Research progress of flow and heat transfer characteristics with self-rewetting fluid

doi:10.16085/j.issn.1000-6613.2017-0682

Abstract

Abstract: Self-rewetting fluid is the non-azeotropic solutions satisfied to enjoy a particular surface tension behavior-an increase in the surface tension with increasing temperature. In the case of non-azeotropic compositions,preferential evaporation of more volatile component takes place. Preferential evaporation results in a composition gradient along the liquid/vapor interface,and the surface tension gradient due to the composition gradient induces Marangoni flow that is expected to enhance boiling heat transfer. Moreover,due to the particular surface tension behavior,the thermocapillary effect induces a liquid inflow to the bubble-heater contact area,which induce the liquid spontaneously move to the high temperature dry out region. In this paper,the researches on the flow and heat transfer characteristics of the self-rewetting fluids in the recent decades were summarized,mainly including heat transfer mechanism of the single component fluids,multi component fluids and self-rewetting fluids,the preparation of self-rewetting fluid and flow and heat transfer characteristics of self-rewetting fluid. Furthermore,the applications of self-rewetting fluid in wickless structure,different angles of inclination,microgravity conditions and different types of heat pipes were introduced in detail.

Key words: self-rewetting fluid, heat transfer mechanism, Marangoni effect, surface tension, visualization

摘要： 自湿润流体是指某些具有自发润湿高温端特性的非共沸的混合溶液。这类溶液各组分的沸点不同，易挥发的组分优先发生沸腾，优先沸腾的组分在气液界面引起组分浓度梯度，再由组分的浓度梯度引起表面张力梯度；同时在气液界面产生温度梯度即热毛细作用也引起了表面张力梯度。由于受到双重表面张力梯度的影响，该溶液高温区域与低温区域之间产生了一股较大的推动力，从而使液体自发地向高温区域流动，湿润烧干部位，增强了沸腾传热。本文对自湿润流体流动与传热特性的相关研究现状及发展动态进行综述，首先详细介绍了单组分流体以及多组分流体强化传热的机理，并进一步介绍了自湿润流体的传热机理。然后对自湿润流体的制备以及自湿润流体的流动与传热特性等进行描述。最后综述了自湿润流体在无毛细芯结构、不同倾斜角下、微重力条件下以及其他类型的热管中的应用。

关键词: 自湿润流体, 传热机理, Marangoni作用, 表面张力, 可视化研究

CLC Number:

TK124

HU Yanxin, HUANG Kaixin, CHEN Sixu, WANG Shuangfeng, HUANG Jin. Research progress of flow and heat transfer characteristics with self-rewetting fluid[J]. Chemical Industry and Engineering Progress, 2017, 36(12): 4329-4342.

胡艳鑫, 黄凯鑫, 陈思旭, 汪双凤, 黄金. 自湿润流体的流动与传热特性研究进展[J]. 化工进展, 2017, 36(12): 4329-4342.

References

[1] ZOU S.11th five year plan and IC industry development in China[C]//8th International Conference on Electronics Packaging Technology,2007.
[2] 彩霞.高密度电子封装可靠性的研究[D]. 上海:中国科学院上海微系统与信息技术研究所,2002:33-34. CAI X. Reliability research on electronic packaging[D].Shanghai:Shanghai Institute of Microsystem and Information Technology Chinese Academy of Sciences,2002:33-34.
[3] ANDREW D,MATHUR D.Thermal management in advanced electronic packaging[J].Semiconductor International,2008,3:83-86.
[4] 杨明伟.半导体激光器组件的传热特性与热电控制技术研究[D].哈尔滨:哈尔滨工业大学,2006:2-19. YANG M W.Research of heat transfer and thermoelectric control technique of laser diode module[D].Harbin:Harbin Institute of Technology,2006:2-19.
[5] ESARTE J,Blanco J M,Mendia F,et al.Improving cooling devices for the hot face of Peltier pellets based on phase change fluids[J].Applied Thermal Engineering,2006,10(26):967-973.
[6] JANZ G J,GARDNER G L,KREBS U,et al.Molten salts:volume 4,Part 1,Fluorides and mixtures electrical conductance,density,viscosity,and surface tension data[J].Journal of Physical and Chemical Reference Data,1974,3(1):1-115.
[7] VOCHTEN R,PETER G.Study of the heat of reversible adsorption at the airsolution interface Ⅱ.Experimental determination of the heat of reversible adsorption of some alcohols[J].Journal of Colloid and Interface Science,1973,42(2):320-327.
[8] ZHANG N L,CHAO D F.Models for enhanced boiling heat transfer by unusual,Marangoni effects under microgravity conditions[J]. International Communications in Heat and Mass Transfer,1999,26(8):1081-1090.
[9] ABE Y,IWASAKI A,TANAKA K.Microgravity experiments on phase change of self-rewetting fluids[J].Annals of the New York Academy of Sciences,2004,1027(1):269-285.
[10] BARANENKO V I,CHICHKAN L A.Thermocapillary convention in the boiling of various fluids[J].Heat Transfer-Sov. Res.,1980,12(2):40-44.
[11] STRAUB J.The role of surface tension for two-phase heat and mass transfer in the absence of gravity[J].Experimental Thermal and Fluid Science,1994,9(3):253-276.
[12] WAYNER P C,KAO Y K,LACROIX L V.The interline heat-transfer coefficient on an evaporating wetting film[J].International Journal of Heat and Mass Transfer,1976,19(5):487-492.
[13] MAREK R,STRAUB J.The origin of thermocapillary convection in subcooled nucleate pool boiling[J].International Journal of Heat and Mass Transfer,2001,44(3):619-632.
[14] KIM J.Review of reduced gravity boiling heat transfer:US research[J].Journal of Japan Society of Microgravity Application, 2003,20(4):264-271.
[15] ABE Y,OKA T,MORi Y H,et al.Pool boiling of a non-azeotropic binary mixture under microgravity[J].International Journal of Heat and Mass Transfer,1994,37(16):2405-2413.
[16] AHMED S,CAREY V P.Effects of gravity on the boiling of binary fluid mixtures[J].International Journal of Heat and Mass Transfer,1998,41(16):2469-2483.
[17] ABE Y,IWASAKI A.Observation of vapor bubble of non-azeotropic binary mixture in microgravity with a two-wavelength interferometer[R]. Electrotechnical Laboratories,Tsukuba,Ibaraki(JP),1999.
[18] ABE Y,IWASAKI A.Single and dual vapor bubble experiments in microgravity[C]//Microgravity Fluid Physics and Heat Transfer:Proceedings of the International Conference on Microgravity Fluid Physics and Heat Transfer held at the Tutle Bay Hilton,Kahuku,Hawaii,USA,1999.
[19] OKA T,ABE Y,MORI Y H,et al.Pool boiling heat transfer in microgravity:experiments with CFC-113 and water utilizing a drop shaft facility[J].JSME International Journal Series B:Fluids and Thermal Engineering,1996,39(4):798-807.
[20] KURAMAE M,SUZUKI M.Two-component heat pipes utilizing the Marangoni effect[J].Journal of Chemical Engineering of Japan,1993,26(2):230-231.
[21] TREFETHEN L.On the jet propulsion of bubbles in a heated liquid[R].Tufts University Mechanical Engineering Report No,1961.
[22] MCGREW J L,BAMFORD F L,REHM T R.Marangoni flow:an additional mechanism in boiling heat transfer[J].Science,1966,153(3740):1106-1107.
[23] VOCHTEN R,PETRE G.Study of the heat of reversible adsorption at the air-solution interface.Ⅱ.Experimental determination of the heat of reversible adsorption of some alcohols[J].Journal of Colloid and Interface Science,1973,42(2):320-327.
[24] HU Y,ZHANG S,LI X,et al.Heat transfer enhancement of subcooled pool boiling with self-rewetting fluid[J].International Journal of Heat and Mass Transfer,2015,83:64-68.
[25] ABE Y.Self-rewetting fluids-Beneficial aqueous solutions[J]. Interdisciplinary Transport Phenomena in the Space Sciences,2006, 1077(1):650-667.
[26] CECERE A,PAOLA R D,SAVINO R,et al.Observation of Marangoni flow in ordinary and self-rewetting fluids using optical diagnostic systems[J].The European Physical Journal Special Topics,2011,192(1):109-120.
[27] SAVINO R,DI PAOLA R,CECERE A,et al.Self-rewetting heat transfer fluids and nanobrines for space heat pipes[J].Acta Astronautica,2010,67(9):1030-1037.
[28] DI PAOLA R,SAVINO R,MIRABILE G D,et al.Self-rewetting carbon nanofluid as working fluid for space and terrestrial heat pipes[J].Journal of Nanoparticle Research,2011,13(11):6207-6216.
[29] SAVINO R,CECERE A,DI PAOLA R.Surface tension-driven flow in wickless heat pipes with self-rewetting fluids[J].International Journal of Heat and Fluid Flow,2009,30(2):380-388.
[30] ABE Y.Thermal management with phase change of self-rewetting fluids[C]//Proceedings of the ASME Heat Transfer Division, 2005:391-398.
[31] MOROVATI M,BINDRA H,ESAKI S,et al.Enhancement of pool boiling and critical heat flux in self-rewetting fluids at above atmospheric pressures[C]//ASME/JSME 20118th Thermal Engineering Joint Conference.American Society of Mechanical Engineers,2011:T10246-T10246-6.
[32] HU Y,ZHANG S,LI X,et al.Heat transfer enhancement mechanism of pool boiling with self-rewetting fluid[J].International Journal of Heat and Mass Transfer,2014,79:309-313.
[33] ZHOU L,LI Y,WEI L,et al.Multi-jet flows and bubble emission during subcooled nucleate boiling of aqueous n-butanol solution on thin wire[J].Experimental Thermal and Fluid Science,2014,58:1-8.
[34] DI FRANCESCANTONIO N,SAVINO R,ABE Y.New alcohol solutions for heat pipes:Marangoni effect and heat transfer enhancement[J].International Journal of Heat and Mass Transfer,2008,51(25):6199-6207.
[35] SAVINO R,DI FRANCESCANTONIO N,FORTEZZA R,et al.Heat pipes with binary mixtures and inverse Marangoni effects for microgravity applications[J].Acta Astronautica,2007,61(1):16-26.
[36] VAN STRALEN S J D.The mechanism of nucleate boiling in pure liquids and in binary mixtures-Part I[J].International Journal of Heat and Mass Transfer,1966,9(10):995IN11007-1006IN31020.
[37] VAN STRALEN S J D,SLUYTER W M.Investigations on the critical heat flux of pure liquids and mixtures under various conditions[J].International Journal of Heat and Mass Transfer,1969,12(11):1353-1384.
[38] VAN STRALEN S J D.The growth rate of vapour bubbles in superheated pure liquids and binary mixtures. Part I:Theory[J].International Journal of Heat and Mass Transfer,1968,11(10):1467-1489.
[39] ZIJL W,RAMAKERS F J M,VAN STRALEN S J D.Global numerical solutions of growth and departure of a vapour bubble at a horizontal superheated wall in a pure liquid and a binary mixture[J].International Journal of Heat and Mass Transfer,1979,22(3):401-420.
[40] VAN WIJK W R,VOS A S,VAN STRALEN S J D.Heat transfer to boiling binary liquid mixtures[J].Chemical Engineering Science,1956,5(2):68-80.
[41] SUZUKI K,NAKANO M,ITOH M.Subcooled boiling of aqueous solution of alcohol[C]//Proceedings of the 6th KSME-JSME Joint Conference on Thermal and Fluid Engineering Conference,2005:21-23.
[42] CAREY V P.On the role of Marangoni effects on the critical heat flux for pool boiling of binary mixtures[J].Journal of Heat Transfer,1996,118:103.
[43] AHMED S,CAREY V P.Effects of surface orientation on the pool boiling heat transfer in water/2-propanol mixtures[J]. Transactions-American Society of Mechanical Engineers Journal of Heat Transfer,1999,121:80-88.
[44] SITAR A,GOLOBIC I.Heat transfer enhancement of self-rewetting aqueous n-butanol solutions boiling in microchannels[J].International Journal of Heat and Mass Transfer,2015,81:198-206.
[45] ZHOU L,WANG Z,DU X,et al.Boiling characteristics of water and self-rewetting fluids in packed bed of spherical glass beads[J].Experimental Thermal and Fluid Science,2015,68:537-544.
[46] DI FRANCESCANTONIO N,SAVINO R,ABE Y.New alcohol solutions for heat pipes:Marangoni effect and heat transfer enhancement[J].International Journal of Heat and Mass Transfer,2008,51(25/26):6199-6207.
[47] SU X,ZHANG M,HAN W,et al.Experimental study on the heat transfer performance of an oscillating heat pipe with self-rewetting nanofluid[J].International Journal of Heat and Mass Transfer,2016,100:378-385.
[48] ZHAO J,QU J,RAO Z.Experiment investigation on thermal performance of a large-scale oscillating heat pipe with self-rewetting fluid used for thermal energy storage[J].International Journal of Heat and Mass Transfer,2017,108:760-769.
[49] WU S C.Study of self-rewetting fluid applied to loop heat pipe[J].International Journal of Thermal Sciences,2015,98:374-380.
[50] 张明,苏新军,韩魏,等.氧化石墨烯/自湿润流体脉动热管的传热特性[J].化工进展,2015,34(8):2951-2954. ZHANG M,SU X J,HAN W,et al.Heat transfer characteristics of pulsating heat pipe with graphene oxide/self-rewetting fluid[J]. Chemical Industry and Engineering Progress,2015,34(8):2951-2954.
[51] FUMOTO K,KAWAJI M.Performance improvement in pulsating heat pipes using a self-rewetting fluid[C]//ASME 2009 Heat Transfer Summer Conference collocated with the InterPACK09 and 3rd Energy Sustainability Conferences,American Society of Mechanical Engineers,2009:359-365.
[52] FUMOTO K,KAWAJI M,KAWANAMI T.Study on a pulsating heat pipe with self-rewetting fluid[J].Journal of Electronic Packaging,2010,132(3):031005.
[53] SENTHILKUMAR R,VAIDYANATHAN S,BALASUBRAMANIAN S. Thermal analysis of heat pipe using self rewetting fluids[J]. Thermal Science,2011,15(3):879-888.
[54] SENTHILKUMAR R,VAIDYANATHAN S,SIVARAMAN B.Comparative study on heat pipe performance using aqueous solutions of alcohols[J].Heat and Mass Transfer,2012,48(12):2033-2040.
[55] KARTHIKEYAN M,VAIDYANATHAN S,SIVARAMAN B.Heat transfer analysis of two phase closed thermosyphon using aqueous solution of n-butanol[J].International Journal of Engineering and Technology,2013,3(6):661-667.
[56] KARTHIKEYAN M,VAIDYANATHAN S,SIVARAMAN B.Thermal performance of a two phase closed thermosyphon using aqueous solution[J].International Journal of Engineering Science and Technology,2010,2(5):913-918.
[57] 辛公明,秦秋杨,张鲁生,等.小角度下自湿润流体重力热管传热特性[J].工程热物理学报,2015(6):1282-1285. XING G M,QING Q Y,ZHANG L S,et al.Thermal characteristics of gravity heat pipe with self-rewetting fluid at small inclination angles[J].Journal of Engineering Thermophysics,2015(6):1282-1285.
[58] ABE Y,OKA T,MORI Y H,et al.Pool boiling of a non-azeotropic binary mixture under microgravity[J].International Journal of Heat and Mass Transfer,1994,37(16):2405-2413.
[59] ONO N.The aqueous solution with nonlinear surface energy and their application to flow boiling in a mini/micro tube(Keynote lecture)[C]//ICNMM07(ASME),Proceedings CD-ROM,2007.
[60] ABE Y,TANAKA K,NAKAGAWA M,et al.Flexible wickless heat pipes radiator with self-rewetting fluids[C]//9th AIAA/ASME Joint Thermophysics and Heat Transfer Conference,2006:3105.
[61] DI PAOLA R,SAVINO R,GATTIA D M,et al.Self-rewetting carbon nanofluid as working fluid for space and terrestrial heat pipes[J]. Journal of Nanoparticle Research,2011,13(11):6207-6216.
[62] ONO N,YOSHIDA T,SHOJI M,et al.Heat transfer and liquid motion of forced convective boiling in a mini-tube for aqueous solutions with nonlinear surface energy[J].Multiphase Science and Technology,2007,19(3):225-240.
[63] TANAKA K,ABE Y,NAKAGAWA M,et al.Low-gravity experiments of lightweight flexible heat pipe panels with self-rewetting fluids[J].Interdisciplinary Transport Phenomena:Fluid,Thermal,Biological,Materials,and Space Sciences,2009,1161:554-561.
[64] ABE Y,TANAKA K,MOCHIZUKI M,et al.Self-rewetting fluids[C]//Proceedings of the 8th International Heat Pipe Symposium of Japan,Kumamoto(1994),2006:76-77.
[65] SAVINO R,ABE Y,FORTEZZA R.Comparative study of heat pipes with different working fluids under normal gravity and microgravity conditions[J].Acta Astronaut,2008,63(1/2/3/4):24-34.
[66] SAVINO R,DI FRANCESCANTONIO N,FORTEZZA R,et al.Heat pipes with binary mixtures and inverse Marangoni effects for microgravity applications[J].Acta Astronaut,2007,61(1/2/3/4/5/6):16-26.
[67] SATO M,ABE Y,URITA Y,et al.Thermal performance of self-rewetting fluid heat pipe containing dilute solutions of polymer-capped silver nanoparticles synthesized by microwave-polyol process[J]. International Journal of Transport Phenomena,2011,12:339-345.
[68] 汪双凤,胡艳鑫,李选友.自湿润流体热管的热输送性能[J].化工学报,2012,63(12):3791-3797. WANG S F,HU Y X,LI X Y.Heat-transport capability of self-rewetting fluid heat pipe[J].Journal of Chemical Industry and Engineering(China),2012,63(12):3791-3797.
[69] PEYGHAMBARZADEH S M,BOHLOUL M R,ASLANZADEH N.Heat transfer and Marangoni flow in a circular heat pipe using self-rewetting fluids[J].Experimental Heat Transfer,2017,30(3):218-234.