热泵耦合甲醇多效精馏节能新工艺

doi:10.16085/j.issn.1000-6613.2019-1992

化工进展 ›› 2020, Vol. 39 ›› Issue (9): 3550-3555.DOI: 10.16085/j.issn.1000-6613.2019-1992

热泵耦合甲醇多效精馏节能新工艺

王东亮(), 孟文亮, 杨勇, 董鹏, 李春强

兰州理工大学石油化工学院，甘肃兰州 730050

出版日期:2020-09-05 发布日期:2020-09-11
通讯作者: 王东亮
作者简介:王东亮（1982—），男，博士，副教授，研究方向为化工系统工程。E-mail：wangdl@lut.edu.cn。
基金资助:
甘肃省科技重大专项(18ZD2GD014)

A novel methanol distillation process combining heat pump and multi-effect process

Dongliang WANG(), Wenliang MENG, Yong YANG, Peng DONG, Chunqiang LI

School of Petrochemical Engineering, Lanzhou University of Technology, Lanzhou 730050, Gansu, China

Online:2020-09-05 Published:2020-09-11
Contact: Dongliang WANG

摘要/Abstract

摘要：

粗甲醇精馏的能耗是影响甲醇生产成本的关键因素之一。虽然五塔多效精馏可以降低精馏过程能耗，但仍存在相当的低品位余热未利用，为进一步降低五塔多效精馏工艺的能耗，本研究引入机械蒸汽再压缩式（MVR）热泵，在常压塔提馏段增设辅助再沸器，形成热泵耦合多效甲醇精馏新工艺。基于新工艺的全流程模拟数据，文章利用夹点技术对热泵设置的合理性进行分析，采用能耗、效能系数（COP）和年总成本（TAC）等指标对新工艺过程进行评价。结果表明：热泵耦合多效甲醇精馏新工艺中热泵设置合理，冷负荷为24.7MW，再沸器总热负荷为22.25MW，COP为22.5，相比五塔多效精馏工艺，冷负荷、热负荷以及TAC分别降低33.76%、32.64%和26.97%。热泵耦合多效甲醇精馏新工艺节能效果显著。

关键词: 甲醇精馏, 五塔多效工艺, 热泵辅助精馏, 低温余热利用, 经济评价

Abstract:

The energy consumption of crude methanol distillation is one of the key factors affecting the production cost of methanol. Although five-column multi-effect distillation can reduce the energy consumption of the distillation process, there is still a considerable amount of low temperature waste heat. In order to further reduce the energy consumption, a mechanical vapor recompression (MVR) heat-pump and an assisted reboiler in the stripping section of the atmospheric column were added to form the novel methanol distillation process combining heat pump and multi-effect process. Based on the whole process simulation data, the rationality of the heat pump setting was analyzed through pinch technology. The energy consumption, the coefficient of performance (COP) and total annual cost (TAC) was used to evaluate the process performance. The results showed that the heat pump setting was reasonable in the novel methanol distillation process. The condenser duty and the total reboiler duty were 24.7MW and 22.25MW， respectively, and the COP was 22.5. The condenser duty, heat duty and TAC were reduced by 33.76%, 32.64% and 26.97%, respectively compared with the five-column multi-effect distillation process. The energy saving effect was significant for the novel methanol distillation process combining heat pump and multi-effect process.

Key words: methanol distillation, five-column multi-effect process, heat-pump assisted distillation, low temperature thermal utilization, economic evaluation

中图分类号:

TQ206

王东亮, 孟文亮, 杨勇, 董鹏, 李春强. 热泵耦合甲醇多效精馏节能新工艺[J]. 化工进展, 2020, 39(9): 3550-3555.

Dongliang WANG, Wenliang MENG, Yong YANG, Peng DONG, Chunqiang LI. A novel methanol distillation process combining heat pump and multi-effect process[J]. Chemical Industry and Engineering Progress, 2020, 39(9): 3550-3555.

参考文献

1	叶鑫, 吕建宁, 丁干红, 等. 甲醇热泵精馏新工艺[J]. 化工进展, 2010, 29(S2): 74-77.
1	YE X, Lü J N, DING G H, et al. Study on the new technology of heat pump rectification in production of methanol[J]. Chemical Industry and Engineering Progress, 2010, 29(S2): 74-77.
2	MEYERS R A. Handbook of synfuels technology[M]. New York: McGraw-Hill, 1984.
3	褚雅志, 秦丽萍, 王胜利, 等. 甲醇精馏工艺及其塔器优化设计[J]. 化工进展, 2008, 27(10): 1659-1662.
3	CHU Y Z, QIN L P, WANG S L, et al. Optimum design of methanol distillation process and columns[J]. Chemical Industry and Engineering Progress, 2008, 27(10): 1659-1662.
4	ZHANG J T, LIANG S R, FENG X. A novel multi-effect methanol distillation process[J]. Chemical Engineering and Processing: Process Intensification, 2010, 49(10): 1031-1037.
5	KISS A A, FLORES LANDAETA S J, INFANTE FERREIRA C A. Towards energy efficient distillation technologies—making the right choice[J]. Energy, 2012, 47(1): 531-542.
6	DE BOR D M VAN, INFANTE FERREIRA C A, KISS A A. Low grade waste heat recovery using heat pumps and power cycles[J]. Energy, 2015, 89: 864-873.
7	CUI C T, SUN J S, LI X G. A hybrid design combining double-effect thermal integration and heat pump to the methanol distillation process for improving energy efficiency[J]. Chemical Engineering and Processing: Process Intensification, 2017, 119: 81-92.
8	CUI C T, LI X G, SUI H, et al. Optimization of coal-based methanol distillation scheme using process superstructure method to maximize energy efficiency[J]. Energy, 2017, 119: 110-120.
9	AMIYA K J. Heat integrated distillation operation[J]. Applied Energy, 2010, 87(5): 1477-1494.
10	CUI C T, LI X G, SUI H, et al. Quick decision-making for close-boiling distillation schemes[J]. Industrial and Engineering Chemistry Research, 2017, 56(17): 5078-5091.
11	CHEW J M, REDDY C C S, RANGAIAH G P. Improving energy efficiency of dividing-wall columns using heat pumps, organic Rankine cycle and Kalina cycle[J]. Chemical Engineering and Processing: Process Intensification, 2014, 76: 45-59.
12	REDDY C C S, FANG Y, RANGAIAH G P. Improving energy efficiency of distillation using heat pump assisted distillation[J]. Asia-Pacific Journal of Chemical Engineering, 2014, 9(6): 905-928.
13	PLESU V, BONET RUIZ A E, BONET J, et al. Simple equation for suitability of heat pump use in distillation[J]. Computer Aided Chemical Engineering, 2014, 33: 1327-1332.
14	DOUGLAS M J. Concept design of chemical process[M]. New York: McGraw-Hill, 1988: 349-350.
15	MIGNARD D. Correlating the chemical engineering plant cost index with macro-economic indicators[J]. Chemical Engineering Research and Design, 2014, 92(2): 285-294.

[1]	张凤岐, 崔成东, 鲍学伟, 朱炜玄, 董宏光. 胺液吸收-分步解吸脱硫工艺的设计与评价[J]. 化工进展, 2023, 42(S1): 518-528.
[2]	毕荣山, 张艳, 陈彦臻, 孙映辉, 陈伦波, 王明泽, 夏力, 孙晓岩, 项曙光. 异戊烷一步脱氢制备异戊二烯工艺模拟分析及经济评价[J]. 化工进展, 2021, 40(11): 5961-5966.
[3]	胡徐腾. 天然气制乙烯技术进展及经济性分析[J]. 化工进展, 2016, 35(06): 1733-1738.
[4]	周文戟，朱兵，费维扬. 不确定条件下煤化工技术经济评价方法 [J]. 化工进展, 2009, 28(12): 2087-.
[5]	王为然，张文慧，陈光旭，徐春明，高金森. 甲乙酮装置循环丁烯脱除仲丁醇吸附剂 [J]. 化工进展, 2009, 28(1): 163-.

热泵耦合甲醇多效精馏节能新工艺

A novel methanol distillation process combining heat pump and multi-effect process

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 5

编辑推荐

Metrics

本文评价