Review of research progress on viscosity-temperature characteristics of coal oil slurry

doi:10.16085/j.issn.1000-6613.2019-0076

Abstract

Abstract:

Coal direct liquefaction technology is one of the important technical ways to alleviate the contradiction between oil supply and demand and realize clean and efficient utilization of coal. The viscosity-temperature characterization of coal oil slurry has an important influence on its preparation, transportation, pressure, and preheating and reaction performance. This paper reviewed the research progress of the viscosity-temperature characteristics of coal oil slurry in terms of its changing rules, research methods, changing mechanism and influencing factors. During the heating process, the rheological properties of coal oil slurry were characterized by non-Newtonian fluid and shear thinning. There were four main methods for measuring viscosity under high temperature and pressure. The change mechanism of viscosity-temperature characteristics was analyzed. The change of viscosity in coal slurry preparation and heating stage was mainly caused by swelling, and in high temperature stage was mainly caused by asphaltene (especially pre-asphaltene) produced by coal pyrolysis. The effects of solvent, coal properties (coal rank, macerals and particle size distribution), shear rate, concentration of coal oil slurry, catalysts and hydrogenation pressure on the viscosity-temperature characteristics of coal oil slurry were analyzed. Finally, the research direction of viscosity-temperature characteristics of coal oil slurry in the future was pointed out, which could provide reference for the further development of coal direct liquefaction technology in China.

Key words: coal direct liquefaction, coal oil slurry, viscosity-temperature characteristics, change mechanism, influencing factors

摘要：

煤直接液化技术是缓解石油供需矛盾、实现煤炭清洁高效利用的重要技术途径之一，油煤浆的黏温特性对其配制、输送、加压、预热及反应性能具有重要影响。本文从油煤浆黏温特性的变化规律、研究方法、变化机理、影响因素等方面的研究进展进行了综述。在升温过程中，油煤浆流变特性表现为非牛顿流体，具有剪切稀化特性；高温高压下黏度测定方法主要有4种；分析黏温特性变化机理：煤浆制备和升温阶段黏度变化主要由溶胀作用导致，高温阶段主要由煤裂解产生沥青质（尤其是前沥青烯）导致；从溶剂、煤的性质（煤阶、显微组分及粒径分布）、剪切速率、油煤浆浓度、催化剂和氢分压等方面分析了油煤浆黏温特性的影响因素。最后指出了未来油煤浆黏温特性的研究方向，为我国煤直接液化技术的进一步发展提供参考。

关键词: 煤直接液化, 油煤浆, 黏温特性, 变化机理, 影响因素

CLC Number:

TQ529.1

Yanjun ZHANG,Geping SHU,Xuwen ZHANG,Shansong GAO,Hongxue WANG. Review of research progress on viscosity-temperature characteristics of coal oil slurry[J]. Chemical Industry and Engineering Progress, 2019, 38(9): 4003-4011.

张彦军,舒歌平,章序文,高山松,王洪学. 油煤浆黏温特性研究进展[J]. 化工进展, 2019, 38(9): 4003-4011.

Figures/Tables 5

References 41

1	中国石油经济技术研究院 . 2018年国内外油气行业发展报告[R]. 北京: 石油工业出版社, 2019.
	China Petroleum Economic and Technological Research Institute . Development report of oil and gas industry at home and abroad 2018[R]. Beijing: Petroleum Industry Press, 2019.
2	张玉卓 . 神华现代煤制油化工工程建设与运营实践[J]. 煤炭学报, 2011, 36(2): 179-184.
	ZHANG Y Z . Construction and operation of Shenhua’s modern coal-to-oil-and-chemicals demonstration projects[J]. Journal of China Coal Science, 2011, 36 (2): 179-184.
3	舒歌平 . 煤炭液化技术[M]. 北京: 煤炭工业出版社, 2003.
	SHU G P . Coal liquefaction technology[M]. Beijing: Coal Industry Press, 2003.
4	吴秀章 . 煤炭直接液化工艺与工程[M]. 北京: 科学出版社, 2015.
	WU X Z . Coal direct liquefaction technology and engineering[M]. Beijing: Science Press, 2015.
5	OKUTANI T , YOKOYAMA S , MAEKAWA Y . Viscosity changes in coal paste during hydrogenation[J]. Fuel, 1984, 63(2):164-168.
6	COHEN A , RICHON D . Rheological properties of coal powder + solvent + nitrogen to 653 K for two different coals[J]. Fuel, 1986, 65(1):117-121.
7	SAKAKI T , SHIBATA M , HIROSUE H . Effect of coal rank on rheological behavior of coal-solvent slurries during heating[J]. Energy & Fuels, 1995, 9(2):182.
8	DENG C R , NIO T, SANADA Y , et al . Relationship between swelling of coal particles and apparent viscosity of slurry during coal liquefaction for Akabira coal/creosote oil slurry system[J]. Fuel, 1989, 68(9): 1134-1139.
9	高晋生, 张德祥 . 煤液化技术[M]. 北京: 化学工业出版社, 2005.
	GAO J S , ZHANG D X . Coal liquefaction technology[M]. Beijing: Chemical Industry Press, 2005.
10	高晋生, 常鸿雁, 张德祥 . 煤直接液化中煤浆黏度变化研究进展[J]. 煤炭转化, 2003, 26(3): 23-28.
	GAO J S , CHANG H Y , ZHANG D X . Research progress on viscosity change of coal slurry during coal liquefaction[J]. Coal Conversion, 2003, 26 (3): 23-28.
11	WANG Y G , HAO L F , XIONG C A . Effects of main parameters on rheological properties of oil-coal slurry[J]. International Journal of Mining Science and Technology, 2006, 16(3): 274-277.
12	王永刚, 郝丽芳, 熊楚安,等 . 常压升温下油煤浆表观黏度变化的研究[J]. 燃料化学学报, 2007, 35(5): 513-517.
	WANG Y G , HAO L F , XIONG C A , et al . Apparent viscosity changes of oil-coal slurry during heating at atmospheric[J]. Journal of Fuel Chemistry and Technology, 2007, 35(5): 513-517.
13	WANG Y G , YAN Y , GUO X K , et al . Rheological behavior of Shengli coal-solvent slurry at low-temperatures and atmospheric pressure[J]. Mining Science & Technology, 2009, 19(6): 779-783.
14	REDDY G V , MOHAPATRA S K , SINHA R K . Rheological properties of coal oil mixtures: influence of coal properties[J]. Liquid Fuels Technology, 1994, 12(9): 1257-1270.
15	熊楚安, 王永刚, 陈伟,等 . 胜利煤液化油煤浆表观黏度的影响因素研究[J]. 燃料化学学报, 2009, 37(2): 145-149.
	XIONG C A , WANG Y G , CHEN W , et al . Influencing factors for apparent viscosity changes of Shengli coal-oil slurry[J]. Journal of Fuel Chemistry and Technology, 2009, 37(2): 145-149.
16	何静, 王永炜, 王满学,等 . 油煤浆流变特性研究[J]. 洁净煤技术, 2016, 22(2): 59-63.
	HE J , WANG Y W , WANG M X , et al . Rheological properties of coal oil mixture[J]. Clean Coal Technology, 2016, 22(2): 59-63.
17	熊楚安,王永刚,许德平 .中国直接液化油煤浆及液化残渣流变特性研究进展[J].化工进展,2009,28(4):597-604.
	XIONG C A , WANG Y G , XU D P . Development of rheological properties of Chinese coal-oil slurry and liquefaction residue in direct liquefaction[J]. Chemical Industry and Engineering Progress, 2009, 28(4): 597-604.
18	WU Y , GUO Z , LI K J . Measure of coal viscosities at high temperature and high pressure[C]//International Workshop on Direct Coal Liquefaction Technology. Beijing: 2008: 124-132.
19	吴艳 . 高温高压下油煤浆黏度测定方法研究[J]. 煤炭科学技术, 2014, 42(s1): 278-280.
	WU Y . Study on measuring viscosity of coal slurry at elevated temperature and high pressure[J]. Coal Science and Technology, 2014, 42(s1): 278-280.
20	史强, 张忠孝, 曹先常, 等 . 高温煤焦油黏温特性的测定与分析[J]. 煤炭学报, 2014, 39(11): 2335-2339.
	SHI Q , ZHANG Z X , CAO X C , et al . Measuring and analyzing on viscosity-temperature characteristic of high-temperature coal tar[J]. Journal of China Coal Science, 2014, 39 (11): 2335-2339.
21	郝丽芳 . 神华上湾煤油煤浆粘-温特性及流变特性研究[D]. 北京: 中国矿业大学(北京), 2006.
	HAO L F . Viscosity-temperature and rheological properties of Shenhua Shangwan kerosene-coal slurry[D]. Beijing: China University of Mining and Technology (Beijing), 2006.
22	TSUTSUMI A , YOSHIDA K . Rheological behaviour of coal-solvent slurries[J]. Fuel, 1986, 65(7): 906-909.
23	OGAWA T , MIYAZAWA K , SAKAI N . Studies on coal and slurry properties during liquefaction[C]//1987 International Conference on coal Science. 1987: 319-322.
24	XIE K C . Coal swelling[M]//Structure and reactivity of coal. Berlin, Heidelberg: Springer, 2015: 23-46.
25	NISHIOKA M . Role of solvation for coal swelling in slurry[J]. Energy & Fuels, 2002, 16(5): 1109-1115.
26	李华民 . 预处理对煤液化反应性的影响研究[D]. 北京: 中国矿业大学(北京), 2010.
	LI H M . Study on the effect of pretreatment on coal liquefaction reactivity[D]. Beijing: China University of Mining and Technology (Beijing), 2010.
27	高山松 . 显微组分及溶剂加氢对神东煤直接液化过程的影响[D]. 上海: 华东理工大学, 2016.
	GAO S S . Effects of macerals and solvent hydrogenation on direct liquefaction of Shendong coal[D]. Shanghai: East China University of Technology, 2016.
28	REN Y J , ZHANG D X , GAO J S . Viscosity variations of coal-oil slurry under high temperature and high pressure during heating process[J]. Fuel Processing Technology, 2011, 92(12): 2272-2277.
29	颜丙峰, 史士东, 李文博 . 煤直接液化条件下神华煤煤浆粘度的测定[J]. 洁净煤技术, 2008, 14(5): 24-26.
	YAN B F , SHI S D , LI W B . Determination of Shenhua coal slurry viscosity under direct coal liquefaction conditions[J]. Clean Coal Technology, 2008, 14(5): 24-26.
30	颜丙峰, 史士东, 李文博 . 高温高压下油煤浆黏度的变化及影响因素[J]. 煤炭学报, 2009, 34(10): 1379-1382.
	YAN B F , SHI S D , LI W B . The change and influence factors of viscosity of coal-oil slurry in high temperature and high pressure[J]. Journal of China Coal Science, 2009, 34(10): 1379-1382.
31	肖乃友, 张荣曾 . 黑山煤制油煤浆高温高压条件下的黏度变化[J]. 煤炭学报, 2010, 35(8): 1354-1358.
	XIAO N Y , ZHANG R Z . Viscosity changes of coal slurry from Heishan coal under high temperature and pressure[J]. Journal of China Coal Science, 2010, 35(8): 1354-1358.
32	李克健, 赵鹏, 史士东, 等 . 油煤浆中溶剂的黏度与油煤浆黏度关系的研究[J]. 洁净煤技术, 2006, 12(2): 36-38.
	LI K J , ZHAO P , SHI S D , et al . Study on the relationship between the viscosity of solvent in coal-oil slurry and the viscosity of coal-oil slurry[J]. Clean Coal Technology, 2006, 12(2): 36-38.
33	熊楚安, 王永刚, 陈伟, 等 . 胜利煤的溶胀行为及溶胀煤的特性分析[J]. 化工进展, 2009, 28(8): 1343-1354.
	XIONG C A , WANG Y G , CHEN W , et al . Swelling behavior and characteristics of Shengli coal[J]. Chemical Industry and Engineering Progress, 2009, 28 (8): 1343-1354.
34	巩恩辉, 武永爱, 于晓荣 . 一种FCC油浆与煤共处理影响因素研究[J]. 煤炭转化, 2018, 41(2): 51-56.
	GONG E H , WU Y A , YU X R . Study on influencing factors of co-treatment of FCC slurry with coal[J]. Coal Conversion, 2018, 41(2): 51-56.
35	高山松, 李克健, 李永伦, 等 . 煤焦油馏分油用作煤直接液化起始溶剂的加氢稳定研究[J]. 石油学报(石油加工), 2012, 28(4): 636-641.
	GAO S S , LI K J , LI Y L , et al . Study on the hydrotreatment of fractions from coal tar used as coal liquefaction starting solvent[J]. Acta Petrolei Sinica(Petroleum Processing Section), 2012, 28 (4): 636-641.
36	SHAN X G , SHU G P , LI K J , et al . Effect of hydrogenation of liquefied heavy oil on direct coal liquefaction[J]. Fuel, 2017, 194:291-296.
37	黄风林, 郭亚冰, 范峥 . 催化裂化(FCC)油浆作煤直接液化溶剂的研究进展[J]. 化工进展, 2014, 33(4): 866-872.
	HUANG F L , GUO Y B , FAN Z . Advances in FCC slurry oil as solvent of direct coal liquefaction[J]. Chemical Industry and Engineering Progress, 2014, 33(4): 866-872.
38	郝丽芳, 王永刚, 熊楚安 . 煤颗粒分布对油煤浆流变特性的影响[J]. 煤炭学报, 2007, 32(2): 190-193.
	HAO L F , WANG Y G , XIONG C A . Effect of particle size distribution on the rheology of oil-coal slurries[J]. Journal of China Coal Science, 2007, 32(2): 190-193.
39	郝丽芳, 王永刚, 孙秀英, 等 . 常压低温条件下油煤浆黏度变化的研究[J]. 煤炭转化, 2006, 29(2): 28-31.
	HAO L F , WANG Y G , SUN X Y , et al . Study on viscosity of oil-coal slurry at low-temperature and atmosphere[J]. Coal Conversion, 2006, 29(2): 28-31.
40	王学云, 张晓静, 陈亚飞, 等 . 催化裂化油浆用作煤油共炼溶剂的流变性研究[J]. 洁净煤技术, 2016, 22(2): 64-68.
	WANG X Y , ZHANG X J , CHEN Y F , et al . Rheological properties of FCC slurry using as coal-oil co-processing solvent[J]. Clean Coal Technology, 2016, 22(2): 64-68.
41	吴春来 . 煤炭直接液化[M]. 北京: 化学工业出版社, 2010.
	WU C L . Coal direct liquefaction[M]. Beijing: Chemical Industry Press, 2010.

[1]	XU Zhongshuo, ZHOU Panpan, WANG Yuhui, HUANG Wei, SONG Xinshan. Advances in sulfur iron ore mediated autotrophic denitrification [J]. Chemical Industry and Engineering Progress, 2023, 42(9): 4863-4871.
[2]	ZHU Zixuan, CHEN Junjiang, ZHANG Xingxing, LI Xiang, LIU Wenru, WU Peng. Research advances on novel wastewater biological nitrogen removal technology by partial denitrification coupled with Anammox [J]. Chemical Industry and Engineering Progress, 2023, 42(4): 2091-2100.
[3]	LI Guangwen, HUA Qucheng, HUANG Zuoxin, DA Zhijian. Progress on polymethacrylate as viscosity index improvers for lube oil [J]. Chemical Industry and Engineering Progress, 2023, 42(3): 1562-1571.
[4]	SU Jingzhen, ZHAN Jian. Research progress of microplastic removal from water environment by biochar [J]. Chemical Industry and Engineering Progress, 2023, 42(10): 5445-5458.
[5]	GUO Zhihan, XU Yunxiang, LI Tianhao, HUANG Zichuan, LIU Wenru, SHEN Yaoliang. Research progress on long-term stable operation of aerobic granular sludge [J]. Chemical Industry and Engineering Progress, 2022, 41(5): 2686-2697.
[6]	CHEN Shiyu, XU Zhicheng, YANG Jing, XU Hao, YAN Wei. Research progress of microbial fuel cell in wastewater treatment [J]. Chemical Industry and Engineering Progress, 2022, 41(2): 951-963.
[7]	DAI Xiaojun, CHENG Yan, WANG Xiaohan, HUANG Wenbin, WEI Qiang, ZHOU Yasong. Research progress in the synthesis of small particle-size SAPO-11 molecular sieves [J]. Chemical Industry and Engineering Progress, 2021, 40(S1): 191-203.
[8]	LIU Chang, CHEN Xu, YANG Jiang. Corrosion inhibitors and its application in CO₂corrosion [J]. Chemical Industry and Engineering Progress, 2021, 40(11): 6305-6314.
[9]	XIAO Kang, WANG Qiong. Progress in research on adsorption for abatement of indoor formaldehyde [J]. Chemical Industry and Engineering Progress, 2021, 40(10): 5747-5771.
[10]	Lijie CHENG, Ningbo GAO, Hua CHU, Cui QUAN, Liheng ZHANG, Xinggang LI. Metabolism and application of perchlorate reducing bacteria in microbial reduction of perchlorate: a review [J]. Chemical Industry and Engineering Progress, 2020, 39(S2): 251-261.
[11]	Huike YE, Qiuzhen WANG, Yaodong HE, Guangyi WANG. Research progress in DHA production by thraustochytrids [J]. Chemical Industry and Engineering Progress, 2020, 39(8): 3235-3245.
[12]	Sisi CHEN, Dianhai YANG, Weihai PANG, Bin DONG, Xiaohu DAI. Advances in research on factors affecting anaerobic conversion of proteinaceous materials in sludge and their promotion strategies [J]. Chemical Industry and Engineering Progress, 2020, 39(5): 1992-1999.
[13]	Sisi CHEN,Dianhai YANG,Weihai PANG,Bin DONG,Xiaohu DAI. Main influencing factors and mechanisms of anaerobic transformation of excess sludge in China [J]. Chemical Industry and Engineering Progress, 2020, 39(4): 1511-1520.
[14]	Fenglei HAN, Mengyu LI, Jiefu LIU, Dandan LI, Wenwen GUO, Shuo ZHOU, Chaocheng ZHAO, Dongfeng ZHAO. Method of checking and accounting for the bag method of VOCs in coal direct liquefaction unit based on BP neural network [J]. Chemical Industry and Engineering Progress, 2020, 39(10): 3949-3955.
[15]	Cong CHEN, Jianzhong LIU, Farui XU. Slurry property of coal water slurry prepared by coking wastewater [J]. Chemical Industry and Engineering Progress, 2019, 38(06): 2986-2991.