Influence of particle size on kinetics of low temperature phase transformation of aluminum hydroxide

doi:10.16085/j.issn.1000-6613.2019-1009

Abstract

Abstract:

The function of particle size to the transformation of aluminum hydroxide to boehmite under low temperature conditions were investigated by comprehensive thermal analysis technique, laser particle size analyzer (LPSA), scanning electron microscopy (SEM) and X-ray diffraction (XRD). Meanwhile, Kissinger equation, Ozawa equation and Crane equation were applied for analysis of the influence of particle size on phase transformation of aluminum hydroxide. The results showed that two clear endothermic peaks were appeared in the course of phase transformation of normal sandy aluminum hydroxide and grinded sandy aluminum hydroxide, and only one endothermic peak was appeared in the course of phase transformation of micron aluminum hydroxide which medium diameter was about 1μm. According to the results of calculations with Kissinger equation and Ozawa equation, the activation energy of phase transformation of aluminum hydroxide was decreased along with the decrease of particle size, which showed that a lower particle size was benefit for phase transformation from aluminum hydroxide to boehmite. The XRD of aluminum hydroxide after calcinations showed that the primary crystal phase was boehmite and the secondary crystal phase was gibbsite. The content of boehmite was increased with the decrease of particle size.

Key words: aluminum hydroxide, boehmite, phase transformation kinetics, particle size

摘要：

利用综合热分析仪分析技术、激光粒度分析、扫描电镜和X射线衍射研究了粒度对氢氧化铝在低温相变转化成勃姆石过程的影响，并采用Kissinger方程、Ozawa方程和Crane方程进行了不同粒度的氢氧化铝在低温相变过程的动力学参数计算。结果表明：普通砂状氢氧化铝在相变过程有2个较为明显的吸热峰，将砂状氢氧化铝研磨至中位径D₅₀在12μm左右时，相变过程仍然有2个明显的吸热峰；当氢氧化铝中位径D₅₀在1μm左右的氢氧化铝，相变过程则只有1个吸热峰。根据Kissinger方程和Ozawa方程计算结果，随着粒度的降低，其相变活化能也相应的降低，说明降低氢氧化铝粒径，有利于勃姆石的制备。根据XRD图谱显示，低温煅烧后，样品的主要物相为勃姆石，此外还含有少量的三水铝石，粒径越细，煅烧后样品中勃姆石含量越高。

关键词: 氢氧化铝, 勃姆石, 相变动力学, 粒度

CLC Number:

TQ026.9

Weidong FAN,Wangxing LI,Dongzhan HAN,Chunhui ZHENG. Influence of particle size on kinetics of low temperature phase transformation of aluminum hydroxide[J]. Chemical Industry and Engineering Progress, 2020, 39(3): 1101-1107.

范伟东,李旺兴,韩东战,郑纯辉. 粒度对氢氧化铝低温相变动力学的影响[J]. 化工进展, 2020, 39(3): 1101-1107.

Figures/Tables 18

References 27

1	李旺兴.氧化铝生产理论与工艺[M].长沙:中南大学出版社,2010:176-180.
	LI Wangxing．Theory and technics of alumina production [M].Changsha:Centrol South University Press,2010:176-180
2	李广慈,柳云骐,刘迪,等.不同形貌纳米薄水铝石的水/溶剂热合成及其催化应用[J].化工进展,2010,29(7):1215-1222.
	LI Guangci,LIU Yunqi,LIU Di,et al.Hydrothermal/solvothermal synthesis and potential catalytic application of nanoscale boehmite with different morphologies[J].Chemical Industry and Engineering Progress,2010,29(7):1215-1222.
3	吴彩虹,郑国源,王吉林,等.高分散纳米薄水铝石和纳米氧化铝的制备及其对甲基橙的吸附性能[J].无机化学学报,2019,36(3):449-458.
	WU Caihong,ZHENG Guoyuan,WANG Jilin,et al.Preparation and adsorption properties for melthyl orange of high dispersed boehmite and alumina nanostrctures[J].Chinese Journal of Inorganic Chemistry,2019,36(3):449-458.
4	李学礼,蔡进军,谭争国,等.活性氧化铝及其前驱体的性质及应用[J].石化技术与应用,2015,33(3):276-281.
	LI Xueli,CAI Jinjun,TAN Zhengguo,et al.Property and application of activated alumina and its precursor[J].Petrochemical Technology & Application,2015,33(3):276-281.
5	LIU Q,WANG A Q,WANG X H,et al.Characterization and catalytic applications of mesoporous γ-alumina from boehmite sol[J].Microporous Meterials,2008,111(4):323-333.
6	权婷婷,郭小蕊,谢天翼,等.捆束状分级结构γ-AlOOH的无模板水热制备及吸附性能研究[J].陶瓷学报,2017,38(3):398-403.
	QUAN Tingting,GUO Xiaorui,XIE Tianyi,et al.Synthesis of bundle-like hierarchical γ-AlOOHvia template-flee hydrothermal method and its adsorption[J].Journal of Ceramics,2017,38(3):398-403.
7	纪惟惟,王智杰,马敬红,等.勃姆石改性氧化铝膜对刚果红染料吸附的研究[J].膜科学与技术,2015,35(6):57-62.
	JI Weiwei,WANG Zhijie,MA Jinghong,et al.Investigation of alumina membrane modified with boehmite for Congo red dye adsorption[J].Membrane Science and Technology,2015,35(6):57-62.
8	HYUCK H,RICHARAD J R.Formation of CoAl layered double hydroxide on the boehmite surface and its role in tungstete sorption[J].Journal of Environmental Sciences,2018,65(3):103-115.
9	STELLA G,FLORIAN H,ANJA M S,et al.Impact of crystalline and amorphous iron and alumina hydroxide on mechanisms of phosphate adsorption and desorption[J].Journal of Environmental Sciences,2018,70(8):178-192.
10	安亚强,张汉鸿,吴春丹,等.低水分勃姆石涂层隔膜研究进展[J].广东化工,2019,46(2):105-107.
	AN Yaqiang,ZHANG Hanhong,WU Chundan,et al.Research progress of low moisture bomsite coating separators[J].Guangdong Chemical Industry,2019,46(2):105-107.
11	柳彦梅,张存良,海士坤,等.勃姆石阻燃和增强聚碳酸亚丙酯复合材料的制备和表征[J].塑料科技,2018,46(9):73-77.
	LIU Yanmei,ZHANG Cunliang,Shikun HAI,et al.Preparation and characterization of flame retardant and reinforced PPC composites with boehmite[J].Plastics Science and Technology,2018,46(9):73-77.
12	王娜,赵莹,朱明,等.勃姆石阻燃改性PP复合材料的制备及其性能研究[J].塑料科技,2017,45(11):36-40.
	WANG Na,ZHAO Ying,ZHU Ming,et al.Study on properties of boehmite flame retardant modified PP composites and its preparation[J].Plastics Science and Technology,2017,45(11):36-40.
13	KANGHEE C,JUNGSU K,HEE T B,et al.Synthesis of CuCl/boehmite adsorbents that exhibit CO selectivity in CO/CO₂ separation[J].Journal of Hazardous Materials,2018,344(15):857-864.
14	ARASH G,ZEINAB S,BAHMAN T.Tribromide ion supported on boehmite nanoparticles as a reusable catalyst for organic reactions[J].Comptes Rendus Chimie,2018,21(11):1011-1022.
15	王瑞,郭彦鑫.勃姆石催化浆态床甲醇脱水制二甲醚[J].工业催化,2015,23(1):54-58.
	WANG Rui,Guo Yanxin.Catalytic performance of boehmite catalysts for methanol dehydration to dim ethyl ether in slurry reactor[J].Industrial Catalysis,2015,23(1):54-58.
16	CHIVAS C,LONGUETB C,POURCHEZC J.Physical, morphological and chemical modification of Al-based nanofillers in by-products of incinerated nanocomposites and related biological outcome[J].Journal of Hazardous Materials,2019,365(3):405-412.
17	MALYALA P,LAERA D,CIANETTI S.The preparation and physico-chemical characterization of aluminum hydroxide/TLR7a, a noval vaccine adjuvant comprising a small molecule adsorbed to aluminum hydroxide[J].Journal of Pharmaceutical Sciences,2018,107(6):1577-1585.
18	刘超,王晶,杨雨佳.水热处理异丙醇铝及其煅烧产物的显微结构[J].硅酸盐学报,2014,42(12):1554-1559.
	LIU Chao,WANG Jing,YANG Yujia.Microstructure of productsvia hydrothermol treatment and calcination of aluminum isopropoxide[J].Journal of the Chinese Ceramic Society,2014,42(12):1554-1559.
19	熊敏,肖汉宇.制备工艺对Al₂O₃纳滤膜的结构及结构性能的影响[J].硅酸盐学报,2018,46(12):1733-1741.
	XIONG Min,XIAO Hanyu.Effect of preparation process on structure and perpeability of Al₂O₃ nanofiltration membrane[J].Journal of the Chinese Ceramic Society,2018,46(12):1733-1741.
20	黄静,夏举佩,罗中秋.碳酸钠沉淀法制备氢氧化铝及其形成机理讨论[J].化工进展,2017,36(3):1120-1125.
	HUANG Jing,XIA Jupei,LUO Zhongqiu.Preparation and growth mechanism of aluminum hydroxide by precipitation method with sodium carbonate[J].Chemical Industry and Engineer Progress,2017,36(3):1120-1125.
21	李长刚,赵萍,王维勋,等.微乳/水热法制备勃姆石[J].齐鲁工业大学学报（自然科学版）,2017,31(5):13-16.
	LI Changgang,ZHAO Ping,WANG Weixun,et al.Preparation of boehmite by microemulsion/hydrothermal method[J].Journal of Shandong Polytechnic University,2017,31(5):13-16.
22	彭志宏,李琼芳,周秋生.氢氧化铝脱水过程的动力学研究[J].轻金属,2010(5):16-18.
	PENG Zhihong,LI Qiongfang,ZHOU Qiusheng.Studies on dehydration kinetics of aluminum hydroxide[J].Light Metals,2010(5):16-18.
23	龚念.特殊形貌氢氧化铝煅烧过程的微观形貌演变及动力学分析[D].大连:大连交通大学,2013.
	GONG Nian.Microsopic morphology evolution and dynamics analysis of the special morphology of aluminum hydroxide during calcination process[D].Dalian:Dalian Jiaotong University,2013.
24	关昕,王晶,史忠祥.水热法制备薄水铝石粉体及其脱水动力学分析[J].大连交通大学学报,2018,39(4):77-82.
	GUAN Xin,WANG Jing,SHI Zhongxiang.Preparation and kinetics of dehydration of boehmite by hydrothermal treatment[J].Journal of Dalian Jiaotong University,2018,39(4):77-82.
25	KISSINGER H E.Reaction kinetics in differential thermal analysis[J].Analytical Chemistry,1957,29(11):1702-1706.
26	OZAWA T.Kinetics of non-isothermal crystallization[J].Polymer,1971,12(3):150-158.
27	CRANE L W.Analysis of curing kinetics in polymer conposite[J].Journal of Polymer Science,1973,11(8):533-540.

编号	化学成分/%				粒度分布/μm
编号	Na₂O	SiO₂	Fe₂O₃	灼减	D₁₀	D₅₀	D₉₀
1^#	0.44	0.009	0.006	34.90	44.63	76.14	128.24
2^#	0.42	0.007	0.006	34.80	1.10	10.62	36.968
3^#	0.34	0.007	0.004	34.86	0.63	1.07	1.81

编号	化学成分/%				粒度分布/μm
编号	Na₂O	SiO₂	Fe₂O₃	灼减	D₁₀	D₅₀	D₉₀
1^#	0.44	0.009	0.006	34.90	44.63	76.14	128.24
2^#	0.42	0.007	0.006	34.80	1.10	10.62	36.968
3^#	0.34	0.007	0.004	34.86	0.63	1.07	1.81

β/K·min^-1	1^#样品				2^#样品				3^#样品
	第一峰		第二峰		第一峰		第二峰		3^#样品
	T_p/K	ω_1/2/K	T_p/K	ω_1/2/K	T_p/K	ω_1/2/K	T_p/K	ω_1/2/K	T_p/K	ω_1/2/K
5	497.7	29.3	569.0	33.1	499.3	23.3	568.4	46.8	560.6	47.7
10	504.3	29.6	581.0	42.0	511.1	23.5	581.1	48.0	572.6	48.9
15	512.1	29.8	586.0	42.5	515.0	23.6	586.7	48.7	578.5	49.1
20	516.9	29.6	591.0	44.2	517.9	24.0	592.5	49.9	586.4	49.8
25	523.0	30.3	593.6	47.0	518.9	24.2	594.8	51.1	589.4	50.1
30	524.9	29.9	594.6	49.4	523.1	24.6	597.1	52.3	590.0	50.7

β/K·min^-1	1^#样品				2^#样品				3^#样品
	第一峰		第二峰		第一峰		第二峰		3^#样品
	T_p/K	ω_1/2/K	T_p/K	ω_1/2/K	T_p/K	ω_1/2/K	T_p/K	ω_1/2/K	T_p/K	ω_1/2/K
5	497.7	29.3	569.0	33.1	499.3	23.3	568.4	46.8	560.6	47.7
10	504.3	29.6	581.0	42.0	511.1	23.5	581.1	48.0	572.6	48.9
15	512.1	29.8	586.0	42.5	515.0	23.6	586.7	48.7	578.5	49.1
20	516.9	29.6	591.0	44.2	517.9	24.0	592.5	49.9	586.4	49.8
25	523.0	30.3	593.6	47.0	518.9	24.2	594.8	51.1	589.4	50.1
30	524.9	29.9	594.6	49.4	523.1	24.6	597.1	52.3	590.0	50.7

样品	活化能E/kJ·mol^-1
样品	Kissinger方程	Ozawa方程
1^#样品第一峰	125.24	127.13
1^#样品第二峰	181.17	181.41
2^#样品第一峰	161.38	161.47
2^#样品第二峰	164.13	165.24
3^#样品	148.41	150.17