LiCl溶液除湿系统的试验研究

doi:10.16085/j.issn.1000-6613.2016-2232

化工进展 ›› 2017, Vol. 36 ›› Issue (S1): 92-100.DOI: 10.16085/j.issn.1000-6613.2016-2232

LiCl溶液除湿系统的试验研究

侯小兵, 邹同华, 韩雨松

天津商业大学, 天津市制冷技术重点实验室, 天津 300134

收稿日期:2016-12-02 修回日期:2017-03-18 出版日期:2017-12-31 发布日期:2017-12-13
通讯作者: 邹同华,教授,主要从事除湿空调研究。
作者简介:侯小兵(1990-),男,硕士研究生,主要从事溶液除湿研究。E-mail:hxb2016@outlook.com。

Experimental investigation on LiCl liquid desiccant air dehumidification system

HOU Xiaobing, ZOU Tonghua, HAN Yusong

Tianjin Key Laboratory of Refrigeration Technology, Tianjin University of Commerce, Tianjin 300134, China

Received:2016-12-02 Revised:2017-03-18 Online:2017-12-31 Published:2017-12-13

摘要/Abstract

摘要： 溶液除湿空气调节装置具有不受气候和地域限制的特点，是最可能被大规模推广的空气调节技术之一。本文进行了逆流填料式单级LiCl溶液除湿过程实验研究，针对除湿过程，研究了进口空气的温度（30～36℃）和相对湿度（50%～70%）对除湿性能的影响。结果表明，除湿性能会随着进口空气温度或相对湿度的升高而增强。此外，针对溶液再生过程，本文考察了再生风进口温度和再生溶液进口温度对再生性能的影响，结果表明，两个温度值的升高均会增大再生能力，且后者的作用更强，但是再生溶液出口温度也会随之上升，从而导致了系统冷源负荷的增大。

关键词: 溶液除湿, 除湿性能, 溶液再生

Abstract: The liquid desiccant air handing device, which can be utilized without the restriction of climatic and geographical regions, is one of the most likely air-conditioning technologies to be promoted in large-scale application.In this paper, the single-stage LiCl solution desiccant process of countercurrent packing is studied through experiments.For the desiccant process, influence of the temperature (30-36℃) and relative humidity (50%-70%) of the inlet air on the dehumidification process is investigated.It is resulted that dehumidifying performance is enhanced with the increase of the temperature or relative humidity of the inlet air.In addition, for the solution regeneration process, the effect of inlet temperature of the regeneration air and solution on the regeneration process is studied.It is shown that, the rise of either temperature can increase the regeneration ability, but the effect from the temperature of the regeneration solution is stronger.However, the outlet temperature of the regenerated solution is also increased accordingly, which can lead to a larger amount of cooling load.

Key words: liquid desiccant, dehumidifying performance, solution regeneration

中图分类号:

TQ028

侯小兵, 邹同华, 韩雨松. LiCl溶液除湿系统的试验研究[J]. 化工进展, 2017, 36(S1): 92-100.

HOU Xiaobing, ZOU Tonghua, HAN Yusong. Experimental investigation on LiCl liquid desiccant air dehumidification system[J]. Chemical Industry and Engineering Progress, 2017, 36(S1): 92-100.

参考文献

[1] 刘晓华,江亿.温湿度独立控制空调系统[M].北京:中国建筑工业出版社,2006. LIU X H,JIANG Y.Temperature and humidity independent control air conditioning system[M].Beijing:China Building Industry Press,2006.
[2] 黄志甲,鲁月红,雷博,等.溴化锂溶液除湿器性能的实验研究[J].化工学报,2010,61(s2):81-85. HUANG Z J,LU Y H,LEI B,et al.Experiment on performance of LiBr-liquid desiccant dehumidification[J].CIESC Journal,2010,61(s2):81-85.
[3] TREYBAL R E.Adiabatic gas absorption and stripping in packed towers[J].Industrial and Engineering Chemistry,1969:61-68.
[4] 刘晓华.溶液调湿式空气处理过程中热湿耦合传递特性分析[D].北京:清华大学建筑学院,2007. LIU X H.Analysis of coupled heat and moisture transfer characteristics in wet air conditioning process[D].Beijing:School of Architecture,Tsinghua University,2007.
[5] 钱俊飞,殷勇高,潘雄伟,等.平板降膜溶液除湿再生过程实验研究及模拟验证[J].化工学报,2014,65(6):2070-2077. QIAN J F,YIN Y G,PAN X W,et al.Experimental investigation and model validation for liquid desiccant dehumidification and regeneration in falling-film plate[J].CIESC Journal,2014,65(6):2070-2077.
[6] 高文忠,柳建华,邬志敏,等.液体除湿再生性能的理论与实验差异性分析[J].暖通空调,2009,39(7):85-89. GAO W Z,LIU J H,WU Z M,et al.Difference analysis of theoretical and experimental results of the liquid desiccant regenerative performance[J].HVAC,2009,39(7):85-89.
[7] MEHTA J R,RANE M V.Liquid desiccant based solar air conditioning system with novel evacuated tube collector as regenerator[J].Procedia Engineering,2013,51:688-693.
[8] 彭冬根,曹熔泉,张小松,等.基于热不平衡考虑的溶液除湿/再生传热传质系数(Ⅱ)实验与模型计算分析[J].化工学报,2011,62(9):2441-2446. PENG D G,CAO R Q,ZHANG X S,et al.Heat and mass transfer coefficients of liquid desiccant dehumidification/regeneration processes with non-thermal equilibrium(Ⅱ)Experiments and calculation result[J].CIESC Journal,2011,62(9):2441-2446.
[9] LAZZARIN R M,CASTELLOTTI F.A new heat pump desiccant dehumidifier for supermarket application[J].Energy and Buildings,2007,39:59-65.
[10] KUMAR R,DHAR P L,JAIN S,et al.Multi absorber standalone liquid desiccant air-conditioning system s for higher performance[J].Solar Energy,2009,83:761-772.
[11] 易晓勤.常用溶液除湿剂的性质研究[D].北京:清华大学建筑学院,2009. YI X Q.Study on the properties of commonly used desiccant[D].Beijing:School of Architecture,Tsinghua University,2009.
[12] ERTAS A,ANDERSON E E,KIRIS I.Properties of a new liquid desiccant solution lithium chloride and calcium chloride mixture[J].Solar Energy,1992,49(3):205-212.
[13] 裴清清,韩俊召.太阳能集热型溶液再生器性能实验研究[J].广州大学学报(自然科学版),2007,6(6):79-82. PEI Q Q,HAN J Z.Experimental research on heat and mass transfer for solar energy regenerator[J].Journal of Guangzhou University(Natural Science Edition),2007,6(6):79-82.

LiCl溶液除湿系统的试验研究

Experimental investigation on LiCl liquid desiccant air dehumidification system

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 3

编辑推荐

Metrics

本文评价

[1]	邹国文, 邹同华, 韩雨松, 邓赛峰, 曹国振. 不同工况下除湿溶液再生的模拟与实验[J]. 化工进展, 2016, 35(07): 1963-1968.
[2]	左远志，杨晓西，丁静. 槽式集热器与燃气锅炉联合驱动的双效型溶液再生系统 [J]. 化工进展, 2009, 28(9): 1559-.
[3]	左远志，杨晓西，丁静. 新型太阳能槽式与平板式联合集热溶液双效再生系统 [J]. 化工进展, 2009, 28(10): 1734-.