Comparison and analysis of heat-power decoupling technologies for CHP units

doi:10.16085/j.issn.1000-6613.2021-1626

Abstract

Abstract:

Increasing the flexibility of combined heat and power (CHP) unit operation can improve the utilization rate of renewable energy and reduce the "abandoned wind energy" and "abandoned solar energy". However, there have been few comparison and analysis studies of the flexible modification techniques. In this paper, Ebsilon software was used to establish thermodynamic model of a 600MW unit, and an associated energy consumption model was established by passing simulation results to a Matlab routine. The influence of heat-power decoupling technologies, such as heat pump, electric boiler, heat storage tank, and steam turbine retrofit technologies on the operation feasible region and thermodynamic performance within the operation feasible region was analyzed using thermodynamic and energy consumption models. The results showed that the heat-power decoupling technologies can expand the operation feasible region of the unit. When heat load of the unit was 500MW, minimum peaking capability of the unit can be ranked from the largest to the smallest after using the heat-power decoupling technologies: electric boiler>bladeless shaft operation of low pressure cylinder>low pressure cylinder near zero output>compression heat pump>heat storage tank. However, energy and exergy efficiency of electric boiler were the lowest among all heat-power decoupling technologies. After analysis, it is an energy-saving decoupling way to use compression heat pump or compression heat pump coupled with heat storage tank in CHP units.

Key words: combined heat and power (CHP), heat-power decoupling technologies, decoupling ability, energy efficiency, exergy efficiency

摘要：

增加热电联产机组运行的灵活性可以提高可再生能源利用率，减小“弃风”和“弃光”率，然而对于灵活性改造技术的对比分析研究相对较少。本文基于Ebsilon建立了600MW案例机组的热力学模型，采用Matlab调用模拟数据构建了该机组的能耗模型。基于此模型对比分析了热泵、电锅炉、蓄热罐及采用汽轮机本体改造等热电解耦技术对机组供热可行域及可行域内机组热力性能的影响规律。研究结果表明，采用热电解耦技术可以扩大机组的供热可行域，当机组热负荷为500MW时，采用热电解耦技术后，机组最小调峰能力由大到小排列为：电锅炉>低压缸光轴运行>低压缸零出力>压缩式热泵>蓄热罐。但电锅炉的能量利用率与?效率在所有热电解耦技术中最低。综合对比分析，在热电联产机组中采用压缩式热泵或热泵与蓄热罐耦合运行是一种节能的热电解耦方式。

关键词: 热电联产, 热电解耦技术, 解耦能力, 能量利用率, ?效率

CLC Number:

TM621

WANG Zijie, GU Yujiong, LIU Haochen, LI Changyun. Comparison and analysis of heat-power decoupling technologies for CHP units[J]. Chemical Industry and Engineering Progress, 2022, 41(7): 3564-3572.

王子杰, 顾煜炯, 刘浩晨, 李长耘. 热电联产机组热电解耦技术对比分析[J]. 化工进展, 2022, 41(7): 3564-3572.

Figures/Tables 8

References 21

1	王卓辉. 我国弃风弃光电量再利用的分析与对策[J]. 中外能源, 2021, 26(5): 23-26.
	WANG Zhuohui. Analysis and countermeasures for reuse of wind and photovoltaic power curtailment in China[J]. Sino-Global Energy, 2021, 26(5): 23-26.
2	国家能源局. 2019年风电并网运行情况[EB/OL]. [2020-02-28]. .
	National Energy Administration. Wind power grid connected operation in 2018[EB/OL]. [2020-02-28]. .
3	叶泽, 李湘旗, 姜飞, 等. 考虑最优弃能率的风光火储联合系统分层优化经济调度[J]. 电网技术, 2021, 45(6): 2270-2280.
	YE Ze, LI Xiangqi, JIANG Fei, et al. Hierarchical optimization economic dispatching of combined wind-PV-thermal-energy storage system considering the optimal energy abandonment rate[J]. Power System Technology, 2021, 45(6): 2270-2280.
4	张冲, 胡林献, 胡佳. 热电机组比重及热负荷对风电消纳率影响的研究[J]. 电力系统保护与控制, 2013, 41(23): 120-125.
	ZHANG Chong, HU Linxian, HU Jia. Research on the impact of the proportion of thermal power generating units and heat load on the wind power accommodation rate[J]. Power System Protection and Control, 2013, 41(23): 120-125.
5	范庆伟, 兰凤春, 李文杰, 等. 热电联产机组增设储热水罐容量配置研究[J]. 热力发电, 2021, 50(3): 98-105.
	FAN Qingwei, LAN Fengchun, LI Wenjie, et al. Capacity designing for a combined heat and power plant assisted by water storage tank[J]. Thermal Power Generation, 2021, 50(3): 98-105.
6	刘媛媛, 隋军, 刘浩. 燃煤热电厂串并联耦合吸收式热泵供热系统研究[J]. 中国电机工程学报, 2016, 36(22): 6148-6155.
	LIU Yuanyuan, SUI Jun, LIU Hao. Research on heating system of serial-parallel coupling absorption heat pump for coal fired power plants[J]. Proceedings of the CSEE, 2016, 36(22): 6148-6155.
7	刘忠秋, 张国柱, 邱寅晨, 等. 热电联产机组集成热泵实现热电解耦的潜力与能耗特性分析[J]. 发电技术, 2019, 40(3): 253-257.
	LIU Zhongqiu, ZHANG Guozhu, QIU Yinchen, et al. Analyses on heat-power decoupling potential and energy consumption characteristics for CHP plant integrated with heat pump[J]. Power Generation Technology, 2019, 40(3): 253-257.
8	崔杨, 陈志, 严干贵, 等. 基于含储热热电联产机组与电锅炉的弃风消纳协调调度模型[J]. 中国电机工程学报, 2016, 36(15): 4072-4081.
	CUI Yang, CHEN Zhi, YAN Gangui, et al. Coordinated wind power accommodating dispatch model based on electric boiler and CHP with thermal energy storage[J]. Proceedings of the CSEE, 2016, 36(15): 4072-4081.
9	杨世豪, 孙小平, 田丰, 等. 热电联产中电锅炉调峰问题[J]. 沈阳航空航天大学学报, 2021, 38(1): 63-69.
	YANG Shihao, SUN Xiaoping, TIAN Feng, et al. Peak regulation of electric boiler in cogeneration[J]. Journal of Shenyang Aerospace University, 2021, 38(1): 63-69.
10	曹丽华, 丁皓轩, 葛维春, 等. 基于遗传算法的热电机组储热罐最优运行策略[J]. 中国电机工程学报, 2020, 40(11): 3574-3583.
	CAO Lihua, DING Haoxuan, GE Weichun, et al. Optimal operation strategy of heat storage tank in CHP unit based on genetic algorithm[J]. Proceedings of the CSEE, 2020, 40(11): 3574-3583.
11	王守鑫, 洪涛, 李超, 等. 基于低压转子光轴技术及蓄热技术的300MW机组灵活性改造[J]. 山东电力技术, 2020, 47(2): 77-80.
	WANG Shouxin, HONG Tao, LI Chao, et al. Flexibility transformation of a 300MW unit based on low pressure rotor smooth shaft technology and heat storage technology[J]. Shandong Electric Power, 2020, 47(2): 77-80.
12	戈志华, 张倩, 熊念, 等. 330MW供热机组低压缸近零出力热力性能分析[J]. 化工进展, 2020, 39(9): 3650-3657.
	GE Zhihua, ZHANG Qian, XIONG Nian, et al. Thermal performance analysis of 330MW heating unit with low pressure cylinder near zero output[J]. Chemical Industry and Engineering Progress, 2020, 39(9): 3650-3657.
13	陈永辉, 李志强, 蒋志庆, 等. 基于电锅炉的火电机组灵活性改造技术研究[J]. 热能动力工程, 2020, 35(1): 261-266.
	CHEN Yonghui, LI Zhiqiang, JIANG Zhiqing, et al. Research on flexible transformation technology of thermal power unit based on electric boiler[J]. Journal of Engineering for Thermal Energy and Power, 2020, 35(1): 261-266.
14	吕泉, 陈天佑, 王海霞, 等. 配置储热后热电机组调峰能力分析[J]. 电力系统自动化, 2014, 38(11): 34-41.
	Quan LYU, CHEN Tianyou, WANG Haixia, et al. Analysis on peak-load regulation ability of cogeneration unit with heat accumulator[J]. Automation of Electric Power Systems, 2014, 38(11): 34-41.
15	张宇, 张利, 王坤, 等. 热电联产机组集成吸收式热泵的热电解耦与能耗特性理论研究[J]. 汽轮机技术, 2020, 62(2): 143-146, 116.
	ZHANG Yu, ZHANG Li, WANG Kun, et al. Theoretical study on heat-electricity decoupling and energy consumption charateristics of combined heat and power plant by integrating absorption heat pump[J]. Turbine Technology, 2020, 62(2): 143-146, 116.
16	鄂志君, 张利, 杨帮宇, 等. 低压缸零出力实现热电联产机组热电解耦与节能的理论研究[J]. 汽轮机技术, 2019, 61(5): 383-386, 391.
	Zhijun E, ZHANG Li, YANG Bangyu, et al. Theoretical study on heat-electricity decoupling and energy saving of low-pressure cylinder zero output renovation of heat and power cogeneration units[J]. Turbine Technology, 2019, 61(5): 383-386, 391.
17	张猛, 刘鑫屏. 330MW亚临界供热机组低压缸零出力改造方案的经济性分析[J]. 广东电力, 2019, 32(3): 9-15.
	ZHANG Meng, LIU Xinping. Economy analysis for zero-output transform of low pressure cylinder of 300MW subcritical heating unit[J]. Guangdong Electric Power, 2019, 32(3): 9-15.
18	王建勋. 650MW超临界机组低压缸零出力技术的灵活性调峰能力及经济性分析[J]. 热能动力工程, 2021, 36(2): 18-23.
	WANG Jianxun. Analysis of flexible peak-load regulation capability and economy on the zero output technology of low-pressure cylinder for 650MW supercritical unit[J]. Journal of Engineering for Thermal Energy and Power, 2021, 36(2): 18-23.
19	郭容赫, 李壮, 王丽萍, 等. 210MW机组低压缸光轴运行经济性分析[J]. 沈阳工程学院学报(自然科学版), 2020, 16(2): 25-28.
	GUO Ronghe, LI Zhuang, WANG Liping, et al. Economic analysis of smooth shaft operation of low pressure cylinder in 210MW unit[J]. Journal of Shenyang Institute of Engineering (Natural Science), 2020, 16(2): 25-28.
20	郭容赫, 樊芮. 汽轮机低压缸光轴运行热电解耦能力分析[J]. 资源节约与环保, 2019(12): 7-8, 10.
	GUO Ronghe, FAN Rui. Analysis of thermoelectric decoupling ability of turbine low pressure cylinder with bladeless shaft[J]. Resources Economization & Environmental Protection, 2019(12): 7-8, 10.
21	ZHANG Dong, LI Jinping, Junhu NAN, et al. Thermal performance prediction and analysis on the economized vapor injection air-source heat pump in cold climate region of China[J]. Sustainable Energy Technologies and Assessments, 2016, 18: 127-133.

参数	数值
额定功率/MW	600
额定蒸汽压力/MPa	24.2
额定蒸汽温度/℃	566
额定蒸汽流量/t·h^-1	1683.91
再热蒸汽温度/℃	566
再热蒸汽压力/MPa	3.88
供热抽汽压力/MPa	1.1
排汽压力/MPa	0.0049

参数	数值
额定功率/MW	600
额定蒸汽压力/MPa	24.2
额定蒸汽温度/℃	566
额定蒸汽流量/t·h^-1	1683.91
再热蒸汽温度/℃	566
再热蒸汽压力/MPa	3.88
供热抽汽压力/MPa	1.1
排汽压力/MPa	0.0049

[1]	ZHANG Dong, LIU Pengfei, LIU Chunyang, HOU Gang, HUI Bo, AN Zhoujian. Performance analysis of solar PV/T photovoltaic energy storage direct drive CHP system [J]. Chemical Industry and Engineering Progress, 2023, 42(6): 2895-2903.
[2]	LIU Hongru, LIN Wensheng. Energy efficiency and carbon emission analysis of hydrogen transport chains based on liquid hydrogen and ammonia [J]. Chemical Industry and Engineering Progress, 2023, 42(3): 1291-1298.
[3]	GU Xubo, LIAO Chuanhua, WANG Changqing. Design optimization of supercritical water oxidation energy recovery system [J]. Chemical Industry and Engineering Progress, 2022, 41(9): 5094-5102.
[4]	ZHANG Zhenyang, MIAO Cong, WANG Feng, LAN Yuqi, AN Gang, YANG Shenyin. Analysis of present status and future technical route on large-scale hydrogen liquefaction plant [J]. Chemical Industry and Engineering Progress, 2022, 41(12): 6261-6274.
[5]	ZENG Cheng, LU Wei, MENG Shida, QIN Rishuai. Thermal-transpiration-effect-based carbon dioxide separation system for flue gas from coal-fired power plant [J]. Chemical Industry and Engineering Progress, 2022, 41(10): 5214-5220.
[6]	WANG Jianxun. Comprehensive analysis of cascade heating technology based on waste heat of thermal power units [J]. Chemical Industry and Engineering Progress, 2021, 40(S2): 149-155.
[7]	LIU Xuetao, LI Minxia, MA Yitai, YAO Liang, ZHAN Haomiao. Comparative analysis of energy efficiency and economy of CO₂ transcritical heat pump system under heating condition [J]. Chemical Industry and Engineering Progress, 2021, 40(3): 1315-1324.
[8]	Haochen LIU,Zhi GENG,Yujiong GU. Central heating supply method of large scale absorption CHP based on st-hp [J]. Chemical Industry and Engineering Progress, 2020, 39(2): 468-477.
[9]	HUANG Jinglun, WANG Huitao, GE Zhong, HAN Jingrong, ZHAO Lingling. Thermodynamic performance of dual-pressure expansion organic Rankine cycle power generation system driven by low-middle temperature waste heat [J]. Chemical Industry and Engineering Progress, 2018, 37(09): 3303-3311.
[10]	LUO Ke, LUO Chao, GONG Yulie. Thermal performance comparison of flash-binary power system [J]. Chemical Industry and Engineering Progress, 2017, 36(04): 1521-1528.
[11]	SHEN Bingjie, TAO Leren, WANG Chao, YU Zhongyang. The exergy analysis of variable frequency rolling rotor compression refrigeration system [J]. Chemical Industry and Engineering Progree, 2017, 36(02): 457-464.
[12]	LI Baojun, HE Gaohong, XIAO Wu, DAI Yan, CHEN Bo. Analysis of energy efficiency of separation technology during a refinery gas recycling process [J]. Chemical Industry and Engineering Progree, 2016, 35(10): 3072-3077.
[13]	WANG Mingtao, FANG Zheng, LIU Qiyi. Thermodynamic analysis of an organic Rankine cycle for waste heat recovery of a turbo-charged diesel engine based on working fluids of alkanes [J]. Chemical Industry and Engineering Progree, 2016, 35(09): 2721-2727.
[14]	YANG Xufei, QI Fengliang, LIU Xiulong, ZOU Jinghuang, XU Jinliang . Experiment on expander inlet superheat of organic Rankine cycle [J]. Chemical Industry and Engineering Progree, 2016, 35(07): 2007-2014.
[15]	LI Weiyi, GAO Jing, LI Zishen, ZHANG Haijia. Working fluids optimization based on economy analysis and exergy efficiency for low-temperature organic Rankine cycle [J]. Chemical Industry and Engineering Progree, 2016, 35(02): 369-375.