有机朗肯循环发电系统变工况运行的实验研究

doi:10.16085/j.issn.1000-6613.2017-0487

化工进展 ›› 2018, Vol. 37 ›› Issue (01): 88-95.DOI: 10.16085/j.issn.1000-6613.2017-0487

有机朗肯循环发电系统变工况运行的实验研究

曹泷, 刘秀龙, 张鸣, 徐进良

华北电力大学低品位能源多相流与传热北京市重点实验室, 北京 102206

收稿日期:2017-03-21 修回日期:2017-04-21 出版日期:2018-01-05 发布日期:2018-01-05
通讯作者: 徐进良,教授,博士生导师,主要从事多相流传热和低品位热源利用技术研究。
作者简介:曹泷(1989-),男,博士研究生,主要从事低品位热源利用技术研究。E-mail:caos0708@163.com。
基金资助:
国家自然科学基金国际合作与交流资助项目（51210011）及中央高校基本科研业务费专项项目（2016XS23）。

Experimental study of organic Rankine cycle power generation system under various operating conditions

CAO Shuang, LIU Xiulong, ZHANG Ming, XU Jinliang

Beijing Key Laboratory of Multiphase Flow and Heat Transfer for Low Grade Energy, North China Electric Power University, Beijing 102206, China

Received:2017-03-21 Revised:2017-04-21 Online:2018-01-05 Published:2018-01-05

摘要/Abstract

摘要： 受余热热源及环境温度不稳定特性的制约，有机朗肯循环（ORC）发电系统在实际应用中需要有较强的变工况能力。本文以R245fa为工质，实验研究了在不同冷热源温度时，ORC系统在相同负载容量及膨胀机转速下的变工况运行特性及各部件实际性能。实验结果表明：热源温度主要决定了膨胀机的入口温度及过热度。随着热源温度的降低，膨胀机内部泄漏量变大，其等熵效率变低，单位质量工质做功能力变差，维持膨胀机做功状态的工质质量流量增加。由于工质在蒸发器内整体吸热量变小，系统发电效率随热源温度的降低而升高。在10℃冷源温度下，热源温度从115℃下降至100℃，机组的最大发电效率从5.03%升高至5.25%。改变冷源温度，主要作用于膨胀机的进出口压力，改变了膨胀机的做功状态。降低冷源温度，膨胀机压比升高，单位质量工质做功能力变强，维持膨胀机做功状态的工质质量流量减小。但由于膨胀机过膨胀运行带来的不可逆损失增加，膨胀机的等熵效率随冷源温度降低而减小。在115℃热源温度下，冷源温度从30℃下降至10℃，系统最大发电效率从6.08%升高至7.01%。

关键词: 有机朗肯循环, 冷热源, 变工况, 实验验证, (火用)

Abstract: Due to the instability of waste heat resource and environment temperature, the organic Rankine cycle (ORC)system should have strong various operating ability in practical application. In this paper, the experimental test of an organic Rankine cycle (ORC) system with R245fa as the working fluid under various operating condition were carried out. The effect of cold and heat sources temperature on ORC system performance were analyzed under the constant electric energy production operating. It was found that the decreased heat resource temperature would decrease the inlet temperature and superheat of expander. Because the expander internal leakage was increased, the expander isentropic efficiency was decreased, and the mass flow rate of the working fluid had to increase to maintain the constant output power. With the falling temperature of heat source, the heat transfer coefficient of evaporator and the electrical efficiency were increased. When the inlet temperature of cooling water was kept at 10℃, the electrical efficiency of ORC system was increased from 5.03% to 5.25% with decreasing heat resource temperature from 115℃ to 100℃. Therefore, the temperature of cold source significantly affected the pressure at expander inlet and outlet. With the inlet temperature of cooling water decreased, the expander isentropic efficiency was decreased, whereas the pressure ratio of the expander as well as the power output capability of unit mass of working fluid were increased. Hence, the electrical efficiency and pure efficiency of the system were increased. When the inlet temperature of cooling water was increased from 10℃ to 30℃ at the hot source temperature of 115℃, the electrical efficiency of ORC system was decreased from 7.01% to 6.08%.

Key words: organic Rankine cycle, cold and heat sources, various operating conditions, experimental validation, exergy

中图分类号:

TK11⁺5

曹泷, 刘秀龙, 张鸣, 徐进良. 有机朗肯循环发电系统变工况运行的实验研究[J]. 化工进展, 2018, 37(01): 88-95.

CAO Shuang, LIU Xiulong, ZHANG Ming, XU Jinliang. Experimental study of organic Rankine cycle power generation system under various operating conditions[J]. Chemical Industry and Engineering Progress, 2018, 37(01): 88-95.

参考文献

[1] RAHBAR K,MAHMOUD S,AL-DADAH R K,et al. Review of organic Rankine cycle for small-scale applications[J]. Energy Conversion and Management,2017,134:135-155.
[2] 刘杰,陈江平,祁照岗. 低温有机朗肯循环的热力学分析[J]. 化工学报,2010,61(s2):9-14. LIU J,CHEN J P,QI Z G. Thermodynamic analysis of low temperature organic Rankine cycle[J]. CIESC Journal,2010,61(s2):9-14.
[3] 汤磊,王羽平,杨平,等. 低品位热能超临界有机朗肯循环发电特性分析[J]. 动力工程学报,2014,34(8):646-652. TANG L,WANG Y P,YANG P,et al. Analysis on characteristics of a supercritical ORC low-grade heat power generation system[J]. Journal of Chinese Society of Power Engineering,2014,34(8):646-652.
[4] 裴刚,王东玥,李晶,等. 有机朗肯循环热电联供系统的实验研究[J]. 化工学报,2013,64(6):1993-2000. PEI G,WANG D Y,LI J,et al. Organic Rankine cycle combined heat and power system[J]. CIESC Journal,2013,64(6):1993-2000.
[5] 宋建忠,张小松,李舒宏,等. 太阳能有机朗肯循环系统的实验特性[J]. 化工学报,2014,65(12):4958-4964. SONG J Z,ZHANG X S,LI S H,et al. Experimental characteristics of solar organic Rankine cycle system[J]. CIESC Journal,2014,65(12):4958-4964.
[6] USMAN M,IMRAN M,YANG Y M,et al. Thermo-economic comparison of air-cooled and cooling tower based organic Rankine cycle(ORC) with R245fa and R1233zde as candidate working fluids for different geographical climate conditions[J]. Energy,2017,123:353-366.
[7] 谢飞博,朱彤,高乃平. 冷源温度对小型ORC低温余热发电系统的影响[J]. 化工学报,2016,67(10):4111-4117. XIE F B,ZHU T,GAO N P. Effect of cold source temperature on power generation of small organic Rankine cycle system with low-grade waste heat[J]. CIESC Journal,2016,67(10):4111-4117.
[8] LIU X H,ZHANG Y F,SHEN J. System performance optimization of ORC-based geo-plant with R245fa under different geothermal water inlet temperatures[J]. Geothermics,2017,66:134-142.
[9] 苗政,刘广林,徐进良,等. 变冷凝工况地热有机朗肯循环发电系统[J]. 重庆大学学报,2014,37(6):51-55. MIAO Z,LIU G L,XU J L,et al. Geothermal heat power organic Rankine cycle system under different condensation temperatures[J]. Journal of Chongqing University,2014,37(6):51-55.
[10] KIM D K,LEE J S,KIM J,et al. Parametric study and performance evaluation of an organic Rankine cycle(ORC) system using low-grade heat at temperatures below 80℃[J]. Applied Energy,2017,189:55-65.
[11] LI L,GE Y T,LUO X,et al. Thermodynamic analysis and comparison between CO₂ transcritical power cycles and R245fa organic Rankine cycles for low grade heat to power energy conversion[J]. Applied Thermal Engineering,2016,106:1290-1299.
[12] SUNG T H,KIM C H. Thermodynamic analysis of a novel dual-loop organic Rankine cycle for engine waste heat and LNG cold[J]. Applied Thermal Engineering,2016,100:1031-1041.
[13] MIAO Z,XU J L,YANG X F,et al. Operation and performance of a low temperature organic Rankine cycle[J]. Applied Thermal Engineering,2015,75:1065-1075.
[14] HSIEH J C,FU B R,WANG T W,et al. Design and preliminary results of a 20-kW transcritical organic Rankine cycle with a screw expander for low-grade waste heat recovery[J]. Applied Thermal Engineering,2017,110:1120-1127.
[15] FU B R,LEE Y R,HSIEH J C. Design,construction,and preliminary results of a 250-kW organic Rankine cycle system[J]. Applied Thermal Engineering,2015,80:339-346.
[16] ZIVIANI D,GUSEV S,LECOMPTE S,et al. Characterizing the performance of a single-screw expander in a small-scale organic Rankine cycle for waste heat recovery[J]. Applied Energy,2016,181:155-170.
[17] YANG X F,XU J L,MIAO Z,et al. Operation of an organic Rankine cycle dependent on pumping flow rates and expander torques[J]. Energy,2015,90:864-878.
[18] BOUVIER J L,LEMORT V,MICHAUX G,et al. Experimental study of an oil-free steam piston expander for micro-combined heat and power systems[J]. Applied Energy,2016,169:788-798.
[19] 张军辉,刘娟芳,陈清华. 有机朗肯循环系统最佳蒸发温度和(火用)分析[J]. 化工学报,2013,64(3):820-826. ZHANG J H,LIU J F,CHEN Q H. Optimal evaporating temperature and exergy analysis for organic Rankine cycle[J]. CIESC Journal,2013,64(3):820-826.
[20] YANG S C,HUNG T C,FENG Y Q,et al. Experimental investigation on a 3kW organic Rankine cycle for low-grade waste heat under different operation parameters[J]. Applied Thermal Engineering,2017,113:756-764.
[21] EYERER S,WIELAND C,VANDERSICKEL A,et al. Experimental study of an ORC(organic Rankine cycle)and analysis of R1233zd-E as a drop-in replacement for R245fa for low temperature heat utilization[J]. Energy,2016,103:660-671.

有机朗肯循环发电系统变工况运行的实验研究

Experimental study of organic Rankine cycle power generation system under various operating conditions

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	李蓝宇, 黄新烨, 王笑楠, 邱彤. 化工科研范式智能化转型的思考与展望[J]. 化工进展, 2023, 42(7): 3325-3330.
[2]	杜涛, 马进伟, 陈茜茜, 方浩, 陈秉章, 陈厚仁. PV/T模块复合冷却模式性能对比测试与数值模拟分析[J]. 化工进展, 2023, 42(2): 722-730.
[3]	李丹, 杨思宇, 钱宇. 耦合溴化锂吸收式制冷与有机朗肯循环的合成气深冷分离工艺[J]. 化工进展, 2022, 41(10): 5236-5246.
[4]	李新国, 弭慧惠, 吴晓松, 高冠怡. 调节传热窄点以提升有机朗肯循环性能的分析[J]. 化工进展, 2021, 40(5): 2517-2525.
[5]	刘广林, 徐进良, 苗政. 共冷凝器双循环有机朗肯发电系统㶲分析[J]. 化工进展, 2021, 40(12): 6656-6662.
[6]	杨杨, 胡海航, 哈雯, 杨斌, 王栋. 管内相分隔高含水油水两相流双参数测量方法[J]. 化工进展, 2021, 40(12): 6441-6449.
[7]	王学科, 沈义伟, 赵洪滨, 曹岭, 陈山, 贾彩, 谢晓峰. 旋涡式氢气循环泵的设计及性能分析[J]. 化工进展, 2020, 39(S2): 89-96.
[8]	张圆圆, 孟永斌, 张琳, 祖元刚. 响应面法优化微波辅助水蒸气蒸馏法提取油樟精油工艺[J]. 化工进展, 2020, 39(S2): 291-299.
[9]	张凯,武多多,刘强,彭越,杨震,段远源. 高密度流体声速测量中脉冲回波传播时间的测定[J]. 化工进展, 2020, 39(4): 1219-1226.
[10]	张婷, 魏顺安, 申威峰. 双效精馏分离不同浓度甲醇水溶液的节能分析[J]. 化工进展, 2019, 38(s1): 52-58.
[11]	王志杰,李枫,赵立新. 含聚浓度对旋流器性能影响的数值模拟与试验[J]. 化工进展, 2019, 38(12): 5287-5296.
[12]	许源, 陶汉中, 张栋玮. 内插扭带对鼓泡反应器脱硫脱硝效果的影响[J]. 化工进展, 2019, 38(06): 2992-3001.
[13]	刘广林, 曹泷, 刘欢, 苗政, 徐进良. 基于单螺杆膨胀机有机朗肯循环有无回热系统性能分析[J]. 化工进展, 2019, 38(06): 2626-2632.
[14]	王治红, 丁晓明, 吴明鸥, 沈晓燕. 有机朗肯循环在多品位余热发电中的应用[J]. 化工进展, 2019, 38(05): 2189-2196.
[15]	杨宇鑫, 张红光, 赵蕊, 李健, 赵腾龙, 张梦茹. 工质泵变运行工况对有机朗肯循环系统性能的影响[J]. 化工进展, 2019, 38(02): 851-857.