基于制备超细复合含能材料的对置受限式撞击流反应器微观混合性能

doi:10.16085/j.issn.1000-6613.2020-0896

摘要/Abstract

摘要：

由于对置受限式撞击流反应器较高的传热及混合效率，能够制备出粒径小、均匀且分布范围窄的超细颗粒。本文采用碘化物-碘酸盐平行竞争反应体系研究入射速度、结构尺寸对对置受限式撞击流反应器微观混合效果的影响规律，并将混合腔尺寸同等比例放大一倍进行对比研究。结果表明，随着入射速度的增大，离集指数减小，微观混合效果提高。喷嘴间距与喷嘴直径比的增大使得离集指数增大，微观混合效果降低。离集指数随着混合腔高度、混合腔出口尺寸的增大呈现先增大后减小的趋势，且混合腔高度对混合效果的影响较混合腔出口尺寸显著。将对置受限式撞击流反应器混合腔尺寸扩大一倍，离集指数增加到原来的2.4倍，微观混合效果显著下降，但是在较大入射速度下，两种结构的混合效果差距减小。研究结果可为纳米复合含能材料的制备提供高效、安全的技术支持。

关键词: 含能材料, 对置受限式撞击流反应器, 微观混合, 离集指数, 超细颗粒

Abstract:

Because of the advantages of high heat transfer and mixing efficiency, the ultrafine particles with small particle size, uniform and narrow distribution range can be prepared by opposed confined impinging jets reactor. The effect of jet velocity and structure size on micromixing quality was investigated by using iodide-iodate parallel-competitive reactions. Micromixing efficiency was compared with that of the mixing chamber size by the same proportion to one time. The experimental results show that the segregation index decreases with jet velocity increases, so that micromixing quality enhances. The increasing of nozzle distance to nozzle diameter ratio results increasing of segregation index, and micromixing efficiency decreases. As mixing chamber height and outlet size increases, segregation index first increases and then reduces. The effect of mixing chamber height on micromixing efficiency is more significant than that of mixing chamber outlet size. The value of the segregation index in magnifying opposed confined impinging jets reactor is 2.4 times larger than that of original opposed confined impinging jets reactor, it demonstrates the significant decreasing of micromixing quality. The results can provide efficient and safe technical support for the preparation of nanocomposite energy-containing materials.

Key words: energy-containing materials, opposed confined impinging jets reactor, micromixing, segregation index, ultrafine particles

中图分类号:

TQ027

梁鹏飞, 张阿芳, 陈锦芳, 郭新俊, 刘所恩. 基于制备超细复合含能材料的对置受限式撞击流反应器微观混合性能[J]. 化工进展, 2020, 39(S2): 42-47.

Pengfei LIANG, Afang ZHANG, Jinfang CHEN, Xinjun GUO, Suo’en LIU. Micromixing efficiency of opposed confined impinging jets reactor base on ultrafine energy-containing materials[J]. Chemical Industry and Engineering Progress, 2020, 39(S2): 42-47.

图/表 7

图1 对置式受限式撞击流反应器参数示意图

图2 实验流程图1,2—储液槽；3,4—泵；5,6—液体转子流量计；7—对置受限式撞击流反应器；8—液体出口

图3 入射速度对XS的影响

图4 喷嘴间距w/d对XS的影响

图5 混合腔高度H对XS的影响

图6 混合腔出口尺寸δ对XS的影响

图7 不同结构尺寸对置受限式撞击流反应器微观混合性能对比

参考文献 25

1	刘志建. 超细材料与超细炸药技术[J] .火炸药学报, 1995(4): 37-40.
	LIU Zhijiang. Superfine materials and superfine explosive technology[J]. Chinese Journal of Explosives and Propellants, 1995 (4): 37-40.
2	李凤生. 超细粉体技术[M]. 北京: 国防工业出版社, 2000.
	LI Fengsheng. Technology of superfine powder[M]. Beijing: National Defense Industry Press, 2000.
3	宋小兰, 王毅, 刘丽霞, 等. 机械球磨法制备纳米TATB及其表征[J]. 固体火箭技术, 2017, 40(4): 471-475.
	SONG Xiaolan, WANG Yi, LIU Lixia, et al. Preparation and characterization of nanometer TATB by mechanical ball milling [J]. Journal of Solid Rocket Technology, 2017, 40(4): 471-475.
4	李凤生，刘杰. 微纳米含能材料研究进展[J]. 含能材料, 2018, 26(12): 1061-1073.
	LI Fengsheng, LIU Jie. Advances in micro-nano energetic materials[J]. Chinese Journal of Energetic Materials, 2018, 26(12): 1061-1073.
5	晋苗苗, 罗运军. 硝化棉/黑索今纳米复合含能材料的制备与热性能研究[J]. 兵工学报, 2014, 35(6): 822-827.
	JIN Miaomiao, LUO Yunjun. Preparation and thermal properties of NC/RDX nano-composite energetic materials[J]. Acta Armamentrii, 2014, 35(6): 822-827.
6	张硕, 丁亚军, 应三九. 微孔NC/TEGN/RDX复合材料的制备及力学性能[J]. 含能材料, 2019, 27(3): 210-221.
	ZHANG Shuo, DING Yajun, YING Sanjiu. Fabrication and mechanical properties of micro-porous NC/TEGN/RDX composites[J]. Chinese Journal of Energetic Materials, 2019, 27(3): 210:221.
7	TAMIR A. 撞击流反应器：原理和应用[M]. 伍沅译. 北京: 化学工业出版社, 1995.
	TAMIR A. Impinging stream reactor: principle and Application[M]. WU Yuan, trans. Beijing: Chemical Industry Press, 1995.
8	伍沅. 撞击流: 原理, 性质, 应用[M]. 北京: 化学工业出版社, 2006.
	WU Yuan. Impinging streams: principles, properties, applications[M]. Beijing: Chemical Industry Press, 2006.
9	王立达. 撞击流-旋转填料床制备乳化柴油的基础研究[D]. 太原: 中北大学, 2009.
	WANG Lida. Basic study on the emul sifiedfuel in impinging stream-rotating packed bed[D]. Taiyuan: North University of China, 2006.
10	祁贵生, 刘有智, 焦纬洲. 撞击流-旋转填料床内络合萃取法分离醋酸稀溶液实验研究[J]. 现代化工, 2008, 28(11): 65-67.
	QI Guisheng, LIU Youzhi, JIAO Weizhou. Experimental research on extraction of acetic acid from dilute solution by chemical complexation impinging stream-rotating packed bed[J]. Modem Chemical Industry, 2008, 28(11): 65-67.
11	霍红, 欧阳朝斌, 刘有智. 纳米硫酸钡的制备工艺及其应用[J]. 山东化工, 2004, 33(6): 23-25.
	HUO Hong, OUYANG Zhaobin, LIU Youzhi. Preparation and application of nanometer BaSO₄[J]. Shandong Chemical Industry, 2004, 33(6): 23-25.
12	董秀芳, 郭雨, 刘有智等. 撞击流-旋转填料床无机包覆超细氧化钛实验研究[J]. 化工科技, 2005, 13(1): 22-25.
	DONG Xiufang, GUO Yu, LIU Youzhi, et al. Studies on inorganic coating of ultrafine TiO₂ with SiO₂ by impinging streams-rotating packed bed technology[J]. Science & Technology in Chemical Industry, 2005, 13(1): 22-25.
13	郭雨. IS-RPB反应器制备燃速催化剂2,4-二羟基苯甲酸铜超细粉末的研究[D]. 太原: 中北大学, 2006.
	GUO Yu. Preparation of combustion catalyst β-Cu ultrafine powders in impinging steam-rotating packed bed[D]. Taiyuan: North University of China, 2006.
14	康荣灿, 刘有智, 郭雨等. 撞击流-旋转填料床合成超细平台燃烧催化剂β-Cu[J]. 化工科技, 2006, 14(4): 1-5.
	KANG Rongcan, LIU Youzhi, GUO Yu, et al. Synthesis of ultrafine β-Cu in impinging stream-rotating packed bed[J]. Science & Technology in Chemical Industry, 2006, 14(4): 1-5.
15	白俊红. 改性超细氢氧化镁阻燃剂的制备[D]. 太原: 中北大学, 2014.
	BAI Junhong. The Preparation of modified ultrafine magnesium hydroxide flame retardant[D]. Taiyuan: North University of China, 2014.
16	LV J, HU C, BAI M, et al. Experimental investigation of free single jet impingement using SiO₂-watet nanofluid[J]. Experimental thermal and fluid science, 2017, 84: 39-46.
17	XU Y, WANG J. Digital particle image velocimetry study on parameter influence on the behavior of impinging synthetic jets[J]. Experimental Thermal and Fluid Science, 2019, 100: 11-32.
18	张小宁, 王卫民, 徐更光. 高速撞击流技术制备炸药超细微粉的研究[J]. 火炸药学报, 1999, 22(3): 1-4.
	ZHANG Xiaoning, WANG Weimin, XU Gengguang. Study on the preparation of ultrafine particle of explosive using the technology of high-speed impinging streams[J]. Chinese Journal of Explosives and Propellants, 1999, 22(3): 1-4.
19	陈潜, 何得昌, 徐更光, 等. 高速撞击流法制备超细HMX炸药[J]. 火炸药学报, 2004, 27(2): 23-25.
	CHEN Qian, HE Dechang, XU Gengguang, et al. Preparation of ultrafine particle of HMX explosive using the technology of high-speeding impinging streams[J]. Chinese Journal of Explosives and Propellants, 2004, 27(2): 23-25.
20	张小宁, 徐更光, 王廷增. 高速撞击流制备超细硝胺炸药的实验研究[J]. 含能材料, 1999, 7(3): 97-99, 102.
	ZHANG Xiaoning, XU Gengguang, WANG Tingzeng. A study on preparation of ultra-fine nitroamine explosives by using high-speed impinging stream[J]. Chinese Journal of Energetic Materials, 1999, 7(3): 97-99, 102.
21	韩迎龙, 李进贤, 曹琪, 等. 高压水射流撞击推进剂壁面稳态流场的数值模拟[J]. 火炸药学报, 2010, 33(5): 56-64.
	HAN Yinglong, LI Jinxian, CAO Qi, et al. Numerical simulation on steady flow field of high pressure water-jet impacting propellant wall[J]. Chinese Journal of Explosives and Propellants, 2010, 33(5): 56-64.
22	伊吉明, 白富强, 常青等. 撞击式射流速度特性及液滴粒度特性的试验[J]. 内燃机学报, 2013, 31(6): 519-524.
	YI Jiming, BAI Fuqiang, CHANG Qing, et al. Experiment on velocity and size distribution of droplets produced by an impinging liquid jet[J]. Transactions of CSICE, 2013, 31(6): 519-524.
23	李裕, 郭雨, 刘有智. 超细2,4-二羟基苯甲酸铜粉体的合成及表征[J]. 火炸药学报, 2006. 6(3): 32-35.
	LI Yu, GU Yu, LIU Youzhi. Synthesis and characterization of ultrafine cupric 2,4-dihydroxy-benzoate(β-Cu)[J]. Chinese Journal of Explosives and Propellants, 2006, 6(3): 32-35.
24	FOURNIER M C, FALK L, Jacques Villermaux. A new parallel competing reaction system for assessing micromixing efficiency-Determination of micromixing time by a simple mixing model[J]. Chemical Engineering Science, 1996, 51(22): 5053-5064.
25	VILLERMAUX J, FALK L. A generalized mixing model for initial contacting of reactive fluids[J]. Chemical Engineering Science, 1990, 49(248): 5127-5140.

[1]	刘卫孝, 刘洋, 高福磊, 汪伟, 汪营磊. 微反应器在含能材料合成与品质提升中的应用[J]. 化工进展, 2023, 42(7): 3349-3364.
[2]	曲晏利, 姜跃佳, 程景才, 杨超. 反应与溶析结晶过程强化及数值模拟研究进展[J]. 化工进展, 2020, 39(12): 4970-4982.
[3]	黄正梁, 聂元清, 杨遥, 孙婧元, 王靖岱, 蒋斌波, 阳永荣. 液-液喷射混合装置微观混合特性的研究进展[J]. 化工进展, 2018, 37(S1): 1-11.
[4]	伍沅，周玉新，郭嘉，袁军. 液体连续相撞击流强化过程特性及相关技术装备的研发和应用 [J]. 化工进展, 2011, 30(3): 463-.
[5]	李林，董勇，崔琳，张立强，马春元. 荷电水雾脱除超细颗粒物的研究进展 [J]. 化工进展, 2010, 29(6): 1143-.
[6]	齐国杰，董勇，崔琳，马春元. 超细颗粒物增湿团聚技术研究进展 [J]. 化工进展, 2009, 28(5): 745-.
[7]	杨宗阳，胡婷婷，乐园，刘淼，沈志刚，陈建峰. 反应结晶法制备琥珀酸舒马普坦干粉吸入剂及其评价 [J]. 化工进展, 2008, 27(9): 1412-.
[8]	谷磊，刘有智，申红艳，张红宇. 陶瓷膜处理乳化悬浮液过程中的膜清洗工艺 [J]. 化工进展, 2007, 26(2): 226-.