胺鲜酯和2,4-二氯苯氧乙酸协同诱导裂殖壶菌积累DHA

doi:10.16085/j.issn.1000-6613.2023-0006

摘要/Abstract

摘要：

目前添加植物生长调节剂是一种促进裂殖壶菌中二十二碳六烯酸（DHA）积累以及提高其产量很有潜力的策略。添加单一植物生长调节剂促进裂殖壶菌DHA积累已有报道，但同时添加两种植物生长调节剂协同促进裂殖壶菌中DHA积累鲜见报道。本工作采用合成植物生长调节剂胺鲜酯（DA-6）和2,4-二氯苯氧乙酸（2,4-D）协同诱导裂殖壶菌积累DHA，提高DHA含量和产量，以DHA为指标优化了DA-6和2,4-D的最佳协同浓度。结果表明：0.05mg/L DA-6和0.5mg/L 2,4-D协同处理裂殖壶菌，裂殖壶菌生物量和油脂含量没显著增加，但DHA含量和产量显著增加，分别达到58.32%和5.17g/L，相比于单独添加DA-6分别增加17%和23%，相比于未添加植物生长调节剂的空白对照组分别增加了48%和48%。本研究表明适宜浓度的合成植物生长调节剂可协同诱导裂殖壶菌中DHA的积累，提高DHA产量，为大规模工业化生产DHA提供新的思路和策略。

关键词: 胺鲜酯, 2,4-二氯苯氧乙酸, 裂殖壶菌, 植物生长调节剂, 二十二碳六烯酸

Abstract:

The addition of plant growth regulators is a currently promising strategy to promote DHA accumulation in Schizochytrium sp. and increase its yield. The addition of a single plant growth regulator has been reported to promote the accumulation of DHA in Schizochytrium sp., but the synergistic promotion of DHA accumulation in Schizochytrium sp. by the addition of two plant growth regulators at the same time has rarely been reported. In this study, two plant growth regulators, diethyl aminoethyl hexanoate (DA-6) and 2,4-dichlorophenoxyacetic acid (2,4-D) were used to synergistically induce the accumulation of DHA in Schizochytrium sp., increasing the content and yield of DHA. The synergistic concentration of DA-6 and 2,4-D was optimized using DHA as an indicator. The results showed that when 0.05mg/L DA-6 combinating with 0.5mg/L 2,4-D was used, the biomass and oil contents did not significantly increase, compared to supplemented DA-6 group and control group without plant growth regulator. But the DHA content and yield increased significantly and reached the highest values, which were 58.32% and 5.17g/L, respectively. Compared to supplemented DA-6 group, DHA content and yield increased by 0.17 times and 0.23 times, respectively; compared to control group without plant growth regulator, DHA content and yield increased by 0.48 times and 0.48 times, respectively. The results of this work indicated that synthetic plant growth regulators with appropriate concentration could synergically induce DHA accumulation in Schizochytrium sp. to increase DHA production, which provided a new idea and strategy for large-scale industrial production of DHA.

Key words: diethyl aminoethyl hexanoate, 2,4-dichlorophenoxyacetic acid, Schizochytrium sp., plant growth regulator, docosahexaenoic acid

中图分类号:

唐裕芳, 刘磊, 杨雨欣, 曾彦霖, 李玉芹, 周蓉, 张妙玲. 胺鲜酯和2,4-二氯苯氧乙酸协同诱导裂殖壶菌积累DHA[J]. 化工进展, 2023, 42(11): 5900-5907.

TANG Yufang, LIU Lei, YANG Yuxin, ZENG Yanlin, LI Yuqin, ZHOU Rong, ZHANG Miaoling. Synergy inducting effect of diethyl aminoethyl hexanoate and 2,4-dichlorophenoxyacetic acid on DHA accumulation in Schizochytrium sp.[J]. Chemical Industry and Engineering Progress, 2023, 42(11): 5900-5907.

图/表 4

图1 DA-6对裂殖壶菌生物量、油脂质量分数、DHA质量分数和产量的影响

图2 DA-6和不同浓度2,4-D协同处理对裂殖壶菌生长、油脂质量分数、DHA质量分数和产量的影响

图3 DA-6 和2,4-D协同处理下裂殖壶菌生长及DHA质量分数和产量变化

图4 DA-6和2,4-D诱导裂殖壶菌积累DHA可能机制↑上调；—|抑制；激活；→ 促进

参考文献 35

1	胡爱云, 龚定芳, 李莎. 裂殖壶菌诱变株高产DHA机理的转录组学分析[J]. 中国油脂, 2019, 44(12): 120-126.
	HU Aiyun, GONG Dingfang, LI Sha. Transcriptome analysis for the mechanism of high-yield of DHA by mutagenic Schizochytrium [J]. China Oils and Fats, 2019, 44(12): 120-126.
2	WEILL P, PLISSONNEAU C, LEGRAND P, et al. May omega-3 fatty acid dietary supplementation help reduce severe complications in Covid-19 patients?[J]. Biochimie, 2020, 179: 275-280.
3	SUN L, REN L, ZHUANG X, et al. Differential effects of nutrient limitations on biochemical constituents and docosahexaenoic acid production of Schizochytrium sp.[J]. Bioresource Technology, 2014, 159: 199-206.
4	黄琼叶. 低温促进裂壶藻DHA积累的分子机制研究[D]. 厦门: 国家海洋局第三海洋研究所, 2017.
	HUANG Qiongye. Study on molecular mechanism of low lemperature promoting DHA accumulation in Chizochytrium sp.[D]. Xiamen: Third Institute of Oceanography (TIO) of the Ministry of Natural Resources, 2017.
5	SUN X, REN L, JI X, et al. Adaptive evolution of Schizochytrium sp. by continuous high oxygen stimulations to enhance docosahexaenoic acid synthesis[J]. Bioresource Technology, 2016, 211: 374-381.
6	蔡传杰, 陈善娜. 植物激素的研究进展[J]. 云南大学学报(自然科学版), 2001, 23(S1): 99-101, 112.
	CAI Chuanjie, CHEN Shanna. Research progress in plant hormones[J]. Journal of Yunnan University (Natural Science Edition), 2001, 23(S1): 99-101, 112.
7	VERHAGE A, WEES S V, PIETERSE C. Plant immunity: It’s the hormones talking, but what do they say?[J]. Plant Physiology, 2010, 154(2): 536-540.
8	SINGH J, JAIN D, AGARWAL P, et al. Auxin and cytokinin synergism augmenting biomass and lipid production in microalgae Desmodesmus sp. JS07[J]. Process Biochemistry, 2020, 95: 223-234.
9	张剑, 杨雨欣, 唐裕芳, 等. 六种植物生长调节剂促进裂壶藻油脂和DHA积累的研究[J]. 湘潭大学学报(自然科学版), 2022, 44(4): 81-89.
	ZHANG Jian, YANG Yuxin, TANG Yufang, et al. Investigation of six plant growth regulators promoting lipid and DHA accumulation in Schizochytrium [J]. Journal of Xiangtan University (Natural Science Edition), 2022, 44(4): 81-89.
10	YU X, SUN J, SUN Y, et al. Metabolomics analysis of phytohormone gibberellin improving lipid and DHA accumulation in Aurantiochytrium sp.[J]. Biochemical Engineering Journal, 2016, 112: 258-268.
11	UDAYAN A, KATHIRESAN S, ARUMUGAM M. Kinetin and Gibberellic acid (GA3) act synergistically to produce high value polyunsaturated fatty acids in Nannochloropsis oceanica CASA CC201[J]. Algal Research, 2018, 32: 182-192.
12	KOZLOVA T A, HARDY B P, LEVIN D B. The combined influence of 24‑epibrassinolide and 3‑indoleacetic acid on growth and accumulation of pigments and fatty acids in the microalgae Scenedesmus quadricauda (CPCC-158)[J]. Algal Research, 2018, 35: 22-32.
13	XING H, ZHAO Y, LI T, et al. Enhancing astaxanthin and lipid coproduction in Haematococcus pluvialis by the combined induction of plant growth regulators and multiple stresses[J]. Bioresource Technology, 2022, 344: 126225.
14	RENUKA N, GULDHE A, SINGH P, et al. Evaluating the potential of cytokinins for biomass and lipid enhancement in microalga Acutodesmus obliquus under nitrogen stress[J]. Energy Conversion and Management, 2017, 140: 14-23.
15	CHOI S A, OH Y K, JEONG M J, et al. Effects of ionic liquid mixtures on lipid extraction from Chlorella vulgaris [J]. Renewable Energy, 2014, 65: 169-174.
16	孙佼文. 优化碳氮源流加强化裂殖壶菌DHA合成及胞内蛋白差异表达分析[D]. 无锡: 江南大学, 2018.
	SUN Jiaowen. Optimizing carbon and nitrogen sources to enhance DHA synthesis and differential expression of intracellular proteins in Schizochytrium sp.[D]. Wuxi: Jiangnan University, 2018.
17	JIANG L, PEI H, HU W, et al. Effect of diethyl aminoethyl hexanoate on the accumulation of high-value biocompounds produced by two novel isolated microalgae[J]. Bioresource Technology, 2015, 197: 178-184.
18	SALAMA E S, JEON B H, CHANG S W, et al. Interactive effect of indole-3-acetic acid and diethyl aminoethyl hexanoate on the growth and fatty acid content of some microalgae for biodiesel production[J]. Journal of Cleaner Production, 2017, 168: 1017-1024.
19	丁巍, 余旭亚, 彭俊. 胺鲜酯提高雨生红球藻(Haematococcus pluvialis LUGU)虾青素含量的作用[J]. 食品工业科技, 2017, 38(16): 150-153, 166.
	DING Wei, YU Xuya, PENG Jun. Effect of diethyl aminoethyl hexanoate on astaxanthin content in Haematococcus pluvialis LUGU[J]. Science and Technology of Food Industry, 2017, 38(16): 150-153, 166.
20	魏萍, 任路静, 纪晓俊, 等. 强化乙酰辅酶A供应对裂殖壶菌合成二十二碳六烯酸的影响[J]. 中国生物工程杂志, 2011, 31(4): 87-91.
	WEI Ping, REN Lujing, JI Xiaojun, et al. Effect of reinforcing acetyl-CoA supply in docosahexaenoic acid production by Schizochytrium sp.[J]. China Biotechnology, 2011, 31(4): 87-91.
21	WANG K, SUN T, CUI J, et al. Screening of chemical modulators for lipid accumulation in Schizochytrium sp. S31[J]. Bioresource Technology, 2018, 260: 124-129.
22	QIN S, LIN H, JIANG P. Advances in genetic engineering of marine algae[J]. Biotechnology Advances, 2012, 30(6): 1602-1613.
23	JU J H, KO D J, HEO S Y, et al. Regulation of lipid accumulation using nitrogen for microalgae lipid production in Schizochytrium sp. ABC101[J]. Renewable Energy, 2020, 153: 580-587.
24	闵青松. 苹果酸对裂殖壶菌发酵产DHA的影响及其流加策略的研究[D]. 沈阳: 沈阳农业大学, 2016.
	MIN Qingsong. Effect of malic acid on DHA production by Schizochytrium sp. and its fed-batch strategy[D]. Shenyang: Shenyang Agricultural University, 2016.
25	王依霖, 莫创荣, 许雪棠, 等. 2,4-二氯苯氧乙酸与盐胁迫联合提高小球藻的产脂量[J]. 食品与发酵工业, 2022, 48(24): 105-110.
	WANG Yilin, MO Chuangrong, XU Xuetang, et al. 2,4-dichlorophenoxyacetic acid combined with salt stress increased lipid production of Chlorella vulgaris [J]. Food and Fermentation Industries, 2022, 48(24): 105-110.
26	LU Y, XU J. Phytohormones in microalgae: A new opportunity for microalgal biotechnology?[J]. Trends in Plant Science, 2015, 20(5): 273-282.
27	ZHAO Y, WANG H, HAN B, et al. Coupling of abiotic stresses and phytohormones for the production of lipids and high-value by-products by microalgae: A review[J]. Bioresource Technology, 2019, 274: 549-556.
28	ZHAO Y, LI D, XU J, et al. Melatonin enhances lipid production in Monoraphidium sp. QLY-1 under nitrogen deficiency conditions via a multi-level mechanism[J]. Bioresource Technology, 2018, 259: 46-53.
29	LI J, DING D, LI N, et al. Melatonin enhances the low-temperature combined low-light tolerance of pepper (Capsicum annuum L.) seedlings by regulating photosynthesis, carotenoid, and hormone metabolism[J]. Environmental and Experimental Botany, 2022, 199: 104868.
30	吕芳, 丁刚, 詹冬梅, 等. 茉莉酸甲酯对铜藻生长、抗氧化系统及岩藻黄素含量的影响[J]. 植物生理学报, 2019, 55(5): 667-675.
	Fang LYU, DING Gang, ZHAN Dongmei, et al. Effect of methyl jasmonate on the growth, antioxidant system and fucoxanthin content of Sargassum horneri [J]. Plant Physiology Journal, 2019, 55(5): 667-675.
31	WANG X, FOSSE H, LI Ket al. Influence of nitrogen limitation on lipid accumulation and EPA and DHA content in four marine microalgae for possible use in aquafeed[J]. Frontiers in Marine Science, 2019, 6: 95.
32	刘飞, 王超, 王振瑶, 等. 植物激素诱导对小球藻Chlorella vulgaris细胞生物量和油脂合成积累的影响[J]. 中国生物制品学杂志, 2017, 30(4): 390-394.
	LIU Fei, WANG Chao, WANG Zhenyao, et al. Effect of induction with phytohormones analogs on biomass and lipid accumulation in Chlorella vulgaris cells[J]. Chinese Journal of Biologicals, 2017, 30(4): 390-394.
33	宋雪婷. 独脚金内酯调控单针藻Monoraphidium sp. QLY-1产油机制的研究[D]. 昆明: 昆明理工大学, 2020.
	SONG Xueting. Study on the mechanism of strigolactone regulating Monoraphidium sp. QLY-1 oil production[D]. Kunming: Kunming University of Science and Technology, 2020.
34	乔腾生. 肌醇提高单针藻Monoraphidium sp. QLY-1在糖蜜废醪液中油脂积累的过程及机制[D]. 昆明: 昆明理工大学, 2021.
	QIAO Tengsheng. Process and mechanism of inositol improving oil accumulation of Monoraphidium sp. QLY-1 in molasses waste mash[D]. Kunming: Kunming University of Science and Technology, 2021.
35	ZHAO Z, YANG H, FENG Z, et al. Role of naphthaleneacetic acid in the degradation of bisphenol A and wastewater treatment by microalgae: Enhancement and signaling[J]. Chemosphere, 2022, 307: 135829.