有机朗肯循环用涡旋膨胀机的改进与实验研究

doi:10.16085/j.issn.1000-6613.2017.05.012

化工进展 ›› 2017, Vol. 36 ›› Issue (05): 1642-1648.DOI: 10.16085/j.issn.1000-6613.2017.05.012

有机朗肯循环用涡旋膨胀机的改进与实验研究

李垒^1,2, 陶乐仁^1,2, 申玲^1,2, 胡永攀^1,2, 李庆普^1,2

1. 上海理工大学能源与动力工程学院, 上海 200093;
2. 上海市动力工程多相流动与传热重点实验室, 上海 200093

收稿日期:2016-09-26 修回日期:2016-12-01 出版日期:2017-05-05 发布日期:2017-05-05
通讯作者: 陶乐仁,博士生导师,教授,主要研究方向为传热传质强化、新能源应用。
作者简介:李垒(1985-),男,博士研究生,主要研究方向为新能源节能技术的应用。E-mail:a7082928@126.com。
基金资助:
上海市动力工程多相流动与传热实验室开放基金项目（13DZ2260900）

Improvement and experimental research on the performance of scroll expander using organic Rankine cycle(ORC)

LI Lei^1,2, TAO Leren^1,2, SHEN Ling^1,2, HU Yongpan^1,2, LI Qingpu^1,2

1. School of Energy and Power Engineering, University of Shanghai for Science and Technology, Shanghai 200093, China;
2. Shanghai Key Laboratory of Multiphase Flow and Heat Transfer in Power Engineering, Shanghai 200093, China

Received:2016-09-26 Revised:2016-12-01 Online:2017-05-05 Published:2017-05-05

摘要/Abstract

摘要： 目前有机朗肯循环（ORC）的效率普遍较低，而膨胀机的性能将对循环效率产生直接的影响。为提高有机朗肯循环用涡旋膨胀机的性能，本文提出对涡旋膨胀机进行了改进，使动涡旋齿的齿头不会遮挡进气孔，进、出气口对称分布，并对涡旋齿端型线进行了修正。研究改进后涡旋膨胀机进口压力、流量、转速等参数对其性能的影响。实验结果表明：改进后膨胀机的最大外等熵效率为53%，且存在一个最佳压力值，使得膨胀机的外等熵效率最大。进口流量的增加会使膨胀机的转速提高，输出功率增大。膨胀机的外等熵效率变化曲线呈抛物线变化，不同的负载对应着不同的最佳流量值，使得膨胀机的外等熵效率最大。不同负载下的膨胀机有着不同的最佳转速，使得其输出功最大，且进气压力越大，其最佳转速也越大。研究结果表明：对涡旋膨胀机的改进是切实可行的，且对膨胀机的实验为以后进一步改进指明了方向。

关键词: 有机朗肯循环, 涡旋膨胀机, 等熵效率, 性能实验

Abstract: The current efficiency of the organic Rankine cycle (ORC) is generally low.The performance of the expander has a direct impact on the cycle efficiency. In order to enhance the scroll expander performance of organic Rankine cycle,the scroll expander was improved. The movable scroll wraps do not block the inlet hole,the inlet and outlet are distributed symmetrically,and the scroll profile modification is adopted. The influence of inlet pressure,flow rate and rotating speed of the scroll expander on its performance was studied. The experimental results showed that the maximum external isentropic efficiency of the modified scroll expander would be up to 53%,and there is an optimal pressure value,which makes the maximum external isentropic efficiency of the expander. The increase of the inlet flow rate will increase the rotating speed and the output power of the expander. The changes of isentropic efficiency show parabolic curves,and different loads correspond to different optimal flow values,which makes the maximum external isentropic efficiency of the expander. Different loads of the expander have different optimal speeds,making the maximum output power,the optimal speed is larger as the inlet pressure increases. Research results showed that it is feasible to improve the scroll expander,and the experiments of expander point out the direction for further improvement.

Key words: organic Rankine cycle(ORC), scroll expander, isentropic efficiency, performance experiment

中图分类号:

TK114

李垒, 陶乐仁, 申玲, 胡永攀, 李庆普. 有机朗肯循环用涡旋膨胀机的改进与实验研究[J]. 化工进展, 2017, 36(05): 1642-1648.

LI Lei, TAO Leren, SHEN Ling, HU Yongpan, LI Qingpu. Improvement and experimental research on the performance of scroll expander using organic Rankine cycle(ORC)[J]. Chemical Industry and Engineering Progress, 2017, 36(05): 1642-1648.

参考文献

[1] HUNG Tzu Chen. Waste heat recovery of organic Rankine cycle using dry fluids[J]. Energy Conversion and Management,2001,42(5):539-553.
[2] 吕晓飞,梁晓飞. 中国低温余热发电技术取得突破[EB/OL]. [2016-09-26].http://www.nea.gov.cn/2014-06/04/c_133382750.htm. LV Xiaofei,LIANG Xiaofei. China's low temperature waste heat power generation technology made a breakthrough[EB/OL]. [2016-09-26]. http://www.nea.gov.cn/2014-06/04/c_133382750.htm.
[3] 顾伟,翁一武,王玉璋,等. 余热利用有机物朗肯循环最佳热回收效率分析[J]. 太阳能学报,2011,32(5):662-668. GU Wei,WENG Yiwu,WANG Yuzhang,et al. Heat recovery efficiency analysis of waste heat driven organic Rankine cycle [J]. Acta Energiae Solaris Sinica,2011,32(5):662-668.
[4] 张业强,吴玉庭,夏国栋,等. 单螺杆膨胀机在有机朗肯循环系统中的性能研究[J]. 机械工程学报,2015,51(16):156-163. ZHANG Yeqiang,WU Yuting,XIA Guodong,et al. Performance study on single-screw expander in organic Rankine cycle system[J]. Journal of Mechanical Engineering,2015,51(16):156-163.
[5] YANAGISAWA T,FUKUTA M,OGI Y,et al. Performance of an oil-free scroll-type air expander[C]//Proceedings of the IMECHE Conference on Compressors and their Systems,2001:167-174.
[6] GAO P,JIANG L,WANG L W,et al. Simulation and experiments on an ORC system with different scroll expanders based on energy and exergy analysis[J]. Applied Thermal Engineering,2015,75:880-888.
[7] 褚晓广,张承慧,李柯,等. 涡旋膨胀机改造及试验性能研究[J]. 西安交通大学学报,2014,48(1):37-41. CHU Xiaoguang,ZHANG Chenghui,LI Ke,et al. Improvement and performance experiment of a scroll expander[J]. Journal of Xi'an Jiaotong University,2014,48(1):37-41.
[8] 程哲铭,欧阳新萍,雷蓉. 涡旋式压缩机涡旋型线的研究综述与前景[J]. 流体机械,2015,43(1):51-56. CHENG Zheming,OUYANG Xinping,LEI Rong. Overview and prospect of the research on profile of scroll compressor[J]. Fluid Machinery,2015,43(1):51-56.
[9] 杨绪飞,戚风亮,刘秀龙,等. 有机朗肯循环膨胀机入口过热度实验[J]. 化工进展,2016,35(7):2007-2014. YANG Xufei,QI Fengliang,LIU Xiulong,et al. Experiment on expander inlet superheat of organic Rankine cycle[J]. Chemical Industry and Engineering Progress,2016,35(7):2007-2014.
[10] 夏立军,裴刚,李晶,等. ORC系统小型涡轮不同转速下的性能分析[J]. 化工学报,2014,65(11):4254-4261. XIA Lijun,PEI Gang,LI Jing,et al. Performance analysis on small-scale turbine used in ORC system at different rotational rates[J]. CIESC Journal,2014,65(11):4254-4261.
[11] 刘超,徐进良. 一种新型天然气锅炉烟气余热回收系统[J]. 化工学报,2013,64(11):4223-4230. LIU Chao,XU Jinliang. A novel heat recovery system for flue gas from natural gas boiler [J].CIESC Journal,2013,64(11):4223-4230.
[12] MENDOZ Luis Carlos,NAVARRO-ESBRI Joaquín,BRUNO Joan Carles,et al. Characterization and modeling of a scroll expander with air and ammonia as working fluid [J].Applied Thermal Engineering,2014,70(1):630-640.
[13] AVACHI Fadhel,KSAYER Elias Boulawz,NEVEU Pierre,et al. Experimental investigation and modeling of a hermetic scroll expander [J]. Applied Energy,2016,181:256-267.
[14] 翁一武. 低品位热能转换过程及利用——有机物工质发电及制冷[M]. 上海,上海交通大学出版社,2014:72-75. WENG Yiwu. Conversion process and utilization of low grade heat energy-Power generation and refrigeration using organic working fluid[M]. Shanghai:Shanghai Jiaotong University Press,2014: 72-75.
[15] 叶佳琦,赵力,邓帅,等. 小型有机朗肯循环系统中工质泵的效率[J]. 化工进展,2016,35(4):1027-1032. YE Jiaqii,ZHAO Li,DENG Shuai,et al. Efficiency of working fluid pump in a small-scale organic Rankine cycle system[J]. Chemical Industry and Engineering Progress,2016,35(4):1027-1032.
[16] 杨兴华,潘家祯,王吉岱. 涡旋式膨胀机内部流场的数值模拟研究[J]. 流体机械,2013,41(2):15-18. YANG Xinghua,PAN Jiazhen,WANG Jidai,et al. Numerical simulation research on the interior flow field of scroll expander [J]. Fluid Machinery,2013,41(2):15-18.
[17] 童明伟,胡鹏. 涡旋式高压气体膨胀机做功过程的热力学分析[J]. 机械工程学报,2010,46(20):139-144. TONG Mingwei,HU Peng. Thermodynamics analysis of working process on scroll high-pressure gas expander [J].Journal of Mechanical Engineering,2010,46(20):139-144.
[18] HE Wei,WU Yuting,PENG Yanhai,et al. Influence of intake pressure on the performance of single screw expander working with compressed air [J]. Applied Thermal Engineering,2013,51(1/2):662-669.
[19] 吴双应,易甜甜,肖兰. 基于多目标函数的亚临界有机朗肯循环的参数优化和性能分析[J]. 化工学报,2014,65(10):4078-4085. WU Shuangying,YI Tiantian,XIAO Lan. Parametric optimization and performance analysis of subcritical organic Rankine cycle based on multi-objective function [J]. CIESC Journal,2014,65(10):4078-4085.
[20] QUOILIN Sylvain,LEMORT Vincent,LEBRUN Jean. Experimental study and modeling of an organic Rankine cycle using scroll expander [J]. Applied Energy,2010,87(4):1260-1268.

有机朗肯循环用涡旋膨胀机的改进与实验研究

Improvement and experimental research on the performance of scroll expander using organic Rankine cycle(ORC)

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	李丹, 杨思宇, 钱宇. 耦合溴化锂吸收式制冷与有机朗肯循环的合成气深冷分离工艺[J]. 化工进展, 2022, 41(10): 5236-5246.
[2]	李新国, 弭慧惠, 吴晓松, 高冠怡. 调节传热窄点以提升有机朗肯循环性能的分析[J]. 化工进展, 2021, 40(5): 2517-2525.
[3]	刘广林, 徐进良, 苗政. 共冷凝器双循环有机朗肯发电系统㶲分析[J]. 化工进展, 2021, 40(12): 6656-6662.
[4]	刘广林, 曹泷, 刘欢, 苗政, 徐进良. 基于单螺杆膨胀机有机朗肯循环有无回热系统性能分析[J]. 化工进展, 2019, 38(06): 2626-2632.
[5]	王治红, 丁晓明, 吴明鸥, 沈晓燕. 有机朗肯循环在多品位余热发电中的应用[J]. 化工进展, 2019, 38(05): 2189-2196.
[6]	杨宇鑫, 张红光, 赵蕊, 李健, 赵腾龙, 张梦茹. 工质泵变运行工况对有机朗肯循环系统性能的影响[J]. 化工进展, 2019, 38(02): 851-857.
[7]	姚玉婷, 李士雨. 高通量换热器用于低温发电系统的研究[J]. 化工进展, 2018, 37(10): 3737-3743.
[8]	黄靖伦, 王辉涛, 葛众, 韩金蓉, 赵玲玲. 双压膨胀有机朗肯循环中低温余热发电系统的热力性能[J]. 化工进展, 2018, 37(09): 3303-3311.
[9]	王明涛, 刘启一, 张百浩. 冷凝条件对基于混合工质的内燃机余热有机朗肯循环热力性能的影响[J]. 化工进展, 2018, 37(08): 2927-2934.
[10]	杨德明, 朱碧云, 顾强, 王争光, 印一凡, 高晓新. 基于机械蒸汽再压缩和有机朗肯循环技术的双溶剂协同萃取精馏分离乙酸甲酯-甲醇-水节能工艺[J]. 化工进展, 2018, 37(05): 2010-2015.
[11]	曹泷, 刘秀龙, 张鸣, 徐进良. 有机朗肯循环发电系统变工况运行的实验研究[J]. 化工进展, 2018, 37(01): 88-95.
[12]	吴国策, 朱兴仪, 赵英汝. 一种新型的太阳能驱动ORC-HP热电联产耦合系统[J]. 化工进展, 2017, 36(S1): 195-202.
[13]	韩中合, 许鸿胜, 范伟, 赵若丞, 王智. 低温烟气有机郎肯循环ORC系统热力性能与经济性的对比分析[J]. 化工进展, 2017, 36(11): 4010-4016.
[14]	刘秀龙, 曹泷, 苗政, 张鸣, 谢学旺, 徐进良. 有机朗肯循环驱动反渗透海水淡化运行模式及工质选择[J]. 化工进展, 2017, 36(10): 3639-3647.
[15]	曹泷, 刘秀龙, 张鸣, 徐进良. 有机朗肯循环系统孤网运行的实验研究[J]. 化工进展, 2017, 36(10): 3577-3583.