2010,14(9):3059-3067.
[15] MAIZZA V,MAIZZA A.Working fluids in non-steady flows for waste energy recovery systems[J].Applied Thermal Engineering,1996,16:579-90.
[16] YAMAMOTO T,FURUHATA T,ARAI N,et al.Design and testing of the organic Rankine cycle[J].Energy,2001,26(3):239-251.
[17] LIU B T,CHIEN K H,WANG C C.Effect of working fluids on organic Rankine cycle for waste heat recovery[J]. Energy,2004,29(8):1207-1217.
[18] LI X G.A trapezoidal cycle with theoretical model based on organic Rankine cycle[J].International Journal of Energy Research,2016,40(12):1624-1637.
[19] LI X G,ZHAO W J,LIN D D,et al.Working fluid selection based on critical temperature and water temperature in organic Rankine cycle[J].Science China Technological Sciences,2015,58(1):138-146.

有机朗肯循环中的工质热源转折温度及其特征

Shift-temperature of heating fluid and its characteristics for working fluid in organic Rankine cycle

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	李丹, 杨思宇, 钱宇. 耦合溴化锂吸收式制冷与有机朗肯循环的合成气深冷分离工艺[J]. 化工进展, 2022, 41(10): 5236-5246.
[2]	李新国, 弭慧惠, 吴晓松, 高冠怡. 调节传热窄点以提升有机朗肯循环性能的分析[J]. 化工进展, 2021, 40(5): 2517-2525.
[3]	刘广林, 徐进良, 苗政. 共冷凝器双循环有机朗肯发电系统㶲分析[J]. 化工进展, 2021, 40(12): 6656-6662.
[4]	刘广林, 曹泷, 刘欢, 苗政, 徐进良. 基于单螺杆膨胀机有机朗肯循环有无回热系统性能分析[J]. 化工进展, 2019, 38(06): 2626-2632.
[5]	王治红, 丁晓明, 吴明鸥, 沈晓燕. 有机朗肯循环在多品位余热发电中的应用[J]. 化工进展, 2019, 38(05): 2189-2196.
[6]	杨宇鑫, 张红光, 赵蕊, 李健, 赵腾龙, 张梦茹. 工质泵变运行工况对有机朗肯循环系统性能的影响[J]. 化工进展, 2019, 38(02): 851-857.
[7]	姚玉婷, 李士雨. 高通量换热器用于低温发电系统的研究[J]. 化工进展, 2018, 37(10): 3737-3743.
[8]	黄靖伦, 王辉涛, 葛众, 韩金蓉, 赵玲玲. 双压膨胀有机朗肯循环中低温余热发电系统的热力性能[J]. 化工进展, 2018, 37(09): 3303-3311.
[9]	王明涛, 刘启一, 张百浩. 冷凝条件对基于混合工质的内燃机余热有机朗肯循环热力性能的影响[J]. 化工进展, 2018, 37(08): 2927-2934.
[10]	杨德明, 朱碧云, 顾强, 王争光, 印一凡, 高晓新. 基于机械蒸汽再压缩和有机朗肯循环技术的双溶剂协同萃取精馏分离乙酸甲酯-甲醇-水节能工艺[J]. 化工进展, 2018, 37(05): 2010-2015.
[11]	曹泷, 刘秀龙, 张鸣, 徐进良. 有机朗肯循环发电系统变工况运行的实验研究[J]. 化工进展, 2018, 37(01): 88-95.
[12]	吴国策, 朱兴仪, 赵英汝. 一种新型的太阳能驱动ORC-HP热电联产耦合系统[J]. 化工进展, 2017, 36(S1): 195-202.
[13]	韩中合, 许鸿胜, 范伟, 赵若丞, 王智. 低温烟气有机郎肯循环ORC系统热力性能与经济性的对比分析[J]. 化工进展, 2017, 36(11): 4010-4016.
[14]	刘秀龙, 曹泷, 苗政, 张鸣, 谢学旺, 徐进良. 有机朗肯循环驱动反渗透海水淡化运行模式及工质选择[J]. 化工进展, 2017, 36(10): 3639-3647.
[15]	曹泷, 刘秀龙, 张鸣, 徐进良. 有机朗肯循环系统孤网运行的实验研究[J]. 化工进展, 2017, 36(10): 3577-3583.