Electrochemical synergistic persulfate oxidation process for treatment of salty organic wastewater

doi:10.16085/j.issn.1000-6613.2019-0444

Chemical Industry and Engineering Progress ›› 2019, Vol. 38 ›› Issue (12): 5572-5577.DOI: 10.16085/j.issn.1000-6613.2019-0444

• Resources and environmental engineering • Previous Articles Next Articles

Electrochemical synergistic persulfate oxidation process for treatment of salty organic wastewater

Xi CHEN^1,^2,^3,⁴(),Zhiyong JI^1,^2,^3,⁴(),Zhihui HUANG^1,^2,⁴,Yingying ZHAO^1,^2,⁴,Jie LIU^1,^2,⁴,Junsheng YUAN^1,^2,⁴

1. National-Local Joint Engineering Laboratory of Chemical Energy Saving Process Integration and Resource Utilization, School of Chemical Engineering and Technology, Hebei University of Technology, Tianjin 300130, China
2. Engineering Research Center of Seawater Utilization of Ministry of Education, School of Chemical Engineering and Technology, Hebei University of Technology, Tianjin 300130, China
3. State Key Laboratory of Petroleum Pollution Control, Beijing 102206, China
4. Hebei Collaborative Innovation Center of Modern Marine Chemical Technology, Tianjin 300130, China

Received:2019-03-24 Online:2019-12-05 Published:2019-12-05
Contact: Zhiyong JI

电化学协同过硫酸盐氧化法处理含盐有机废水

陈希^1,^2,^3,⁴(),纪志永^1,^2,^3,⁴(),黄智辉^1,^2,⁴,赵颖颖^1,^2,⁴,刘杰^1,^2,⁴,袁俊生^1,^2,⁴

1. 河北工业大学化工学院，化工节能过程集成与资源利用国家-地方联合工程实验室，天津 300130
2. 河北工业;大学化工学院，海水资源高效利用化工技术教育部工程研究中心，天津 300130
3. 石油石化污染物控制与处理;国家重点实验室，北京 102206
4. 河北省现代海洋化工技术协同创新中心，天津 300130

通讯作者: 纪志永
作者简介:陈希（1994—），女，硕士研究生，研究方向为环境化学工程。E-mall：925778198@qq.com。
基金资助:
国家重点研发计划(2016YFB0600504);河北省青年拔尖人才支持计划(2016-9)

Abstract

Abstract:

In recent years, the discharge of wastewater has increased with the continuous development of coal chemical industry. Wastewater treatment has become a hot and difficult spot for the large emissions, high salt and high COD. Based on the actual ingredients of the salty organic wastewater (TDS content is 25000mg/L) from a plant located in Yili (Sinkiang), 2-methoxyphenol was chosen as a typical organic in coal chemical wastewater. The method of electrochemistry synergistic persulfate oxidation was investigated to degrade 2-methoxyphenol. The influence of voltage, initial concentration of sodium persulfate, electrode distances and initial pH on the degradation ratio of 2-methoxyphenol were discussed. Considering the electronic consumption and oxidant cost, the suitable degradation conditions of 2-methoxyphenol were the voltage of 2V, electrode distance of 3cm, initial sodium persulfate concentration of 5g/L, pH=12 and reaction time of 3h, and the degradation ratio could reach 97.5%. Compared with the single method of electrochemistry or persulfate oxidation, this method has obvious improvement on the degradation of 2-methoxyphenol and shows a synergistic effect. These results could provide a new method on environmental and efficiency wastewater treatment of coal chemical industry in the future.

Key words: electrochemistry, persulfate oxidation, synergistic, salty organic wastewater, 2-methoxyphenol, radical

摘要：

近年来，随着煤化工行业不断发展，废水排放量加大。煤化工行业废水排放量大、高盐和高化学需氧量的现状使得对其的处理成为一大热点和难点。本文以伊犁某工厂实际含盐有机废水（TDS含量25000mg/L）成分为依据，选取2-甲氧基苯酚作为煤化工废水中典型有机物，采用电化学协同过硫酸盐法处理含盐有机废水，主要考察电压、初始过硫酸钠浓度、极板间距及初始pH对2-甲氧基苯酚降解率的影响。结果表明，综合考虑电能消耗及氧化剂成本，在2V电压、极板间距3cm、过硫酸钠投加量5g/L、pH=12以及反应3h条件下，2-甲氧基苯酚的降解率可达到97.5%，相较单一的电化学法或过硫酸盐氧化法均有显著提升，协同效应明显。本文研究结果为今后煤化工行业含盐有机废水的绿色高效处理提供了一种新的思路。

关键词: 电化学, 过硫酸盐氧化, 协同, 含盐有机废水, 2-甲氧基苯酚, 自由基

CLC Number:

X784

Xi CHEN,Zhiyong JI,Zhihui HUANG,Yingying ZHAO,Jie LIU,Junsheng YUAN. Electrochemical synergistic persulfate oxidation process for treatment of salty organic wastewater[J]. Chemical Industry and Engineering Progress, 2019, 38(12): 5572-5577.

陈希,纪志永,黄智辉,赵颖颖,刘杰,袁俊生. 电化学协同过硫酸盐氧化法处理含盐有机废水[J]. 化工进展, 2019, 38(12): 5572-5577.

Figures/Tables 7

References 25

1	姜忠义, 李玉平, 陈志强, 等. 煤化工废水近零排放与资源化关键技术研究与应用示范[J]. 化工进展, 2016, 35(12): 4099-4100.
	JIANG Z Y, LI Y P, CHEN Z Q, et al. Key technologies study and application demonstration of near-zero-liquid-discharge and resource recovery of coal chemical industry wastewater[J]. Chemical Industry and Engineering Progress, 2016, 35(12): 4099-4100.
2	任同伟, 俞彬, 阳春芳, 等. 煤化工高含盐废水资源化处理技术的工程应用研究[J]. 工业水处理, 2019, 39(2): 96-99.
	REN T W, YU B, YANG C F, et al. Research on the engineering application of the recycling treatment technology of high salinity wastewater in coal chemical industry[J]. Industrial Water Treatment, 2019, 39(2): 96-99.
3	纪钦洪, 于广欣, 张振家. 煤化工含盐废水处理与综合利用探讨[J]. 水处理技术, 2014, 40(11): 8-12.
	JI Q H, YU G X, ZHANG Z J. Discussion on treatment and comprehensive utilization of salty wastewater from coal chemical industry[J]. Technology of Water Treatment, 2014, 40(11): 8-12.
4	王香莲, 湛含辉, 刘浩. 煤化工废水处理现状及发展方向[J]. 现代化工, 2014, 34(3): 1-4.
	WANG X L, ZHAN H H, LIU H. Current situation and development direction of coal chemical industry wastewater treatment[J]. Modern Chemical Industry, 2014, 34(3): 1-4.
5	YEO I, YOON S, YEE J. Development of an urban energy demand forecasting system to support environmentally friendly urban planning[J]. Applied Energy, 2013, 110: 304-317.
6	陈思. 基于膜处理的煤化工含盐废水的处理技术[J]. 化工设计通讯, 2019, 45(1): 6.
	CHEN S. Treatment technology of coal chemical salty wastewater based on membrane treatment[J]. Chemical Engineering Design Communications, 2019, 45(1): 6.
7	JIN X, LI E, LU S, et al. Coking wastewater treatment for industrial reuse purpose: combining biological processes with ultrafiltration, nanofiltration and reverse osmosis[J]. Journal of Environmental Sciences, 2013, 25(8): 1565-1574.
8	WANG W, HAN H, YUAN M, et al. Treatment of coal gasification wastewater by a two-continuous UASB system with step-feed for COD and phenols removal[J]. Bioresource Technology, 2011, 102(9): 5454-5460.
9	HOU B, DENG R, ZHUANG H, et al. Advanced treatment of coal chemical industry wastewater by electro-catalysis with Gd-doped Ti/SnO₂ anode[J]. Polish Journal of Environmental Studies, 2017, 26(3): 1097-1104.
10	杨世迎, 陈友媛, 胥慧真, 等. 过硫酸盐活化高级氧化新技术[J]. 化学进展, 2008(9): 1433-1438.
	YANG S Y, CHEN Y Y, XU H Z, et al. A novel advanced oxidation technology based on activated persulfate[J]. Progress in Chemistry, 2008(9): 1433-1438.
11	OLMEZ-HANCI T, ARSLAN-ALATON I. Comparison of sulfate and hydroxyl radical based advanced oxidation of phenol[J]. Chemical Engineering Journal, 2013, 224: 10-16.
12	HOELDERICH W F, KOLLMER F. Oxidation reactions in the synthesis of intermediate and fine chemicals using environmentally benign oxidants and the right reactor system[J]. Pure Appl. Chem., 2000, 72(7): 1273-1287.
13	ABU A S S, AZIZ H A, ADLAN M N. Optimization of stabilized leachate treatment using ozone/persulfate in the advanced oxidation process[J]. Waste Management, 2013, 33(6): 1434-1441.
14	DING Y, ZHU L, HUANG A, et al. A heterogeneous Co₃O₄-Bi₂O₃ composite catalyst for oxidative degradation of organic pollutants in the presence of peroxymonosulfate[J]. Catalysis Science & Technology, 2012, 2(9): 1977-1984.
15	ROMERO A, SANTOS A, VICENTE F, et al. Diuron abatement using activated persulphate: effect of pH, Fe(Ⅱ) and oxidant dosage[J]. Chemical Engineering Journal, 2010, 162(1): 257-265.
16	HORI H, YAMAMOTO A, KOIKE K, et al. Persulfate-induced photochemical decomposition of a fluorotelomer unsaturated carboxylic acid in water[J]. Water Research, 2007, 41(13): 2962-2968.
17	MA J, YANG Y, JIANG X, et al. Impacts of inorganic anions and natural organic matter on thermally activated persulfate oxidation of BTEX in water[J]. Chemosphere, 2018, 190: 296-306.
18	LIU H, BRUTON T A, LI W, et al. Oxidation of benzene by persulfate in the presence of Fe(Ⅲ)- and Mn(Ⅳ)-containing oxides: stoichiometric efficiency and transformation products[J]. Environmental Science & Technology, 2016, 50(2): 890-898.
19	吴娜娜, 钱虹, 王宇思, 等. 电化学协同过硫酸盐处理有机废水的研究进展[J]. 建筑与预算, 2017(9): 29-33.
	WU N N, QIAN H, WANG Y S, et al. Research progress in electrochemical synergistic persulfate treatment of organic wastewater[J]. Construction and Budget, 2017(9): 29-33.
20	朱应良, 万金泉, 马邕文, 等. 电化学协同过硫酸盐法氧化处理橙黄G染料废水[J]. 水处理技术, 2016, 42(8): 48-51.
	ZHU Y L, WAN J Q, MA Y W, et al. Electrochemical synergistic persulfate oxidation treatment of orange G dye wastewater[J]. Technology of Water Treatment, 2016, 42(8): 48-51.
21	FAN Y, JI Y, KONG D, et al. Kinetic and mechanistic investigations of the degradation of sulfamethazine in heat-activated persulfate oxidation process[J]. Journal of Hazardous Materials, 2015, 300: 39-47.
22	YANG S, CUI Y, LIU Y, et al. Electrochemical generation of persulfate and its performance on 4-bromophenol treatment[J]. Separation and Purification Technology, 2018, 207: 461-469.
23	LIN H, WU J, ZHANG H. Degradation of clofibric acid in aqueous solution by an EC/Fe³⁺/PMS process[J]. Chemical Engineering Journal, 2014, 244: 514-521.
24	SILVA-RACKOV C K O DA, LAWAL W A, NFODZO P A, et al. Degradation of PFOA by hydrogen peroxide and persulfate activated by iron-modified diatomite[J]. Applied Catalysis B: Environmental, 2016, 192: 253-259.
25	NIE M, YANG Y, ZHANG Z, et al. Degradation of chloramphenicol by thermally activated persulfate in aqueous solution[J]. Chemical Engineering Journal, 2014, 246: 373-382.

[1]	ZHANG Mingyan, LIU Yan, ZHANG Xueting, LIU Yake, LI Congju, ZHANG Xiuling. Research progress of non-noble metal bifunctional catalysts in zinc-air batteries [J]. Chemical Industry and Engineering Progress, 2023, 42(S1): 276-286.
[2]	HU Xi, WANG Mingshan, LI Enzhi, HUANG Siming, CHEN Junchen, GUO Bingshu, YU Bo, MA Zhiyuan, LI Xing. Research progress on preparation and sodium storage properties of tungsten disulfide composites [J]. Chemical Industry and Engineering Progress, 2023, 42(S1): 344-355.
[3]	ZHANG Jie, BAI Zhongbo, FENG Baoxin, PENG Xiaolin, REN Weiwei, ZHANG Jingli, LIU Eryong. Effect of PEG and its compound additives on post-treatment of electrolytic copper foils [J]. Chemical Industry and Engineering Progress, 2023, 42(S1): 374-381.
[4]	BAI Zhihua, ZHANG Jun. Oxidative removal of NO in DTPMPA/Fenton system [J]. Chemical Industry and Engineering Progress, 2023, 42(9): 4967-4973.
[5]	WANG Yaogang, HAN Zishan, GAO Jiachen, WANG Xinyu, LI Siqi, YANG Quanhong, WENG Zhe. Strategies for regulating product selectivity of copper-based catalysts in electrochemical CO₂ reduction [J]. Chemical Industry and Engineering Progress, 2023, 42(8): 4043-4057.
[6]	LIU Yi, FANG Qiang, ZHONG Dazhong, ZHAO Qiang, LI Jinping. Cu facets regulation of Ag/Cu coupled catalysts for electrocatalytic reduction of carbon dioxide [J]. Chemical Industry and Engineering Progress, 2023, 42(8): 4136-4142.
[7]	ZHANG Yajuan, XU Hui, HU Bei, SHI Xingwei. Preparation of NiCoP/rGO/NF electrocatalyst by eletroless plating for efficient hydrogen evolution reaction [J]. Chemical Industry and Engineering Progress, 2023, 42(8): 4275-4282.
[8]	WANG Shuaiqing, YANG Siwen, LI Na, SUN Zhanying, AN Haoran. Research progress on element doped biomass carbon materials for electrochemical energy storage [J]. Chemical Industry and Engineering Progress, 2023, 42(8): 4296-4306.
[9]	LI Haidong, YANG Yuankun, GUO Shushu, WANG Benjin, YUE Tingting, FU Kaibin, WANG Zhe, HE Shouqin, YAO Jun, CHEN Shu. Effect of carbonization and calcination temperature on As(Ⅲ) removal performance of plant-based Fe-C microelectrolytic materials [J]. Chemical Industry and Engineering Progress, 2023, 42(7): 3652-3663.
[10]	XU Peiyao, CHEN Biaoqi, KANKALA Ranjith Kumar, WANG Shibin, CHEN Aizheng. Research progress of nanomaterials for synergistic ferroptosis anticancer therapy [J]. Chemical Industry and Engineering Progress, 2023, 42(7): 3684-3694.
[11]	XU Wei, LI Kaijun, SONG Linye, ZHANG Xinghui, YAO Shunhua. Research progress of photocatalysis and co-electrochemical degradation of VOCs [J]. Chemical Industry and Engineering Progress, 2023, 42(7): 3520-3531.
[12]	ZHANG Peng, PAN Yuan. Progress of single atom catalysts in electrocatalytic oxygen reduction to hydrogen peroxide [J]. Chemical Industry and Engineering Progress, 2023, 42(6): 2944-2953.
[13]	CHEN Shaohua, WANG Yihua, HU Qiangfei, HU Kun, CHEN Li’ai, LI Jie. Research progress on detection of Cr(Ⅵ) by electrochemically modified electrode [J]. Chemical Industry and Engineering Progress, 2023, 42(5): 2429-2438.
[14]	LI Huahua, LI Yihang, JIN Beichen, LI Longxin, CHENG Shao’an. Research progress of Anammox bio-electrochemical coupling wastewater treatment system [J]. Chemical Industry and Engineering Progress, 2023, 42(5): 2678-2690.
[15]	GUO Pengju, HE Xiaobo, YIN Fengxiang. Research progress in MOF-based catalysts for electrocatalytic nitrogen reduction to ammonia [J]. Chemical Industry and Engineering Progress, 2023, 42(4): 1797-1810.

Electrochemical synergistic persulfate oxidation process for treatment of salty organic wastewater

电化学协同过硫酸盐氧化法处理含盐有机废水

RichHTML

PDF (PC)

Knowledge

Abstract

Cite this article

share this article

Figures/Tables 7

References 25

Related Articles 15

Recommended Articles

Metrics

Comments